MOBILE SAND COMPANY: 22 incidentes reportables Metal/Non-Metal

ROUND HEAD ON CUTTING EDGE BOLT SPUN WHEN IMPACE

EMPLOYEE SPILLED GASOLINE ON LEG 12/30/88 REOCCURING FLAIR UP

EMPLOYEE WAS LOOKING OVER CABLE DRIVE SECTION WHEN HE SLIPPED ON DRIVE SECTION CAUSING FALL. EMPLOYEE FELL HITTING STEEL ROLLER AGAINST RIBS.

REMOVING STEEL STAKES FROM WORK AREA AT NORTH END OF OFFICE OVER TO FENCE LINE. EE STEPPED ON LOOSE GRAVEL NEXT TO GENCE SLIPPED AND TWISTED LOWER BACK AND CUT ACROSS FOREHEAD FROM WIRE ON TOP OF FENCE.

MECHANIC WAS CLEANING OIL SATURATED AREA OF THE ENGINE AREA OF THE LOADER. MECHANIC TURNED AND SLIPPED AND FELL.

EMPLOYEE WAS GRINDING ABOUT A DOZEN EYE LIFT PLATES ON THE BENCH. EVERY TIME HE WOULD STOP TO CHANGE PLATES AND RECLAMP, HE WOULD START THE GRINDER WHICH WOULD THROW THE CIRCUIT BREAKER. EMPLO YEE KEPT THE GRINDER RUNNING AND SET IT ON ITS BACKSIDE WHILE RE-CLAMPING. AFTER ABOUT 10 PIECES OF PLAT, THE GRINDER SLIPPED AND CAUGHT LEFT ARM.

DRIVING THE FRONT END LOADER DOING REGULARLY ROUTINE DUTIES WHILE IN THE YARD.

LABOR WAS SHOVELING WET CONCRETE FROM POINT OF DISCHARGE FROM A READY MIX TRUCK TO A POSITION UNDER A CONVEYOR BELT LINE. WHILE BENDING UNDER THE CONVEYOR LINE, WITH A SHOVEL FULL OF WET CONCR ETE, THE LABORER STRAINED HIS BACK.

2 LABORERS WERE CHANGING SCREENS ON THE SCREEN.INJURED EMPLOYEE BENT DOWN TO PICK-UP SCREEN.WHEN RISING WEIGHT OF SCREEN WITH METHOD OF PICK-UP CAUSED STRAIN ON LOWER BACK.

HE TURNED ON FUEL TRUCK, ENGAGED POWER TAKE OFF , THEN WENT TO FUEL HIS LOADER. NO FUEL CAME OUT. HE LOOKED UNDER FUEL TRUCK TO SEE WHAT WAS WRONG. HE REACHED FOR WHAT HE THOUGHT WAS THE PROBL EM WHILE ENGINE WAS RUNNING AND P.T.O. GRABBED HIS CLOTHING AND PULLED HIM IN.

ROCK ROLLED DOWN SURGE FEED PILE & OVER END OF TUNNEL TO FEED BELT STRICKING EMPL ON LOWER BACK. HE REPORTED TO ME ON 3/5 HE SAID HE DID NOT WANT REPORT FILLED OUT BECAUSE HIS BACK DID NOT HU RT VERY MUCH. TODAY 3/14 HE SAID BACK WAS STILL HURTING SO I SENT HIM TO DR.

EMPLOYEE WAS WORKING AROUND CRUSHER & COMPLAINED OF DUST BOTHERING HIM BUT DR SAID HE ALREADY HAD SINUS PROBLEMS SO EMPLOYEE STATED HIS BACK WAS HURTING

EE SAID THE DUST FROM THE FRONT END LOADER 988-B DUMPING INTO THE FEEDER WAS CAUSING HIM TO HAVE HEADACH.

EMPLOYEE WAS USING A 10LB SLEDGE HAMMER TO KNOCK THE ROCKS THAT WERE STUCK OUT FROM BETWEEN THE GRIZZLEY BARS.

EMPLOYEE WAS STEPPING OUT OF THE CAB OF HIS LAODER WHEN HE TRIPED CAUSING HIM TO JUMP TO THE GROUND AND LAND FLAT FOOTED.

EE WAS SHOVELING AROUND EL JAY SCREEN

EMPLOYEE COMPALINED OF HEADACHE AND LOW CHEST PAIN.

EMPL WAS SHOVELING AT JAW CRUSHER.

EMPLOYEE SPILLED GASOLINE ON LEG.

HARD DIRT IN SOFT SAND

WHILE CUTTING A BEARING RACE OUT OF SCREEN A PIECE OF SLAG GOT BEHIND EMPLOYEES SAFETY GLASSES AND BURNED AND SCRATCHED EYE