DeSilva Gates Aggregates Metal/Non-Metal

Employee was pushing pit run material to the feeder in a D10. Employee states struck a rock and this jarred EE around in the seat. EE stated that it started hurting later that day. *Injury was not reported by employee until 11/2/2023.

Removing welder from service truck. Slide tray slid all the way out of compartment. Welder fell on employee's foot, landed just past edge of the steel toe. Broken right big toe.

Employee pinched right index finger between fork and mast while adjusting fork spread on forklift. 4 stitches to close laceration.

On pit pump in main pit to remove float and pump from service. Needed to disconnect from discharge hose and the float flipped in the water. Employee fell into the water and hit his knee as he was going in and cut his leg requiring stitches.

Employee was installing a wear plate on a conveyor that feeds a twin shaft coarse material washer. He was standing on a partition between the two tubs. He removed his gloves to retrieve hardware. At this point, he lost his balance and fell aproximately 3'. He braced his hand during and cut his left hand in between the index and middle finger that required 10 sutures.

CRANE WAS LOWERING SCREEN INTO SCRUBBER. EE WAS TRYING TO POSITION SCREEN, IT SLIPPED & CAUGHT HIS FOREARM BETWEEN SPRAY BAR IN SCRUBBER & SCREEN, CUTTING WRIST.

WHILE CUTTING METAL IN TUNNEL, A PIECE OF HOT SLAG FELL INTO RIGHT EAR.

THE FIRST WE KNEW OF THIS INJURY WAS ON 9-13-2001. EE IS NOT SURE WHEN IT OCCURRED OR WHAT ACTIVITY HE WAS PERFORMING. THE MORNING OF THE 13TH HE NOTICED A BUILGE IN HIS ABDOMEN BEFORE COMING TO WORK. HIS WIFE CALLED HIS FAMILY DR. WHO SAID HE SHOULD GO TO ER. THE DRS THERE SAID IT WAS 3WORK RELATED. HE WAS ALSO SEEN BY OUR CO DR. & A HERNIA SPECIALIST WHO ALL AGGREED IT WAS WORK R

REACHING INTO CAR TO GET TOOLS, A RAZOR KNIFE CUT EMPLOYEE'S HAND.

AS EE STEPPED UP PORTABLE BASE PLATFORM, HE SLIPPED AND FELL TWISTING AND INJURING FOOT.

EE WAS WALKING BETWEEN 2 SCREENS AND SLIPPED HITTING HIS FACE AGAINST CONVEYOR.

WHEN CLOSING EQUIPMENT DOOR, EE'S HAND SLIPPED INTO JAM AND DOOR CLOSED.

WHILE STANDING ON DECK OF HAUL TRUCK TO CLEAN WINDSHIELD, EE SLIPPED AND STRUCK HIS RIBS AND WRIST AS HE FELL TO THE GROUND. HE LANDED IN A STANDING POSITION.

WHILE MOVING A PIECE OF PLYWOOD ON THE PILE EE FELT HIS BACK POP.

EE TWISTED KNEE WHEN CLIMBING ONTO EXCAVATOR, HAD FOOT AT AN ANGLE TO CLIMB ONTO MACHINE.

EMPLOYEE WAS CLEANING AND INSPECTING YARD AND FELL IN A HOLE. EMPLOYEE REPORTED HE PULLED A LEG MUSCLE. DR REPORT STATES BACK STRAIN.

WHILE LIFTING OXYGEN AND ACETELYN TANKS ONTO TRUCK, EE FELT STRAIN TO LOWER BACK.

EE WAS TRYING TO DISLODGE PIECE OF STEEL FROM JAW CRUSHER. BLOCK OF STEEL CAME OUT & SMASHED END OF RIGHT THUMB

7/16/98 WRIST HURTING-EE CLAIMS IT IS A REOCCURANCE OF INJURY SUSTAINED 3/21/97

WHILE EE WAS UNLOADING A TRUCK, A FELLOW WORKER STARTED TO DRIVE IT AWAY. EE RAN AROUND THE TRUCK TO STOP IT AND SLIPPED ON LOOSE ROCK, INJURING HIS RIGHT KNEE.

ROCK ON SCREEN FELL OFF AND SMASHED FINGER.

CRANE LIFTING CHAIN, 1 OF 3, DISCONNECTED CAUSING GENERATOR TO BECOME UNBALANCED AND WHEN HITTING GROUND, ROLLED ON TOP OF EE.

EE WAS UNDER SCALPER CHUTE & JAMMED THUMB INTO LINING BOX.

ALLEGEDLY FELL THROUGH CAT WLAK. ACCIDENT UNDER INVESTIGATION.

EE STATES THAT WHILE GREASING THE PLANT, HE SLIPPED IN A DITCH AND INJURED HIS RIGHT CALF AND HIP.

EMPLOYEE STATES THAT FOUR DAYS AFTER HE WAS EMPLOYED BY THE COMPANY HE STARTED TO FELL PAINA ND SWELLING N HISI HANDS AND WRIST, WHICH WORSENED AND CONTINUED UP TO THE PRESENT.

EMPLOYEE WAS MOVING PIPE HE WAS PREPARING TO WELD AND STRAINED LOWER BACK.

EMPLOYEE WAS WORKING ON JAW CRUSHER IN THE PLANT. HE WAS USING A SLUG WRENCH TO TIGHTEN THE LINERS. HE HIT HIS THUMB WITH A HAMMER.

EE WAS WALKING UNDER MAIN FEED CONVEYOR WHEN HE SLIPPED AND FELL IN THE MUD. HE PUT HIS HANDS OUT TO BRACE HIMSELF AND INJURED HIS RIGHT HAND.

EMPLOYEE WAS GREASING NEW WET SCREEN WHEN HE SLIPPED AND STEPPED WRONG, PULLING BACK MUSCLES.

EE WAS WORKING ON CONVEYOR BELT A MILL WHEN HE WAS BIT OR STUNG BY AN INSECT

HAUL TRUCK WAS BEING LOADED BY DRAGLINE. DRAGLINE BUCKET HIT TAILGATE OF TRUCK CAUSING A WHIPLASH ACTION.

LABORER WAS SHOVLEING MATERIAL AND MOVED A HEAT EXCHANGER. HE TEHN TOOK HIS LUNCH BREAK. WHILE RESTING HIS LOWER BACK TIGHTENED UP AND THEN BEGAN TO BE VERY PAINFUL.

EMPLOYEE WAS USING RAZOR KNIFE TO ENLARGE HOLE ALREADY PUNCHED IN RUBBER LINING. HE WAS SITTING DOWN, HOLDING THE RUBBER WITH HIS LEFT HAND AND USING THE RAZOR KNIFE WITH HIS RIGHT HAND. THE KNIFE SLIPPED, LACERATING HIS LEFT HAND.

EMPLOYEE WAS MANUALLY GUIDING PIPE WHICH WAS SUSPENDED BY CRANE THE GROUND WAS SOFT & MUDDY AS EMPLOYEE WAS HOLDING PIPE IT JERKED UP AT HIM DUE TO THE MUDDY CONDITIONS HE WAS NOT ABLE TO STEP AWAY & STRAINED BACK TRYING TO AVOID PIPE

HAUL TRUCK THAT EMPLOYEE DRIVES WAS BEING LOADED WITH MATERIAL WHEN DRAGLINE BUCKET DROPPED INTO BED OF TRUCK. DUE TO HOT WEATHER, GREASE ON HOIST CLUTCH MELTED, ALLOWING CLUTCH TO SLIP AND B UCKET TO FAIL.

EMPLOYEE CLAIMS THAT WHILE HE WAS USING OXY/ACT BURNING TORCH AND STANDING ON WOOD CATWALK HE HAD TO STAND ON TIPTOES TO REACH BOLT BEING CUT. HE FELT A "POP" IN CALF MUSCLE OF RIGHT LEG. DOCT ORS DIAGNOSE MUSCLE STRAIN. EMPLOYEE DID NOT WANT TO GO TO THE DOCTOR UNTIL FOUR DAYS AFTER ACCIDENT ON 4-28-92.

EMPLOYEE CLAIMS THAT WHILE HE WAS REMOVING THE CSK PLOW BOLTS FROM THE CUTTING BLADE ON LOADER BUCKET WITH AIR WRENCH ONE OF THE BOLTS FELL FROM THE COUNTERSUNK HOLE IN THE BUCKET AND THE HEAD OF THE BOLT CUT EMPLOYEES MIDDLE FINGER ON HIS LEFT HAND.

EE CLAIMS THAT WHILE HE WAS CLEANING OFF WIRE CLOTH SCREENS WITH STEEL CLEANING ROD HE FELT A TWINGE OF PAIN IN HIS UPPER BACK LEFT SHOULDER AND NECK AREA.

EMPLOYEE AND CO-WORKER WERE LIFTING AND CARRYING OUT A HEAVY IMPACT IDLER FROM NARROW TUNNEL WALKWAY.EMPLOYEE FELT SHARP PAIN IN LOWER BACK ON RIGHT SIDE.IDLER WAS TO HEAVY FOR ONE PERSON TO R EMOVE BY HIMSLEF AND THUS TWO REPAIRMEN DID THE JOB BUT INJURED EMPLOYEE HAS HAD BACK PROBLEMS BEFORE AND RESTRAINED HIS BACK AGAIN ON THE PROJECT.

EMPLOYEE WAS CLEANING CRUSHED ROCK DRY SCREENS WITH METAL CLEANING ROD AND STEPPED BACKWARD AND HIT LEFT EAR AGAINST A CHUTE GATE LEVER WHICH HAD A PIECE OF TIE WIRE ON ITS END.EMPLOYEE LACERA TED HIS LEFT EAR REQUIRING FOUR SUTURES.

EMPLOYEE WAS WORKING UNDER SCREENS DUST PARTICLES BLEW INTO EYES

EMPLOYEE WAS USING A HAMMER TO LOOSEN AND SMOOTH SOME ROUGH EDGES ON A METAL RIM.A SMALL PARTICLE FLEW INTO HIS RIGHT EYE.

IT WAS DARK AT 5:45 AM. THE EMPLOYEE HAD JUST TALKED TO SEVERAL EMPLOYEES AT THE SHOP AND THEN WALKED TO THE PARKING LOT ON THE SOUTH SIDE OF THE SHOP TO TALK TO OTHER EMPLOYEES WHO STARTED WO RK AT 6 AM. EMPLOYEE TRIPPED OVER A STEEL WEAR PLATE LINER THAT REPAIRMAN HAD LEFT IN THE WALKWAY AND FELL. EMPLOYEE HIT LEFT SIDE OF RIBS AGAINST STEEL RAIL WHEN HE FELL.

EMPLOYEE CLAIMS THAT WHEN HE WAS HAMMERING OUT HOLDING PIN ON DRAGLINE BUCKET TEETH HE HIT INDEX FINGER ON RT HAND <WHICH WAS HOLDING HAMMER PUNCH| WITH SLEDGE HAMMER IN HIS LEFT HAND

EMPLOYEE CLAIMS THAT AS HE STEPPED ONTO THE GROUND UPON DESCENDING THE LADDER ON THE MANITOWAC DRAGLINE HE STEPPED ONTO AN UNEVEN GROUND SURFACE AND SPRAINED LIGAMENTS IN HIS RIGHT KNEE.NOTE: EMPLOYEE DID NOT WANT TO SEE DOCTOR UNTIL THE DAY AFTER THE ACCIDENT ACCIDENT DAY 10-25-89 DOCTOR TREATMENT AND THIS REPORT 10-26-89.

EMPL CLEANING OFF TOP OF WIRE CLOTH SCREENS ON C #3 & 4 USING HOE TYPE CLEANING BAR.EMPL HT LEFT HAND AGAINST SIDE PLAT FRAME AND BROKE MIDDLE FINGER ON LEFT HAND.TOLD SUPV FOLLOWING MONDAY-9- 25-89 AND WAS SENT TO DR TO EXAMINE.WAS WEARING PROTECTIVE GLOVES AT TIME OF ACCIDENT./

EMPLOYEE WAS DRIVING COMPANY TRUCK WHEN A BEE STUNG HIM ON THE UPPER INSIDE OF THE EMPLOYEES LEFT ARM.THE EMPLOYEE REQUESTED TO HAVE THE STING TREATED THE NEXT DAY BECAUSE IT WAS BADLY SWOLLEN AND RED.

EMPLOYEE WAS DESCENDING OFF CLAMSHELL CRANE TO GROUND. EMPLOYEE CLAIMS THAT WHILE HE WAS CLIMBING-DOWN RIG HE TWISTED HIS RIGHT KNEE. EMPLOYEE REPORTED ACCIDENT TO SUPERVISOR THREE DAYS AFTER ACCIDENT. HE DID NOT WANT TO SEE DOCTOR AT THAT TIME. KNEE STILL PAINFUL AND EMPLOYEE GOING TO DOCTOR ON MONDAY,JUNE 5TH, 1989.

EMPL ON PIT HOPPER WATERING MACTERIAL WHEN BITYTEN BY WASP.

EMPLOYEE WAS SITTING IN DRIVERS SEAT ON TEREX HAUL TRUCK WAITING FOR 7-YARD DRAGLINE TO LOAD HAUL TRUCK.THE DRAGLINE BUCKET STRUCK THE TOP OF THE HAUL TRUCK DUMP BOX WHEN THE DRAGLINE OPERATOR DUMPRED THE BUCKET THAT THE TRUCK DRIVER BOUNCED IN HIS SEAT AND HIT HIS ELBOW AGAINST THE SIDE OF THE DOOR WINDOW HANDLE BRUISING SAME.LATER DIAGNOSED AS BONE CHIP IN LEFT ELBOW.

EMP CLAINS THAT3WHILE HE WAS BREAKING A STEEL BAND ON WOOD PARTS CRATE WITH A CHISEL HAMMER A PIECE OF STEEL SLIVER ENTERED TOP OF MIDDLE FINGE ON RT HAND. EMP THOUGHT HE HAD REMOVED ALL OF T THE SLIVER BUT 2IS FINGER BECAME SORE 2 WEEKS LATER AND X RAYS HOWED A PIECE OF STEEL STILL EMBEDDED IN FINGER. ACCIDENT OCCURRED 12 21 87

EMPLOYEE NOT PO8ITIVE JUST WHEN HE GOT PIECE OF FOREIGN MATTER IN LEFT EYE BELIEVES IT WAS WHEN HE WAS WASHING DOWN AROUND THE CR ROCK SCREENING AREA EMPLOYEE WASHED OUT EYE SAME AM REPORTED INCIDENT FOLLO4ING TUESDAY TO SUPERVISOR WHEN HE FELT THERE WAS STILL MATTER IN EYE WENT TO DR 12-8-87 UNABLE TO FIND ANYTHING IN EYE WENT OT DR FOLLOWING FRIDAY 12-11-87 AND FOUND MINUTE PA

UPON DESCENDING3LADDER THREE RUNG FROM CATWALK TO GROUND ON MANITOWOC DRAGLINE THE EMPLOYEE CLAIMS THAT HE LOST HIS BALANCE. EMPLOYEE GRABBED OUT AND CAUGHT HOLD OF FOOT RAILING ON BOTTOM OF C ATWALK AND CUT 7HE PALM OF HIS RIGHT HAND ON SHARP CORNER OF THE FOOT RAILING ON BOTTOM OF CATWALK AND CUT THE PALM OF HIS RIGHT HAND ON SHARP CORNER OF THE FOOT RAILING. LACERATION APPROX. O

EMPLOYEE CLAIMS3THAT WHILE HE WAS CLEANING OFF THE DEW ON THE WINDSHIELD AND MIRROWS ON FRONT-ENTO KEEP FROM FALLING AND TWISTED RIGHT SHOULDER AND LOWER LEFT BACK.

AFTER PLACING C6TTING ENDGES INSIDE OF LOADER BUCKET THE EMPLOYEE SIGNALED THE OPERATOR TO LIFT THE FRONT-END OF THE BUCKET SO THAT THE EDGES WOULD NOT FALL OUT. THE BUCKET WAS RESTING ON CURV ED STEEL LINER 1LATES AND AS THE BUCKET WAS TIPPED UPWARDS THE STEEL PLATES WERE FORCED DOWNWARDS AND CAUGHT THE EMPLOYEES TOES ON HIS LEFT FOOT AND FRACTURED THE LITTLE TOE. EMPLOYEE WAS STA

EMPLOYEE REPAIN1 ON U0 WATER JET PUMP AND PIPE FITTINGS. EMPLOYEE CLAIMS HE STRUCK HIMSELF ON THE RIGHT THUMB WITH A HAMMER. X RAYS SHOWED FRACTURE OF TIP OF RIGHT THUMB. ALSO MAY LOOSE THUMB NAIL. 3