Mission Viejo Materials Incorporated Metal/Non-Metal

ON 6/17/93, EMPLOYEE WAS EXITING FROM 988B CAT LOADER, STEPPED ON SMALL ROCK AND TWISTED ANKLE. SAL THOUGHT IT WOULD BE ALRIGHT, SO THEREFORE HE DIDN'T REPORT INJURY. ON 2/23/93, SAL WAS RUS HING OVER TO TURN ON THE JAW CRUSHER, WHEN HE FELT HIS ANKLE WEAKEN, CAUSING EXTREME PAIN. REPORTED INJURY TO OFFICE ON 6/23/93. SENT FOR MEDICAL ATTENTION.

I.NAME WORKING UNDER SHAKER SCREEN ABOVE #4 GRAVEL CHUTE INSTALLING RUBBER WIPERS WHEN THE HAMMER SLIPPED CAUSING EMPL TO HIT LEFT LEG.REPORTED TO OFFICE AND SEEKED MEDICAL ATTENTION 7-6-92.

A ROCK FELL OFF OF SCREEN STRIKING A SHOVEL, CAUSING THE HANDLE TO HIT INJURED ON THE JAW. EMPLOYEE WAS REMOVING SCRAP WOOD FROMT HE NORTH SIDE OF LOG WASHER AT TIME OF ACCIDENT.

HE WAS SWINGING A 10 LB SLEDGEHAMMER, TIGHTENING THE STANDARD CONE, WHEN HE FELT A PULL IN HIS BACK. OVER THE COURSE OF THE MORNING, PAIN BECAME PROGRESSIVELY WORSE.

EE WAS CLEANING FLOORS OF PLANT. TWO MEN WERE WORKING ABOVE WITH LARGE RUBBER STRIPS. ONE STIP DROPPED, FALLING 80', HITTING HIM ON RIGHT SHOULDER & LEG.

EMPLOYEE WAS EXITING FROM THE CAB OF THE WELDING TRUCK & SLIPPED ON THE RUNNING BOARD HITTING HIS REAR & BACK & ENDING UP ON THE GROUND HEAVY DEW ON THE GROUND THAT EVENING

CONDITIONS WERE NORMAL.THE EMPLOYEE WAS EXITING FROM THE D-9 DOZER WHEN HE TWISTED AND SRPAINED HIS LEFT ANKLE.

REMOVING LEAF SPRING IT FELL ON FOOT

EE WAS LOOSING THE NUTS ON THE CRUSHER WITH A SLEDGE HAMMER, WHICH CAUSED A PULL IN HIS BACK.

RAZOR KNIFE I.NAME USING TO OPEN BUCKETS OF NORBACK SLIPPED CUTTING RIGHT THIGH.STITCHES REQ TO CLOSE THE WOUND.

EMPLOYEE WAS CLIMBING UP LADDER ON CAT 966 LOADER IN ORDER TO STOCK-PILE SAND, WHEN HE BUMPED HIS LEFT KNEE ON TOP OF LADDER.

MEDICAL CLINIC REFERRED EMPLOYEE TO OPHTHALMOGOLIST RUST RING HAD FORMED ON EYE WHICH REQUIRED EYE TO BE SANDED BY DR

I.NAME WAS PULLING ROCKS OUT OF JAW CRUSHER WHEN HE FELT A PAIN IN HIS BACK. HE FINISHED HIS SHIFT. ON THE FOLLOWING DAY, HE WORKED MOST OF HIS SHIFT, BUT CAME TO OFFICE TO REPORT INJURY AND S EEK MEDICAL ATTENTION, DATE BEING 9-18-90. EXAM, PHYSICAL THERAPY, PRESCRIPTION GIVEN.

INJURED WAS ASSISTING MECHANIC WITH FIXING TOOTH ON BUCKET OF 922B CAT LOADER.WHILE MECHANIC WAS HITTING BAR WITH SLEDGE HAMMER WHICH INJURED WAS HOLDING IN PLACE,A PIECE OF SMALL METAL FLEW O FF AND HIT INJURED IN NECK.

I.NAME WAS HOLDING BOLT ON SYMONS CRUSHER WITH LARGE WRENCH WHILE ANOTHER EMPLOYEE WAS POUNDING BOLT IN PLACE WITH SLEDGE HAMMER. THE HAMMER MISSED THE BOLT, HIT THE LEG OF CRUSHER, WHICH CAUS ED IT TO RICOCHET HITTING ISDRO'S LITTLE FINGER.

WHILE OPERATING D8 DOZER OUT IN PIT SMALL METAL FRAGMENT FLEW OFF EXHAUST PIPE INTO EMPL'S EYE.

IT WAS A COMBINATION OF OPERATING THE 988 CAT LOADER AND HOT WEATHER CONDITIONS,CAUSING DIZZINESS,HEADACHE, AND BACK PAIN.THESE CIRCUMSTANCES CAUSED EMPLOYEE NOT TO BE ABLE TO WORK ANY LONGER, AND SEEK MEDICAL AID.NOTE CLINIC ADMINISTERED PAIN MEDICATION AND PHYSICAL THERAPY.

EMPLOYEE WAS SHOVELING SAND FROM UNDERNEATH THE SAND CONVEYOR IN ORDER TO MOVE IT TO A DIFFERENT LOCATION, WHEN HE EXPIERENCED A SHARP PAIN IN HIS BACK. NOTE: DR. ORDERED PHYSICAL TERAPY, PA IN MEDICATION ADN BACK BRACE.

EMPL WAS WALKING ALONG BAK OF POND CHECKING WATER LEVEL WHEN BANK GAVE WAY. WHILE TRYING TO PULL SELF OUT OF MUD EMPL FELT SOMETHING PULL IN BACK. HE THOUGHT AT TIME PROBLEM WOULD WOURK ITS WA Y OUT BUT NEW SHOCKS ON PICKUP TRUCK ONLY AGGAVATED PROBLEM THOUOUT WEEK. REPORTED TO DR 4/16/90.

EMPLOYEE WAS DRIVING EUCLID BOTTOM DUMP WHEN MAKING A TURN THE FRONT WHEELS HIT SOME LARGE ROCKS CAUSING STEERING WHEEL TO SPIN SWIFTLY PUSHING HIS ARM AWAY FROM WHEEL CAUSING SHARP PAIN TO RT SHOULDER IN MEDICATION ADMINISTRATED GIVEN 3 DAYS OFF

EE WAS CLEANING OFF GASKETS FROM ATOYOTA ENGINE, WHEN LOCK OUT ON KNIFE FAILED, CAUSING KNIFE TO FOLD, CUTTING TOP OF MIDDLE FINGER.

ROLLING UP HOSE, STEPPED ON SOE BOARDS IN FLOODED AREA WHICH COVERING 5' HOLE WHEN BOARDS SLIPPED AWAY CAUSING HIM TO FALL IN HOLE

EMPL WAS CUTTING PIECE OF RUBBER BELTING WHEN KNIFE SLIPPED & CUT HIM IN LEG.

EMPLOYEE WAS CLIMBING ON BOBCAT, WHEN HIS FOOT SLIPPED HITTING GEARS, WHICH CAUSED THE BUCKET TO TILT AND PINCH TOES ON HIS LEFT FOOT. DR. REPORT: BRUISED AND PINCHED TOES, WITH POSSIBLE BROKE N SMALL TOE. PRESCRIPTION MEDICATION ADMINISTERED.

EMPLOYEE WAS DIE GRINDING A BOLT HOLE OUT OF THE DOZER, WHEN A SMALL METAL FRAGMENT FLEW IN HIS EYE. HE WAS WEARING SAFTEY GLASSES.

PIT TRUCK DRIVER WAS DECENDING DOWN HILL WITH LOADED TRUCK OF MATERIAL AS WAS ASCENDING UP THE HILL TO WATER ROAD. CONSEQUENTLY, THE TWO TRUCKS WERE INVOLVED IN A HEAD ON COLLISION. HE REFUS ED TO SEE DR. AT TIME OF ACCIDENT. GIVEN THE REST OF THE DAY OFF. REPORTED TO DR. MORNING 11-10-89.

EMPLOYEE WAS DESCENDING DOWN THE STAIRS TO THE 1ST PLATFORM OF PLANT WHEN A PIECE OF 6" STEEL UNISTRUT DROPPED FROM ABOVE, HITTING I.NAME ON HEAD. 2 STITCHES REQUIRED.

EMPLOYEE STRAINED THE MUSCLES AROUND HIS KNEE WHILE WALKING UP AND DOWN THE STAIRS AT THE PLANT,AND WHILE CLIMBING DOWN THE CONVEYOR TO WELD TAIL PULLEY TO MOUNT.

INJURED WAS PULLING ON A ROPE TO HELP STABLIZE A CONVEYOR BELT, WHEN A MATERIAL DEBRIS OF DIRT AND ROCK SPILLED FROM THE BELT. A VERY SMALL PARTICLE OF ROCK HIT EMPLOYEE IN LEFT EYE. NOTE - EMPLOYEE DID NOT REPORT INJURY TO OFFICE UNTIL 10-24-89.

HE WAS PUSHING UP MATERIAL ON SRUGE PILE, WHEN HIS LEFT EYE BECAME EXTERMELY IRRATATED CAUSING GREAT DISCOMFORT. HE WAS OPERATING THE CATDOZER AT THE TIME.

EE WAS LIFTING CAB OF BOOM TRUCK WITH LEFT ARM AND LOCKING IT IN PLACE WITH RIGHT HAND. WHEN HE WENT TO STRAIGHTEN UP HE FELT PAIN UNDER LEFT SHOULDER BLADE.

I NAME WAS REPAIRING & CLEANING CRACKS ON 992B LOADER WITH PORTABLE HAND GRINDER WHEN TOOL REARED BACK HITTING I NAME IN CHIN GRINDER CAUSED LACERATION WHICH REQUIRED STITCHES I NAME ATTRIBUTE D ACCIDENT BY WORKING IN TIGHT QUARTERS I NAME WAS OFF ON 091889 DUE TO PERSONAL REASONS

AFTER PULLING ON BREAKER BAR AND LIFTING CAB OF LUB TRUCK INJURED WENT TO STEP UP TO GET INSIDE OF CAB TO START TRUCK WHEN HE FELT EXCRUCIATING PAIN IN HIS BACK. EMPLOYEE UNDERGOING PHYSICAL THERAPY TREATMENBTS. 2 DR. OPINIONS. DR. 000 2 WEEKS LIGHT DUTY, DR. XXX 3 DAYS OFF.

I NAME CLAIMS THAT HE SLIPPED AND FELL 5' FLAT ON HIS BACK WHIILE TIGHTNING #1743 SCREEN 2ND DECK OF PLANT ACCIDENT WAS NOT KNOWN OR REPORTED BY I NAME UNTIL 8/21/89 2 PRESCRIPTION DRUGS ADMIN STERED BY CLINIC

EMPL WAS INSIDE THE CHUTE EXPLAINING HOW TO DO A JOB WHEN ANOTHER EMPL STRUCK AN ARCH CAUSING A FLASH BURN THE OTHER EMPLS ALL HAD WELDING HOODS ON

EMPLOYEE WAS GREASING THE JAW CRUSHER WHEN A ROCK FLIPPED OUT AND STRUCK HIM ON THE NOSE RESULTING IN A NOSEHBLEED.

EMPLOYEE WAS DESCENDING FROM THE WATER TRUCK WHEN HE SLIPPED ON THE STEP HIS LEFT KNEE HIT THE FUEL TANK

EMPLOYEE WAS WELDING NEAR ANOTHER EMPLOYEE, WHEN HE REMOVED HIS WELDING HOOD. HE WAS ALSO USING A LENS THAT WAS NOT DARK ENOGH.

EMPLOYEE WAS TURNING A WRENCH WHILE WORKING ON LOADER, WHEN HIS EYE STARTED TO HURT. HE IMMEDIATELY STOPPED AND CHECKED HIS EYE OUT. THERE WAS SMALL FRAGMENT LODGED IN HIS LEFT EYE.

WHILE ASSISTING THE HEAD MECHANIC WITH REPAIR OF DOZER I,NAME WALKED DOWN BETWEEN THE DOZER AND THE SERVICE TRUCK TO TURN OFF THE COMPRESSOR WHEN HE BUMPED HIS HEAD INTO THE CORNER OF AN OPEN DOOR ON SERVICE TRUCK.

WHILE CUTTING I BEAM LOOSE FROM STRUCTURE I NAME STOPPED AND BENT DOWN TO CHECK IT WHEN PART OF BEAM UNEXPECTELY BROKE LOOSE STRIKING I NAME IN HEAD

WHILE CLIMBING UPON A LARGE ENDDUMP TRUCK EMPLOYEE SLIPPED FALLING TO THE GROUND FROM A HEIGHT OF K5FT INJURING HIS LEFT HIP

WHILE GRINDING ON A PIECE OF METAL A BURR LODGED IN EMPLOYEE'S HAND, IN THE PALM AREA. EMPLOYEE DID NOT NOTIFY COMPANY OF THIS INJURY UNTIL 2-24-89.

EMPLOYEE WAS REMOVING A ROCK FROM BETWEEN THE DUEL TRIES OF THE BOTTOM DUMP TRUCK. HE WAS USING A HAMMER TO TRY AND KNOCK THE ROCK LOOSE FROM THE TIRES. WHEN THE ROCK WAS DISLODGED IT HIT TH E OPERATOR ON THE FOOT.

WHILE WALKING UP THE STAIRS TO THE CONTROL ROOM OF THE CRUSHING P LANT THE EMPLOYEE SLIPPED ON THE STEPS OF THE STAIRWAY

EMPLOYEE WAS WA5KING DOWN STEPS STEPS WERE WET EMPLOYEE SLIPPED & TWISTED KNEE

WORKERS HAD REM2VED PART OF THE DECKING TO REPLACE IT AND I,NAME WALKED INTO THE HOLE AND BRUISED AND STRAINED HIS RIGHT LEG.

EMPLOYE DROVE A3TRUCK OFFA 75 FT. CLIFF-APPARENTLY ON PURPOSE-SEE ATTACHED POLICE REPORT.

EMPLOYEE WAS WE5DING ON BUCKET AND USING GRINDER WHEN HE LIFTED HIS WELING HOOD AND A PIECE OF WIRE BRUSH FLEW INTI HIS EYE;ALSO THE WELD POPPED CAUSING SLAG TO ENTER SAME EYE.

EMPLOYEE WAS GR9ASING TAIL PULLEY AND TURNED AROUND AND HIT KNEE ON LADDER.

CONTINUOUS PULL3NG ON STEERING WHEEL WITHOUT POWER STEERING & TURNING NECK IN OPPOSITE DIRECTION DISPLACEMENT OF CERVICAL DISC & RADICULAR NEURALGIA & COMPRESSION OF SPINAL NE RVE ROOT & SEGM9NTAL DYSFUNCTION.

EMPLOYEE APPARE3TLY PASSED OUT AND FELL OVER GUARD RAIL

HE WAS GRINDING3A PIECE OF STWL ON A LOADER WHN%*@%* WHEN A FRAGMENT OF STEEL FLEW UP INTO HIS RIGHT EYE. HE WAS WEARING GOGGLES AT THE TIME OF THE ACCIDENT.

EMPLOYEE WAS ATTEMPTING TO ASSIST THE DRIVE OF A TRUCK FROM KING BEARING COMPANY WITH THE UNLOADING OF A TROUGHING ROLLER. THE DRIVER WAS IN A HURRY AND WAS INPATIENT. HE PUSHED THE ROLLER TOW ARD I,NAME BEFORE I,NAME WAS READY, CAUSING I,NAME TO CATCH HIS THUMB BETWEEN THE ROLLER ANDTHE SIDE OF THE TRUCK, CAUSING SPRAIN, BRUISE AND LOCERATION TO RIGHT THUMB.

I,NAME ALONG WITH TWO OTHER EMPLOYEES, WAS STANDING ON TOP OF THE SAND LINE BELT WHILE LIFTING AN ELECTRIC MOTOR IN PLACE. WHILE DOING THE LIFTING, HE FELT A PULL IN HIS LEFT UPPER ARM.

EMPLOYEE WAS DRIVING THE SPARE BUNKER TRUCK. AS HE WAS GETTING OUT OF THE CAB OF THE TRUCK, HE MISSED THE STEP AND TO AVOID FALLING TO THE GROUND, HE HELD ON THE HANDRAILS.

EMPLOYEE WAS STANDING ON BACK OF WELDING TRUCK WITH ARMS EXTENDED OVERHEAD, TRYING TO ADJUST CATWALK ON 841 DRAGLINE SO THAT HE COULD WELD IT IN PLACE CAUSING LOWER BACK STRAIN.

WHEN EMPLOYEE WAS MOVING DRAG CABLE TO WELDING TRUCK HE STRAINED HIS LOWER BACK

EMPLOYEE WAS USING A WIRE BRUSH TO CLEAN A PIECE OF STEEL. A PIECE OF STEEL FLEW IN HIS RIGHT EYE

EMPLOYEE WAS HELPING TWO OTHER EMPLOYEES ROLL A LARGE CONVEYOR BELT. THE BELT WAS EXCEEDINGLY HEAVY, CAUSING MR. AVALOS TO STRAIN WITH THE ACTIVITY.

EMP WAS OPERATING 814 DRAGLINE AND WAS HOLDING TRAVEL CLUTCH THE FORCE AND AKWARD POSITION REQUIRED TO OPERATE MACHINE CAUSED EMP TO PULL MUSCLE IN LOWER BACK

EMPLOYEE WAS PUNCHING HOLES IN A CONVEYOR BELT. THE GROUND THAT HE WAS WORKING ON WAS UNEVEN, CAUSING HIM TO TWIST HIS KNEE.

EMPLOYEE WAS WORKING ON CONVEYOR BELT AND AS HE WAS COMING DOWN LADDER HE STEPPED OFF LAST STEP AND STEPPED INTO SOME SOFT MATERIAL FELL AND TWISTED HIS BACK

EMP DROVE UNDER THE PLANT WITH THE BED UP ON HIS BUNKER TRUCK. THE TRUCK REARED UP ABOUT 45% ANGLE AND THE STEERING WHEEL HIT HIM ABOVE THE RIGHT EYE

EMPLOYEE WAS CHANGING SCREENS WITH ANOTHER EMPLOYEE. HE WAS BALANCING ON A BEAM BEHING THE SCREEN TRYING TO MOVE THE NEW SCREEN INTO PLACE WHEN HE LOST HIS BALANCE AND FELL BACKWARDS ABOUT EI GHT FEET TO THE GROUND.

HE WAS WORKING NEAR THE HEAD PULLY OF A CONVYEOR, BREAKING FLEXO BOLTS WITH AND FLEXO TOOL. JUST AS HE WAS SWINGING THE HAMMER, ANOTHER EMPLOYEE STEPPED ON TO THE BELT. THE BELT MOVED CAUSING CABRERA TO MISS THE TOOL AND HIT HIS HAND.

EMPLOYEE WAS DRILLING A HOLE IN CONCRETE WITH ROTO HAMMER WHILE DRILLING HOLE IN CONCRETE EMPLOYEE GOT A SMALL PIECE OF ROCK IN HIS LEFT EYE

WALKING OUT ON WATER LINE TO POND PUMP IN RIVERBED TO OPEN 2\\ WATER VALVE.AN ELEC CONTR HAD LEFT LID OPEN TO ELEC DISCONNECT BOX.EMPL DID NOT SEE OPEN LID AND RAN INTO IT.

EMPLOYEE WAS WELDING ON A BUMKER ABOUT 4 FEET OFF THE GROUND LOST HIS FOOTING AND SLIPPED LANDING ON THE BUNKER AND HITTING HIS ELBOW