Buscar en el registro

EE was driving a 135-foot manlift. As EE approached the railroad crossing, the front tires of the manlift dropped into a swale before the crossing. The two front tires dropped first, then the two rear tires. This initiated the manlift basket to bounce EE causing EE to twist their arm as EE held onto the guard rail. EE sprained left elbow, placed on restricted duty 2/5/24.

Laborer was holding lower part of a pallet that separated from its top part and the laborer tried to position pallet so it would sit flat on pallet's stand. A forklift operator set pallet down before laborer moved hand away from pallet. Laborer's right index finger was pinched between pallet and pallet's stand. This caused a laceration to finger resulting in 2 stitches.

While digging in pile, the loader found some hard digging. When the loader bucket came loose, it caused the machine to bounce.

Unknown - still investigating.

Operator backed and stopped loader within 3' of kiln door. After operator stopped, EE stepped behind the loader to pick up wire cable and shackle. When he stood up, the loader inexplicably lurched backwards pinning him against the kiln door. The right rear of the loader struck EE's right arm, hip/torso area, compressing him against the door.

EE was operating the cat skid loader moving clinker from outside under kilns to clinker drag. The conditions while running the skid loader were very dusty between the coolers. Being in the dust for a long time, his eyes got aggravated, he rubbed them, and got some clinker dust in his right eye.

While back draffing pile, hand slipped off steering wheel causing him to strike elbow on steering knob.

EE WAS VISUALLY INSPECTING A BROKEN SCREW CONVEYOR THRU AN ACCESS DOOR ONT HE EAST SIDE OF DRIVE END OF SCREW CONVEYOR. THE COMPARTMENT ABOVE EVIDENTLY HIT IT'S PULSE DOWN CYCLE WHICH WENT DUS T FALLING INTO SCREW AND SPLASHED OUT AND HIT INJURIED IN FACE. REQUIRED PRESCRIPTION MEDICATIONS FOR EYES.

EE WAS ON HIS WAY TO UNPLUG SILO 21 WEIGTHFEEDER WHEN HE NOTICED SILO 11 WAS ALSO PLUGGED WITH A LUMP IN THE DISCHARGE CHUTE. HE GRABBED ANOTHER LUMP AND PROCEEDED TO TRY TO KNOCK IT THROUGH. THIS WORKED, HOWEVER THE LUMP THAT HE USED THEN BECAME LODGED BETWEEN THE CHUTE & THE WEIGTH BELT TRAPPING HIS FINGERS IN A PINCH POINT. AS THE BELT CONTINUED TO RUN & HIS FINGERS WERE CUT.

EMPLOYEE WAS PUSHING TREES OVER WITH A DOZER WHEN HE RAN UP ON A TREE TOO CLOSE TO EDGE OF SLOPE AND DOZER TIPPED OVER DOWN THE SLOPE AND ROLLED ALL THE WAY OVER. EMPLOYEE WAS WEARING SEATBELT AT TIME. EMPLOYEE WAS NOT SUPPOSED T0 BE PERFORMING THIS TYPE OF WORK AS HE WAS NOT TRAINED TO PUSH TREES.

EE WAS IN ROUTE FROM ST.LOUIS TO CAPE GIRARDEAU TO ATTEND MSHA TRAINING AT LONE STAR CEMENT WHENHE HAD AN AUTOMOBILE ACCIDENT (1 CAR) HE APPARENTLY DOZED OFF & RAN OFF ROAD HITTING A ROCK BLUF F HEAD ON (WAS DRIVING HIS OWN VEHICLE)

EMPLOYEE WAS WELDING A UNISTRUT ON MILL BUILDING HOIST FOR PLANT ELECTRICIANS AND THE FINISH MILL #1 AIRSLIDE WAS BLOWING OUT AND DUSTED UP THE MILL BUILDING. A LARGE QUANTITY OF DUST FELL ON EMPLOYEE'S HEAD (HARD HAT) AND WENT DOWN BEHIND HIS WELDING HOOK AND INTO HIS EYES. HE WASHED HIS EYES SEVERAL TIME SBUT COUL DNOT ET LEFT EYE CLEANED OUT, SOHE WAS SENT TO EMERGENCY ROOM.

EMPLOYEE WAS OPERATING A LOADER DIGGING OUT SHOT ROCK TO LOAD TRUCKS REAR END OF LOADER LIFTED OFF THE GROUND AS HE WAS DIGGING THE ROCK & WHEN THE ROCK CAME LOOSE THE BACK END OF THE LOADER C AMD DOWN JARRING THE EMPLOYEE CAUSING LOW BACK PAIN HE DID NOT REAUEST TO SEE A DOC UNTIL 07-22-93

95149ED WAS INSIDE 2 KILN WHILE ANOTHER EE WAS CLOSING THE HOOD DOOR USING THE EMICO LOADER WHEN THE DOOR SHUT A PIECE OF CASTABLE FELL OUT WHICH STRUCK INJURED ON RIGHT KNEE AND FOOT. EE APPE 19540TO BE GOING INTO SHOCK SO AN AMBULANCE WAS SUMMONED EE WAS TAKEN TO LOCAL HOSPITAL KNEE WAS WRAPPED WITH ICE BANAGE AND BUDDY SPLINT WAS PUT ON LITTLE TOE RIGHT.

EMPLOYEE WAS OPERATING A BOBCAT CLEANING UP AROUND THE BOTTOM ASH & MILL SCALE HOPPER FEEDERS HE REALLY CANT REMEMBER ANY PARTICULAR INCIDENT THAT MAY HAVE CAUSED THE INJURY BUT HE THINKS IT WAS CAUSED BY THE BOUNCING MOTION OF THE BOBCAT ON THE FROZEN GROUND

EMPLOYEE WAS REMOVING JUMPER CABLES FROM STARTER OF A M743 BOBCAT LOADER WHEN HIS HAND CAME IN CONTACT WITH MOVING FAN BLADE RESULTING IN LACERATION TO MIDDLE FINGER OF RIGHT HAND, REQUIRING 8 SUTURES. WAS GIVEN CEPHALEXIN (ANTIBIOTIC).

EE WAS USING A TRACKMOBILE TO PUSH EMPTY RAIL CARS OUT TO RIVER CEMENT CO MAIN SPUR FOR PICK UP BY FURLINGTON NORTHERN. IT WAS RAINING AND WHEN EE TRIED TO STOP CAR HE WAS PUSHING THE TRACKMOB ILE SLID ON THE WET RAILS CAUSING RAIL CAR TO RAM INTO OTHER RAIL CARS ALREADY IN POSITION. COLLISION WAS HARD ENOUGH TO CAUSE LEAD CAR TO DERAIL. EE DID NOT COMPLAIN OF BACK HURT THAT DAY BU

GOT OFF FORK LIFT FT SLIPPED IN SOME LOOSE MATERAIL CAUSING HIS FT LEG TO SLIDE OUT

EMPLOYEE WAS OPERATING A LARGE FRONT END LOADER HE HAD PICKED UP A LARGE BOULDER IN THE BUCKET AS HE WAS BACKING UP HE HIT AN UNEVEN PLACE IN QUARRY FLOOR THE BACK OF THE LOADER CAME OFF THE G ROUND & THE ROCK ROLLED OUT OF THE BUCKET LETTING THE LOADER TO COME DOWN HARD THROWING EMPLOYEE AGAINST THE RIGHT SIDE DOOR GLASS & FRAME

ATTACHED SHEET-ASSIGNED TO TAKE SAMPLE OF #2 KILN PRECIPITATOR DUST FROM K423 SCREW CONVEYOR...PIPE WAS PLUGGED FROM MATERIAL THAT HAD HARDENED.EMPL REMOVED PORTION OF PIPE DECIDED TO TEST..BY STICKING FINGER INTO PIPE,GOT FINGER INTO SCREEW WHICH CUT & MASHED RIGHT INDEX FINGER.

EMPL WAS ASSIGNED TO ASSIST IN REMOVAL OF CAOL PIPE TO #2 KILN. #2 KILN WAS DOWN FOR REFRACTOR REPAIR. EMPL WAS OPERATING FORKLIFT TO LIFT SECTION OF CAOL PIPE WHEN LARGE AMOUNT OF COAL DUST WAS SHAKEN FROM TOP OF PIPE & FELL ON OPERATOR. INJURED GOT DUST IN BOTH EYES. AFTER WASHING OUT EYES HE COMPLAINED THAT HIS RIGHT EYE CONTINUED TO BE I RRITATED. CONSEQUENTLY HE SAW DR.

EMPLOYEE WAS AS8IGNED TO CLEAN A LARGE SPILL OF CLINKER FROM ISLE BETWEEN VIBRATING CONVEYOR PANS AND THE MAGALDI CONVEYOR BOTH CONVEYING SYSTEMS WERE SHUT DOWN BECAUSE OF THE LARGE SPILL EMPL OYEE HAD COMPLE7ED CLEANING AROUND VIBRATING CONVEYOR PAN AND PRODUCTION WAS INFORMED TO GO AHEAD AND START THAT SYSTEM EMPLOYEE CONTINUED TO CLEAN MATERIAL FROM AROUND CONVEYOR WHEN THE VIBR

INJ HAD JUST FI3ISHED TALKING TO THE DRIVER OF A FLATBED TRUCK THAT WAS PULLING A TRAILER CARRYING A WELDING MACHINE ON IT. AS IHE STARTED TO TURN AND WALK AWAY A TIRE ON THE TRAILER STRUCK TH E BACK OF HIS L9G AND KNOCKED HIM DOWN. THE TRAILER TIRE ALSO RAN OVER HIS ANKLE AND FOOT. THIS RESULTED IN A CAST BEING PLACED ON HIS R FOOT. ACCIDENT CAUSED A CHIPPED BONE IN R FOOT AS WELL

EMPLOYEE STATES3THAST WHILE STANDING APPROXIMATELY 15-20 FEET FROM THE UNDERNEATH SIDE OF C-3 CONVEYOR BELT A HARD CHUNK OF DIRT APPROXIMATELY THE SIZE OF A BASEBALL FELL FROM ABOVE AND STRUCK EMPLOYEE ON TH9 RIGHT ARM JUST ABOVE THE WRIST. THE MATERIAL CRUMBLED UPON STRIKING THE EMPLOYEE.DOCTOR WAS SEEN AND DIAGNOSED RIGHT FOREARM CONTUSION INJURY AND PUT A WRIST SPLINT ON THE ARM

EMPLOYEE WAS AS8IGNED TO OPERATE AN EIMCO FRONT END LOADER INSIDE #1 ROTARY KILN.HE WAS REMOVING OLD REFRACTORY AND COATING WITH THE LOADER-PREPARING LILN FOR REFRACTORY REPLACEMENT.WHILE OPE RATORING THE MA7HINE OVER ROUGH COATING HE WAS SEVERLEY JARRED AND HE ALLEGES AT THE TIME HE FELT SOMETHING PULL IN HIS GROUN.

EMPLOYEE ALLEGE8 HIS HAND SLIPPED OFF CONTROL LO LEVER OF LOADER CAUSING HIS R T ELBOW TO SWELL RT INITIALLY SAW EMPLOYEE FOR THIS ALLEGED INJURY ON 11-15-85 DR GAVE ORTHOPAEDIC EXAM AND ASPI RATION OF RT EL6OW OLE CRANON BURSA WAS PERFORMED EMPLOYEE WAS GIVEN AN ELBOW SLEEVE TO WEAR

INJURED WAS OPERATING A LOADED 50 MACK REAR DUMP TRUCK ON A HAUL ROAD WHEN THE RT REAR AXLE HOUSING OF TRUCK BROKE ALLOWING AXLE AND RT REAR DUAL TIRES TO COME OFF CAUSING THE RT REAR OF DUMP BED TO FALL TO GROUND SCOOTING ON THE HAUL ROAD INJURED REMAINED IN DRIVERS POSITION THROUGHOUT BUT DID RECEIVE A JOLT WHEN RT REAR OF BED STRUCK THE HAUL ROAD DIGGING INTO THE BED OF THE RO

EMPLOYEE WAS INSTALLING A COVER PLATE ON THE RCC 300 BARGE DUST COLLECTOR PIPE. WHILE IN THE PROCESS OF PLACING THE COVER PLATE ON THE OPENING THE BARGE MOVED IN AGAINST THE CONCRETE BARGE LOA DING DOCK CATCHING THE EMPLOYEES RIGHT HAND 4TH AND 5TH DIGITS BETWEEN THE COVER PLATE AND THE BARGE LOADING DOCK.

EMPLOYEE WAS HAULING SAND FROM SAND PIT TO PRIMARY CRUSHER. A CEMENT TRUCK WAS PARKED IN A "NO THE RIGHT FRONT TIRE OF HIS TRUCK OVER THE CURB AND INTO A SOFT DITCH BANK THERBY PULLING HIS TRU CK INTO THE DITCH.