Search the record

EE WAS FITTING 6AGS ON THE THIMBLES IN #51 DUST COLLECTOR. A BAG SLIPPED CAUSING HIS THUMB TO STRIKE THE SHARP EDGE OF T HE NEXT THIMBLE.

EMPLOYEE STATES3HE WAS PULLING BUCKET BACK INTO PLACE ON POER WHEELBARROW & STRUCK FINGER ON GAS TANK OR BAC

WHILE PUTTING D9IVE CHAIN ON COOLER HE FELT SHARP PAIN IN SIDE AND CHEST.

EMP WAS INSTALL3NG A HYDRAULIC CYLINDER IN LITTLE CAT LOADER. THE CYLINDER SLIPPPED CAUSING CUT OF FINGER

EMP WAS PUTTING3A PIECE OF PLYWOOD ON DISCHARGE SLIDE. THE PLYWOOD FELL OFF THE SLIDE STRIKING HIS LEFT FOOT

EMPLOYEE WAS RE5CHING IN TO REMOVE STOCK FROM SMALL MAGAZINE STORAGE BOX. COVER LID CAME FORWARD AND STRUCK HIS HAND. WIND MAY HAVE BEEN A FACTOR.

EMPLOYEE WAS AS8ISTING ADJUSTMENT OF CLUTCH ON 10 RAW MILL. ANOTHER EMPLOYEE TURNED THE ADJUSTMENT BLOCK AND UNIT TURNED FREELY CATCHING INJURED S FINGER BETWEEN THE BLOCK AND THE ADJUSTING NU T ADJUSTMENT BL2CKS ARE NORMALLY TURNED USING CHAINFALL DUE TO SIZE AND TIGHTNESS. THIS OCCASION, UNIT TURNED FREE AND WAS A SURPRISE.

EMPL ASSISTING REPAIR OF COUPLER ON BRADLEY MILL.WHEN JOB OB REMOVAL WAS OVER,HYDRAULIC JACK WAS PLACED NEARBY ON UNUSED MILL FOUNDATION ON ITS SIDE.THE JACK ROLLED OFF AND STRUCK EMPL ON FOOT BEHIND THE STEEL TOE OF HIS SAFETY WORK BOOT.

EMPL PUTTING BOLT IN HOUSING AND BACK OF HAND NICKED EDGE OF HOUSING.

PACKING BAGS OF CEMENT.CATCHING BAG OF CEMENT AS IT FELL OFF DELIVERY CHUTE.

EMPLOYEE WAS REMOVING A EUCLID DRIVELINE WHEN THE WEIGHT OF THE DRIVELINE CAUSED IT TO PIVOT UPWARD AND CRUSH HIS FINGER AGAINST THE FRAME OF THE TRUCK. (HE WAS ATTEMPTING TO CONTROL A HEAVY O BJECT WITH MUSCLE POWER ALONE.)

PUTTING A DUST COLLECTOR BAG IN PLACE. THE CLAMP SPRING CAME OUT OF THE CLAMP HANDLE, FLEW BACK, CAUGHT RIGHT INDEX FINGERNAIL.

EMPLOYEE WAS CRAWLING UNDER THE DAMPER OF #19 KILN COOLER AND STRUCK HIS KNEE AGAINST THE DAMPER. LAST DAY WORKED WAS 4-19-85 AND SAW DOCTOR ON 4-22-85.

TIGHTENING A CAP ON #2 KILN HOOD DRAFT LINE. PHYSICAL FORCE USED WHEN PUSHING ON CAP ROD LATER CAUSED PAIN IN LEFT HAND AND SWELLING OF LEFT WRIST.

EMPLOYEE WAS INSIDE THE RUBBER-TIRE DOZER AND ATTEMPTED TO CLOSE THE DOOR. DOOR CLOSED AND CAUGHT HIS THUMB BETWEEN THE DOOR AND THE FRAME.

PULLING CHAIN BLOCK ON OVERHEAD TROLLEY THROUGH STORE ROOM. CHAIN CAUGHT A PIECE OF 1/4"X4"X10\ LONG PIECE OF STAINLESS STEEL WHICH WAS IMPROPERLY PLACED ON TOP OF STORAGE BIN, CAUSING TI TO F ALL AND TO STRIKE INJURED\S NOSE.

BAG OF CEMENT BURST IN INJURED\XS FACE.

HELPING TO INSTALL NEW LINERS ON INSPECTION DOOR. INJURED WAS HOLDING LINERS IN PLACE, WITH BOTH ELBOWS RESTING FOR SUPPORT ON A STEEL BENCH. A CO-WORKER BOLTED THE LINERS IN PLACE. THE SAM E EVENING, IMJURED EMPLOYEE FELT PAIN AND SWELLING IN LEFT ELBOW.

EMPLOYEE WAS REMOVING A USED GASKET FROM AN ENFINE HEAD WHEN HIS HAND SLIPPED AND WAS CUT ON A SHARP EDGE

EMPLOYEE WAS ASSISTING PLACING AN ACETYLENE CYLINDER INTO A CART RACK.OTHER EMPLOYEE LET HIS END GO.INJURED CAUGHT HIS FINGER BETWEEN THE CYLINDER AND THE CART RACK.

WORKING ON COOLER GRATES. WORKING UNDER AN OVERHEAD BUILD UP OF HOT MATERIAL, SOME OF IT FELL STRIKING INJURED AT BACK OF HIS HEAD, CAUSING BURNS TO BOTH CARS AND BACK OF HEAD.

PULLING DOWN A ROW OF OLD BRICK IN KILN #2. INJURED STATED A BRICK STRUCK HIS RIGHT WRIST.

EMPLOYEE WAS POKING CHUNKS AT A HOPPER USING A STEEL BAR ROD. HE STRUCK HIS HAND AGAINST THE IDLER ROLLER GUARD.

EMPL ASSIST. UNLOADING METAL SECTIONS FROM TRUCK.PIECE OF IRON STRUCK HIS FINGER.

ASSISTING PLACEMENT OF AN ELBOW SECTION OF AN AIR DUCT ONTO A TRANSPORTER PLATFORM. HOOK-UP WENT SLACK AND UNIT ROLLED OFFTRANSPORTER ONTO FLOOR. SECTION DID NOT STRIKE EMPLOYEE.

EMP WAS ASSISTING REPAIR OF SOOTBLOWER AT REPAIR BENCH. UNIT ROLLED OFF BENCH AND HE TRIED TO HOLD IT, OR KEEP IT FROM HITTING THE FLOOR. INJURED COULD HAVE PREVENTED THIS ACCIDENT BY BLOCKING THE UNIT OR SECURING IT WITH CHAIN OR SLING TO AN OVERHEAD EXISTING HOIST TROLLEY

EMPLOYEE WAS ATTEMPTING TO REMOVE A COMPRESSOR BLADE FROM ITS METAL DELIVERY CASE. THE BLADE STUCK IN THE CASE, AND CASE FELL ST RIKING EMPLOYEES WRIST

EMPLOYEE WAS CUTTING SOME EXPANSION JOINT FABRIC USING A UTILITY KNIFE AND STRAIGHT EDGE. THE KNIFE JUMPED THE STRAIGHT EDGE AND CUT HIS THUMB

EMPLOYEE WAS ADJUSTING CLUTCH ON KILN AUXILIARY DRIVE. CLUTCH WAS HOT. HE JERKED HIS HAND BACK AND STRUCK EDGE OF CLUTCH BELL HOUSING

EMPLOYEE WAS FILLING A MOP BUCKET WITH HOT WAT E R THROUGH A HOSE, THE HOSE BVUCKED WHEN STEAM AND HOT WATER CAME THROUGH

WHILE EMP WAS LIFTING AND ADJUSTING GRIZZLEY SECTION IN #20 COOLER IT SLIPPED OUUT OF HIS LEFT HAND, PINCHING HIS FINGER OF HIS RIGHT HAND BETWEEN THE GRIZZLEY AND THE COOLER GRATES. THE GRIZ ZLEY WAS HEAVY AND THE EMPLOYEE TRIED HANDLING IT BY HIMSELF

EMP WAS ASSISTING REMOVAL OF SCAFFOLDING LONG SUPPORT PIPES IN THE PROCESS OTHER EMPLOYEES PULLED AND INJUREDS ARM STRUCK SIDE OF KILN HOOD

EMP AND FELLOW REPAIRMAN WERE REMOVING SHEAVE V BELT FROM #2 SCREEN EMP WAS HOLDING AND GUIDING SHEAVE WHILE OTHER EMP LOSENED SHEAVE WHEN IT CAME LOOSE EMP WAS CAUGHT UNAWARE AND SHEAVE WEIGH MORE THAN HE THOUGHT HE TRIED TO CATCH IT AND PINCHED FINGER BETWEEN SHEAVE AND SCREEN FRAME

EMPLOYEE WAS REPLACING A TANK OF PROPANE GAS ON HIS LIFT TRUCK. WHILE IN THE PROCESS HE CAUGHT HIS RIGHT INDEX FINGER BETWEEN THE LIFT TRUCK BODY AND THE GAS TANK.

EE WAS REMOVING JOB CARD FROM PULLEY OF A FAN CASING WHICH WAS IN FOR SHOP REPAIR. HE PULLED THE BELT TO LOOSEN THE CARD & THE MOMENTUM CARRIED HIS HAND INTO OPPOSITE PULLEY.

EMPLOYEE WAS LIFTING WEIGHING AND REPLACING FIRE EXTINGUISHERS THROUGHTOUT THE PLANT AREA

EMPLOYEE WAS TRANSFERRING BAGS OF CEMENT FROM A CONVEYOR TO A PALLET. HE FELT PAIN IN HIS LEFT TESTICULAR AREA.

EMPLOYEE WAS REMOVING CLEANING AND RETURNING WATER COOLER TOWER LOUVRES A LOUVRE BROKE AND PIECE OF IT STRUCK THE RIGHT WRIST OF THE INJURED EMPLOYEE

EMPLOYEE CLAIMS WHILE REPLACING LIFTERS AND LINERS IN #1 MILL THE LINER SLIPPED PINCHING HIS FINGER

EMPLOYEE WAS CHANGING DRILL BITS AND THOUGHT THREAD ON NEW BIT WAS STARTED AS HE REACHED FOR A TOOL BIT FELL OUT AND STURCK HIS FINGER

REACHING UP TO CLOSE TIPPLER VALVE ON BOILER HOPPER HOT DUST FLUSHED AND WENT UP ARM UNDER COAT SLEEVE.

EMP STATES HE WAS HOOKING THE CAR PULLER HOOK TO RAILROAD CAR

ANOTHER EMP SLID A WOODEN CHOCK USED FOR SECURINNG A COMPRESSED GAS BOTTLE ACROSS THE BED OF PICKUP TRUCK CHOCK STRUCK FINGER