Buscar en el registro

Employee was tapping a hose on the ground to dislodge a clog when the material released and hit him in the eye

EE was checking Off Spec Door on # 4 Grizzly on the # 4 Kiln. The door was stuck in the open position and the EE pulled on the door to get it back on the hinges. He felt a pull in his lower back. Conditions and work conditions were normal, no Slip, Trip or Fall Hazards and Poor Housekeeping was NOT noted.

Employee (Bowl Mill Attendent), was attending the clay feed belt, noticed large piece of clay, he stopped the belt and attempted to remove clay without assistance. He felt pain in his lower back, notified Supervisor. He was taken to local hospital - Diagnosed w/ back strain - light duty release to work 14 days.

Employee (mech) installing cylinder on scraper. After getting out from under it, felt a catch in his back. Occupational Doctor on 7/25/06 ? diagnosed w/ minor lower left back strain. Also given 10lb lifting restriction - later clarified on 8/11 to be because of back strain not an unrelated personal hlth issue.

The employee was removing a lump of clay from a conveyor. The weight of the clay was approx. 15 lbs. As the employee reached to remove the clay from the belt he felt a pull in his right arm (bicep). The employee has a possible torn tendon in the right arm next to the shoulder.

The employee was preparing to trim skirts on a belt conveyor. The employee exposed the blade of the cutter before positioning himself in firm working position. As the employee tried to position himself to complete the work he punctured and lacerated the left wrist.

The employee was preparing to replace a door on the back portion 6X16 Shaker Screen. The employee pulled a muscle on the right side of his back.

On 9/21/04 empl. reports back pain attributed to a work accident on 3/9/03. That day lifted 10lb can, strained back. 3/10/03 and 9/27/04 Dr visits status: perform normal job. Visits on 10/6 & 10/8/04 Dr noted no change, refer to specialist exam 10/12 & MRI 16th. MRI & diagnosis was Lumbar Spondylosis. Empl. could contin. to work w/limits on lifting, bending, etc.

EQUIPMENT REPAIRS, EMPLOYEE HAD TWO FINGERS CUT.

THE EMPLOYEE WAS CLIMBING UP THE LADDER ON A FRONT END LOADER WHEN HE FELT SOMETHING POP IN HIS LEFT ELBOW. THERE WAS NO TRAUMA TO THE ELBOW. NO DEFECTS WERE FOUND BUT THE INVESTIGATION IS CON TINUING.

IMPROPER BODY POSTURE. THE EE WAS REACHING FOR A ROLLER HOUSING AND PULLED A MUSCLE IN THE UPPER RIGHT PORTION OF HIS BACK.

THE EE THREW THE OFF SPEC CHUTE. WHEN THE KILN GOT BACK ON SPEC, THE EE HAD TO PULL THE CHUTE BACK UP IN ORDER FOR THE MATERIAL TO GO TO THE STOCKPILE. WHEN THE EE THREW THE CHUTE, HE PULLED A MUSCLE IN THE MIDDLE OF HIS BACK.

EE WORKED NORMAL SHIFT AS A CLAY FEED ATTENDANT & WENT HOME. HE NOTICED SWELLING AROUND HIS RIGHT ELBOW. THE DOCTOR SAID HIS SWELLING IS FROM BURSITIS FROM AN OLD INJURY 4/25/00.

THE EE WAS CLEANING & SHOVELING UNDER THE TAIL PULLEY. WHEN THE EE STOOD UP FROM SHOVELING HE FELT A PAIN IN HIS UPPER & LOWER BACK.

EE WAS SHOVELING UNDER THE #2 TAIL PULLEY & THE EE BENT UNDER THE CATWALK TO GET TO THE OTHER SIDE. WHEN THE EE TRIED TO GET UP HE FELT A POP IN HIS BAKC

THE EMPLOYEE WAS TRYING TO UNSTOP A CLAMGATE. THE EE TRIED TO UNSTOP THE CLAMGATE BY USING THE HANDLE. THE EE'S HAND SLIPPED OFF THE HANDLE. THIS CAUSED THE HANDLE TO COME BACK UP AND HIT T HE EMPLOYEE IN THE HAND.

EE WAS PULLING A SECOND BATTERY FROM A FORKLIFT.THE WEIGHT OF THE BATTERY WAS PLACED ON HIS RIGHT ARM. THIS CAUSED HIM TO FEEL A PULL & BURNING SENSATION.

EE WAS PUSHING DIRT CLODS ON GRILL BELT WHEN A LARGE PIECE OF DIRT CAME ON BELT. WHEN EE WENT TO PUSH DIRT OFF BELT, HE PULLED A MUSCLE IN HIS BACK.

THE EE WAS PLACING A 55 LB APPROX. CYLINDER ON A TABLE. IT WAS NOT A STRAIN ON THE EMPIRE TO REMOVE THE CYLINDER INITALLY.

3 MEN WERE WORKING ON A DUMP TRUCK WHEN ONE WENT TO PUT A BOLT IN A SPRING INSULATOR AND THE TRUCK FELL. THE TRUCK WAS HELD UP ON BLOCKS AND 3 JACKS. THE TRUCK FELL ON CO-WORKER'S HAND AND HI T INJURED ON THE RIGHT LEG.

3 MEN WERE WORKING ON A DUMP TRK, WHEN EE WENT TO PUT A BOLT IN TO A SPRING IN INSULATOR ON THE TRK FELL THE TRK WAS HELP UP BY BLOCKS & JACKS THE TRK FELL ON EE'S RIGH HAND, HE RECEIVED A PO INTER CUT THAT REQUIRED 4 STITCHES ON TOP SIDE OF HAND BETWEEN THUMB & FINGER

THE EE WAS WORKING ON THE #1 SILO CONVEYOR BELT. THE EE WAS TAKING SAFETY PERCAUTIONS BY WEARING HIS SAFETY GLASSES.

EE WAS ATTEMPTING TO COOL A LOG WITH WATER HOSE AT BACK DOOR OF #4 COOLER. WHEN WATER SPRAYED ON HOT MATERIAL, STEAM WAS CREATED AND BLEW BACK, BURNING HIS RIGHT ARM.

EE WAS TIGHTENING ROPE ON ROLLER ON REVERSIBLE BELT ROPE BROKE AND EE JAMMED HIS FINGER BETWEEN ROLLERS AND ANGLE IRON.

EMPLOYEE WAS HELPING SUPERVISOR PUT A GUARD ON THE #3 FAN AND THE #2 COOLER. AS THE SUPERVISOR LET GO OF THE GUARD, THE EMPLOYEE WAS STILL HOLDING THE GUARD. WHEN THE GUARD CAME DOWN, IT FELL ON HIS RIGHT HAND.

EE WAS THROWING A PIECE OF CLAY OFF THE BELT, WHEN THE CLAY BROKE IN EE'S HAND. EE TRIED TO GRAB PIECE OF CLAY AND HIT HIS ELBOW.

ASSISTING NEW EE IN ASSEMBLING HARD HAT BAND SLIPPED DOWN INTO HARD HAT AND THUMB STRUCK SIDE OF HAT, PULLING NAIL BACK CAUSING A TEAR ON SIDE OF THUMB NAIL.

EMPLOYEE WAS UNCHOKING A LOADING DOOR, BY REMOVING A PIECE OF METAL, WHEN HE PULLED HIS ARM OUT TOO QUIKLY GETTING RIGHT ELBOW CAUGHT IN DOOR.

WHILE INSPECTING AND GREASING BEARINGS, EMPLOYEERAISED GUARD TO INSPECT THE BEARINGS. THE GUARD FELL ON HIS HAND AND CUT HIS SMALL FINGER ON HISRIGHT HAND.

EE WAS ASSISTING IN THE INSTALLATIO OF BAGS IN THE DUST SYSTEM BAGHOUSE. HE SLIPPED ON THE LADDER STRIKING ELBOW ON THE LADDER REFUSED MED TR EATMENT DID NOT REQUEST MED TREATMENT UNTIL 7/28/ 99

SHOVELING COAL OFF SILO ROOF RESULTED IN LOWER BACK STRAIN Y

EE WAS CLIMBING INTO CAB OF CHERRY PICKER AND HE BENT AND TWISTED LEFT KNEE. HE RE-INJURED HIS LEFT KNEE ON 6/16/99 WHILE WASHING OUT MATERIAL ON #3 COOLER DRAG CHAIN.

EE WAS TURNING TO GET AN OIL BUCKET WHEN HE FELT HIS BACK "GIVE OUT". HE SUFFERED A BACK STRAIN FROM IMPROPER BODY MOVEMENT.

EE WAS SHOVELING UNDER A COAL BELT PULLEY AND STRAINED HIS BACK.

LEFT HAND SLIPPED WHILE WIRING THE SPARE WATER PUMP AND JAMMED ON THE PECKER HEAD CAUSING SWELLING AND FRACTURE OF THE RING FINGER Y

EE WAS CHANGING THE OXYGEN BOTTLE ON THE WELDING TRUCK WHEN HE SMASHED HIS FINGERS BETWEEN THE OXYGEN BOTTLE & TRUCK CAUSING A FRACTURE OF THE 3RD & 4TH FINGERS ON THE LEFT HAND.

EE WAS RETREUVUNG A BUCKET HE DROPPED IN THE SHIPPING TUNNEL. HE DUCKED UNDER THE CROSS BRACE IN THE TUNNEL & RETREIVED THE BUCKET. WHEN RETURNING, HE CAME UP UNDER THE CROSS BRACE TOO SOON ST RIKING IT WITH HIS FACE CAUSING A SMALL CUT ON THE BRIDGE OF NOSE.

EMPLOYEE WAS HSOVELING OUT FROM UNDER THE DISCHARGE CONVEYOR WHEN HE PULLED HIS LOWER BACK.

EE WAS CHECKING THE WATER IN THE FRONT END LOADER (938F) AND THE RADIATOR CAP BLEW OFF, BURNING HIM ON HIS RIGHT HAND, ARM AND HIS TOP LIP.

EE WAS DIGGING THE TAIL PULLEY OUT WHEN HE TURNED TO GET UP HIS BACK BEGAN TO HURT WITH A SHARP PAIN.

EMPLOYEE WAS CARRYING A BATTERY TO INSTALL IN A LOADER WHEN HE FELT A MUSCLE PULL IN HIS UPPER BACK.

EMPLOYEE HURT HIS SHOULDER GETTING A LARGE PIECE OF WOOD OFF OF A BELT AND THROWING IT THROUGH THE CHUTE BEHIND HIM.

EE WAS ASSISTING IN THE REINSTALLATION OF THE GUARD OVER THE V BELTS ON THE 3 CRUSHER. HE WAS NOT WEARING WORK GLOVES AT THE TIME HE CUT HIS FINGER ON THE GUARD S EDGING.

EE WAS LIFTING THE #3 SCRUBBER BLOWER NOZZLE WHEN IT SLIPPED FROM HIS GRIP STRIKING HIS PINKY FINGER. HIS FINGER TIP WAS CUT IN A SEMI-CIRCULAR OPENING.

EMPLOYEE WAS CLOSING THE TAILGATE ON THE DUMP TRUCK HE WAS OPERATING. HE MADE AN ATTEMPT TO REMOVE SOME MUD FROM THE TAILGATE WHILE TRYING TO CLOSE IT. THE TAILGATE STRUCK HIS FINGER DURING TH E PROCESS.

SERVICING #4 BOWL MILL ROLLERS-POURING 150W PIL INTO THE ROLLER, THE ROLLER MUST HAVE BEEN LOW ON OIL AND WAS HOT WHEN EE PUT THE COLD OIL IN ITFLUSHED BACK AND HIT EE IN THE FACE. BURNS TO N ECK AND FACE.

EE AND COWORKER WERE OPENING A COLLER DOOR WHEN MATERIAL FORCED THE DOOR TO OPEN LETTING STEAM OUT. EE THREW ARM UP OVER FACE, AND WAS BURNED ON UNDERARM.

EMPLOYEE WAS ASSISTING IN REPLACING IDLERS ON TUNNEL BELT IN THE SHIPPING DEPT. ANOTHER EMP WAS HOLDING UP THE BELT WITH A PIPE, WHEN THE PIPE SLIPPED, STRIKING EMP'S MIDDLE FINGER.

EMPLOYEE WAS HELPING REPAIR #2 DRIVE CHAIN.HE REACHED ACROSS THE CHAIN AND HIS GLOVE CAUGHT ON A BOLT CAUSING HIS ARM TO BE PULLED INTO OR AGAINST THE CHAIN.EMPLOYEE SUFFERED LACERATIONS AND S OME TEAR IN SMALLER LIGAMENTS TO HIS RIGHT FOREARM.

EE WAS ASSISTING COWORKER IN PUTTING THE DUST CHUT BACK ON #3 KILN INLET SEAL. COWORKER WAS LEANING ACROSS A HANDRAIL AS HE WRAPPED A CHAIN AROUND THE CHUTE. EE WAS STANDING BESIDE HIM WITH HI S HAND ON THE HANDRAIL. THE WELD ON THE HANDRAIL BROKE UNDER THE WEIGHT OF COWORKER CAUSING THE CHUTE TO SHOOT FORWARD STRIKING EE'S HAND CAUSING THE INJURY.