Buscar en el registro

As the employee was picking stones out of the crusher he felt a pain in his back. This was not considered a recordable incident until later and that is why there was a delay in reporting this incident.

Installing hose under loader above the belly pan, felt strain in left shoulder. This injury was not reported to me until November 5, 2009. I could not report this to MSHA until it was reported to me.

The emp injured works in the quality department and developed tendonitis in his right thumb and wrist due to carrying sample buckets of stone and using wire brush to clean screens for gradations.

The employee was providing assistance in fabricating a work stand in the Shop. As he was carrying a section of steel grating and attempting to lift it onto the stand, the piece of steel slipped from the employee's grip and caught his finger against the edge of the work stand.

EE had upper body thru access door to primary screen sand bin to assist co-work in dislodging massive chunk of sand, ice & snow was frozen to sides of bin overtop of moving conveyor belt. During their attempts, belt caught chunk & suddenly moved it towards ee. Frozen material struck ee and wedged him against access door frame.

After loading his truck from the overhead bins, the employee noticed stones leaking out from the back of his bin dump truck. He began removing the material that was preventing the tailgate from completely closing with his fingers. As he cleared the material, the tailgate suddenly shut and pinched his fingers against the dump bed.

While maneuvering to grease along the bottom of a front-end loader, the employee bumped the back of his head and then reacted by suddenly leaning forward, striking the front of his head against a corner on the loader.

AS THE EMPLOYEE WAS PUTTING A SCREEN PATCH ON THE TOP DECK FINISH SCREEN AT THE SECONDARY PLANT, THE EE LOOKED UPWARD TO TIGHTEN BOLTS WHEN STONE CHIPS FELL & STRUCK HIS LEFT EYE.

As the employee pulled open the tailgate on his bin truck to dislodge a rock that was wedged, the tailgate suddenly closed shut and crushed his finger against the truck bed.

As the employee picked up a piece of scrap steel plate from the ground at the Upper Plant, a 4-foot section of 2-inch angle iron slid off the plate and fell on top of his right foot.

The ee felt pain in his lower back while shoveling stone off of a conveyor belt that had stopped due to an accumulation of too much material.

WHILE TAPPING ON THE ENGINE TIMING COVER ON A FRONT END LOADER, A PIECE OF PAINT CHIPPED OFF & STRUCK THE EE'S RIGHT EYE.

THE EE LOADED HIS BIN DUMP TRUCK WITHOUT KNOWING THAT THE TAILGATE WAS UNLATCHED. AFTER NOTICING THAT THE LOAD OF STONE WAS PREVENTING THE TAILGATE FROM COMPLETELY CLOSING HE REMOVED SOME BUIL DUP. WHEN THE STONES FELL OUT, THE TAILGATE SUDDENLY CLOSED AND CRUSHED 3 OF HIS LEFT FINGERS BETWEEN THE TAILGATE AND DUMP BED.

THE EMPLOYEE DEVELOPED BACK PAIN AFTER FITTING A SCREEN INTO THE BOTTOM DECK OF A POWER SCREEN.

WHILE THE EEE WAS ATTEMPTING TO UPRIGHT AN APPROXIMATELY 200 POUND STEEL SHAFT FROM GROUND LEVEL TO A VERTICAL POSITION, THE SHAFT SLIPPED FROM HIS HANDS AND CRUSHED THE TIPS OF HIS FINGERS AG AINST THE FLOOR.

WHILE THE EMPLOYEE WAS PULLING ON THE TAILGATE OF HIS DUMP TRUCK TO RELEASE EXCESS SAND, A LUMP OF FROZEN MATERIAL FELL OUT AND LANDED ON HIS LEFT FOOT.

EMPLOYEE DEVELOPED DELAYED BACK PAIN AFTER SHOVELING STONE OFF #2 SCREEN.

AS THE EMPLOYEE WAS SLIDING A STEEL PLATE FROM THE TOP OF TWO BEAMS ON A 100 TON PRESS WITH ONE HAND, THE PLATE FELL BETWEEN THE BEAMS PINCHING HIS FINGER IN BETWEEN THE HANDLE ON THE PLATE AND ONE OF THE BEAMS.

EMPLOYEE FELT PAIN IN HIS STOMACH WHILE HE WAS LIFTING 80 LB BAGS OF LIME OFF OF A TELESCOPING CONVEYER AND PLACING THE BAGS ONTO PALLETS.

EE STRAINED HIS BACK WHILE TRYING TO SLIDE A PIECE OF PLYWOOD BETWEEN A CONVEYOR BELT UNDER TENSION AND THE CONVEYOR TROUGH IDLERS IN ORDER TO LACE THE BELT TOGETHER.

WHILE GRABBING FOR A HANDHOLD ON A CUSTOMER TRUCK'S SIDEBOARD, SEVERAL SPLINTERS LODGED UNDERNEATH THE EMPLOYEE'S FINGERNAIL.

WHILE SHOVELING LIME OUT OF A PIT THE EE STRAINED HIS BACK AS HE WAS TWISTING HIS BODY TO PLACE THE MATERIAL INTO A WHEELBARROW

EE WAS SLIDING A BAG ONTO BAG FILL TUBE WHEN HE JISSED THE BAG VALVE AND HIT HIS FINGER ON THE FILL TUBE, CUTTING HIS FINGER, REQUIRING STITCHES.

EMPLOYEE WAS BAGGING MATERIAL, HE HIT THE BAG NOZZLE WITH THE BACK OF HIS RIGHTHAND CAUSING A LACERATION WHICH REQUIRED STITCHES.

EE WAS WORKING ON A DUST COLLECTOR PIPE TO UNBLOCK PIPE. DUST FELL AND GOT INTO EE'S EYES.

EE WAS CHANGING SCREENS IN TOWER #1. WHILE WORKING HE BENT OVER & FELT A SHARP PAIN IN HIS LOWER BACK. THE PAIN GOT WORSE OVER THE NEXT 2 DAYS UNTIL HE WAS UNABLE TO WORK.

EE WAS LOADING 80 LB BAGS OF MATERIAL ON A TRUCK. EE WAS STOCKING BAGS AND FELT STRAIN IN HIS BACK.

EMPLOYEE WAS STRETCHING TO REACH A GREASE FITTING ON HSI LOADER WHEN HE FELT A PAIN IN LEFT KNEE/HIP. AFTE A MONTH THE PAIN BOTHERED HIM TO A POINT, HE WENT TO THE DOCTOR. ON 5-23-96 HE HAD SURGERY TO HIS LEFT KNEE.

EE WAS LOADING 80# BAGS ON TRUCK WHEN HE FELT A PAIN IN HIS LOWER BACK.

FROM ABOUT 10:00 AM TO 11:30 AM ON THE 11TH EMPLOYEE HELPED LOAD 80 LB BAGS OF LIME ONTO A TRAILER.AT ABOUT 2:30OM HE BEGAN SHOVELING TO REMOVE STONE SAND FROM IN FRONT OF A DOOR AT UPPER PLAN T..DURING THE SHOVELING,HE BEGAN TO FEEL SLIGHT PAIN IN HIS BACK.FROM 4:00 TO 4:45 PM HE HELPED LOAD ANOTHER TRAILER WITH BAGGED LIME.AFTER LOADING THAT TRAILER HE HAD DIFFICULTY MOVING WITH

EMPLOYEE WAS PERFORMING MAINTENANCE ON THE PRIMARY CRUSHER. HE BENT OVER AND PICKED UP A CHAIN AND PAIN FLEW INTO HIS BACK. THE EMPLOYEE DID NOT VISIT A DR RIGHT AWAY, BUT PAIN PERSISTED SO HE WENT TO THE DR AFTER SEVERAL WEEKS. (THIS INJURY WAS FIRST AID ONLY AT THE BEGINNING, BUT AFTER CONTINUING VISITS TO THE CHIROPRACTOR, THE STATUS WAS CHANGED TO MEDICAL TREATMENT.

EE WAS REPAIRING A WATER PIPE. AFTER THREADING THE PIPE, HE USED A RAG TO WIPE OFF THE NEW THREADS. LATER, HE USED THE SAME RAG TO WIPE HIS FACE. A FOREIGN BODY WENT INTO HIS EYE.

WHILE PLOWING SNOW THE EE PUSHED A COVER OFF OF A FILL PIPE FOR AN UNDERGROUND STROAGE TANK AS THE EE ROLLED THE COVER BACK TOWARD THE HOLE TO REPLACE IT A SHARP BURR ON THE COVER CUT THE EE S FINGER.

EMPLOYEE WAS HELPING TO CHANGE SCREEN ON A 6X16 SHAKER DURING THE WORK A RUST PARTICLE FELL INTO THE EMPLOYEES EYE

EMPLOYEE TWISTED WRONG WHILE HLPING TO PULL A PUMP OUT OF A WELL AND FELT PAIN IN HIS BACK.

EMPL MOVING A ROCK OFF QUARRY HAUL ROAD.PICKED UP THE ROCK AND TWISTED AS EMPL TOSSED THE ROCK OFF THE ROAD.THE TWISTING WHILE LIFTING THE ROCK CAUSED LOWER BACK STRAIN.

A CABLE BROKE ON A LIME LOADOUT CHUTE BECAUSE OF THE POSITION OF THE CHUTE THE TRAILER WAS UNABLE TO PULL OUT FROM UNDERNEATH THE CHUTE EMPLOYEE STOOD ON TOP OF THE TRAILER & ATT EMPTED TO MOV E THE CHUTE AS HE PULLED ON THE CHUTE IT SWUNG OUT & KNOCKED THE EMPLOYEE OFF THE TRAILER EMPLOYEE FELL APPROX 10-11 FT TO THE GROUND

EMPLOYEE TURNED ON THE WATER SUPPLY TO A SECONDARY CRUSHER. WHEN HE BENT OVER TO SEE IF THE WATER WAS RUNNING PROPERLY, HE FELT SOMETHING PULL IN HIS BACK.

EMPLOYEE WAS SHOVELING STONE TO STEM BLAST HOLES.

THE EMPLOYEE WAS OPERATING A TOWMOTOR AT THE TIME. WHILE OPENING THE TOWMOTOR DOOR TO GET OUT OF THE TOWMOTOR, THE EMPLOYEE PUSHED AGAINST A CRACKED WINDOW ON THE TOWMOTOR DOOR. HE SUFFERED A SMALL CUT ON HIS LEFT HAND WHICH HE PUT A BANDAID ON. HE CONTINUED TO FEEL DISCOMFORT AND WENT TO THE DOCTOR 10-9-89. THE DOCTOR USED A SMALL KNIFE TO REMOVE A SLIVER OF GLASS.

EMPL MOUNTING TRUCK AT BEGINNING OF DAY.AS HE LIFTED RIGHT LEG UP TO 1ST STEP,FELT SEVERE PAIN IN HIS BACK.SUSPECTED AGGRAVATION OF PRE-EXISTING CRUSHED DISC IN HIS BACK.

HIM AND ANOTHER EMPLOYEE WERE LIFTING A HORESPOWER VIBRATORY SCREEN MOTOR UP APPROX. 4 FEET. AS HE WAS LIFTING, HE FELT A PAIN IN HIS BACK.