Buscar en el registro

The employee was using a scraper to clean ash from the sidewalls of a damper when EE slipped and crushed EE's finger along the side of the firing hood. The employee suffered a laceration along with a fractured left ring finger tip.

Employee was using a two long pry bars to clean out a plugged transfer chute. Employee's left finger was pinched between the 2 pry bars causing a laceration that required 8 stitches.

Employee was pulling ash with the chunk puller and his left hand was pinched between an i-beam and the chunk puller causing a hand contusion with hematoma.

Employee was pulling the ash can up with a hoist to empty the can. While employee was holding the chain to guide the ash can his thumb ran into the pulley. Employee's right thumb was cut and bruised.

Employee was loading boxcar and while cutting some cardboard he cut left middle finger. Received 2 stitches.

Employee was raking ash on the #1 kiln floor when he strained his groin muscle.

Employee was pulling ash with ash puller and roller rest from the grates using the front pulling door. Employee struck his right hand against a burner pipe joint. The right little finger (pinky) is bruised and sore. Employee did seek medical attention on 1/30/07.

Employee was attempting to clear a bagger spout with a metal rod. While checking to see if spout was open, hydrated lime shot out of spout. The lime deflected off the cross member of the seat causing some lime to get into employee's left eye. Employee flushed eye out but after 45 minutes it still was bothering him. E'ee went to emergency room.

Employee was using a prybar to pull off grates. Prybar slipped and hit employee on his chest and left side. Caused bruising and cuts to his chest. Em'ee started work the night of 10/18 at 6:30 p.m.

EE was raking chunks of coal, while raking chujmks he twisted his back to toss chunks into a barrel. Ee felt pain in his lower back.

EE WAS USING A UTILITY KNIFE TO CUT THROUGH AN AIR HOSE ON A RAILCAR. HE WAS PULLING THE KNIFE TOWARDS HIM; THE KNIFE SLIPPED OFF THE HOSE & STRUCK HIS LEFT INDEX FINGER. EE WAS WEARING GLOVES BUT THE KNIFE CUT THROUGH THE GLOVE & CUT HIS FINGER. EE DID SEEK MEDICAL ATTENTION; "SUPER GLUE" WAS USED TO SEAL THE WOUND.

Ee was attempting to dislodge a chunk of lime from the bottom of a baghouse. The hot dust that was hung up poured out onto his left boot. The extreme temperature of the dust caused the boot leather to become burning hot. The heated leather caused burns to his left foot. Ee did seek medical attention on 10-16-04.

EE WAS REMOVING ASH RING FROM #2 KILN WITH A CHISEL. A PIECE OF ASH WENT INTO HIS LEFT EYE. EE DID RISNSE HIS EYE. AFTER A FEW DAYS, HE NOTICED THE EYE WAS STILL RED AND SORE. ON 5-14-04 HE DECIDED TO GET MEDICAL ATTENTION. HE RECEIVED THREE PRESCRIPTIONS.

EMPLOYEE WAS ATTEMPTING TO OPEN THE SLIDE PLATE ON THE GROUND LIME SCREW CONVEYOR. HE WAS POUNDING ON THE PLATE WITH A HAMMER WHEN IT CAME LOOSE CAUSING A BURST OF LIME DUST. LIME DUST GOT INT O BOTH EYES. EMPLOYEE IMMEDIATELY FLUSHED HIS EYES. HE DID SEEK MEDICAL ATTENTION.

EE WAS ATTEMPTING TO BREAK THE MERRICK AIRLOCK WITH THE CHAIN STILL ON. HE WAS USING A PIPE WRENCH, HIS RIGHT HAND SLIPPED OFF THE PIPE WRENCH. THIS ACTION CAUSED HIM TO SMASH HIS RIGHT MIDDLE FINGER. HE RECEIVED A SMALL CUT BELOW THE NAIL AND MASSIVE BRUISING OF THE NAIL.

EE WAS IN THE PROCESS OF "KNOCKING DOWN" KILN ASH. EE TRIPPED OVER AN ASH PILE: HIS LEFT KNEE WAS OVEREXTENDED. MEDICAL ATTENTION WAS RECEIVED.

EE WAS SWEEPING THE PREHEATER FLOOR WITH A BROOM. DUST AND DEBRIS ENTERED HIS RIGHT EYE.

EE WAS USING A UTILITY KNIFE WHILE UNTYING BULK BAGS. WHILE CUTTING THE INSTIDE STRAP, HE CUT HIS LEFT INDEX FINGER. THE CUT REQUIRED STITCHES.

EE WAS USING A SLEDGE HAMMER TO BREAK UP A PIECE OF KILN ASH. WHEN THE HAMMER FACE CONTACTED WITH THE PIECE OF ASH, THE EE FELT SOMETHING POP IN HIS LEFT WRIST AND FELT PAIN.

EMPLOYEE WAS SHOVELING LIME FROM THE HYDRATE ELEVATOR PIT. WHILE SHOVELING, EMPLOYEE FELT A PAIN IN THE LOWER MIDDLE BACK.

EMPLOYEE WAS TIGHTENING A CHAIN COME-ALONG TO REMOVE A COOLER PIPE FROM KILN #2 COOLER. THE COOLER PIPE CLAMP JAW BROKE. THE CLAMP FLEW BACK AND STRUCK EMPLOYEE IN THE LEFT SIDE OF HIS ABDOMEN . EMPLOYEE WENT TO THE EMERGENCY ROOM. CAT SCAN PERFORMED AND MEDICATION PRESCRIBED.

EE WAS PULLING ASH CHUNKS WITH A RAKE. HE NOTICED BACK PAIN. EE WENT TO THE DOCTOR ON 5-18-01.

EMPLOYEE WAS WORKING IN KILN #2 CLEANING OUT STONE AND ASH. HE WA SPULLING A RAKE THROUGHOUT THE DAY. HE FELT OKAY AT 2:30 PM WHEN HIS SHIFT ENDED. FRIDAY MORNING WHEN HE AWOKE, HIS RIGHT SIDE , LOWER BACK MID SECTION AND RIGHT SHOULDER WEREVERY SORE AND STIFF.

EES WERE RAKING ASH FROM KILN #2 GRATES; ASH DUST WENT INTO EE'S EYES.

EES WERE RAKING ASH FROM KILN #2 GRATES; ASH DUST WENT INTO EE'S EYES.

WHILE AN EMPLOYEE AND THE INJURED WERE LOOSENING UP THE BOTTOM PLATE ON THE MIXER BOX WITH THE VISE GRIPS, INJURED GOT THE PLATE LOOSE AND THE PRESSURE RELEASED OUT AND THE VISE GRIPS FLEW BAC K AND HIT INJURED IN THE LEFT HAND PALM AREA BY THE THUMB, DEEPLY CUTTING HIS LEFT PALM AREA BELOW THE THUMB, STTITCHES WERE GIVEN.

WHILE EMPLOYEE WAS USING A TIN SNIPS TO CUT THE METAL BANDING ON THE BOXCAR, THE METAL BAND AFTER BEING CUT SNAPPED UP AND CAUGHT INJURED IN THE RIGHT HAND ON TOP OF THE THUMB AREA CAUSING A D DEP CUT. HE REQUIRED 6 STITCHES TO THIS AREA.

EMPLOYEE WA HELPING CLEAN OUT THE GRADING ON THEDOUBLE BELL DECK. WHILE POUNDING THE ROCK THROUGH THE TRADING, A STONE CAME UP. THIS STONE STRUCK THE EMPLOYEE'S MOUTH CAUSING IT TO BLEED. HIS FRONT TEETH WERE CHIPPED ALSO.

WHILE EE WAS CUTTING A PIECE OF HOSE, THE UTILITY KNIFE SLIPPED THROUGH THE HOSE AND CUT HIS RIGHT HAND INDEX FINGER. HE IMMEDIATELY WENT TO A MEDICAL FACILITY AND RECEIVED 6 STITCHES.

EE WAS PULLING ASH CHUNKS FROM THE COOLER GRATESWITH A CHUNK PULLER. THE PULLER GOT STUCK IN THEGRATE, CAUSING EE TO USE CONSIDERABLE FORCE TO REMOVE4 THE CHUNKS

EE LOADED A BULT TRK ON 3/15/99-WHILE POUNDING WITH A SLEDGE HAMMER THE EE FELT A SHARP PAIN IN HIS RIGHT SHOULDER PAIN PROGRESSED THRU OUT THE DAY. PAIN HAS BEEN PRESENT SINCE ACCIDENT OF 2/17/99

EE WAS KNOCKING DOWN LIME AND ASH IN THE #2 KILN, WHEN SOME LIME DUST AND CHUNKLS FELL BEHIND HS SAFETY GLASSES AND WENT INTO HIS EYES. HIS EYE WERE FLUSHED WITH SALIN SOLUTION AND HE DID SEEK MEDICAL ATTENTION.

IT IS ALLEGED THAT WHIEL POUNDING ON THE DUST BIN WITH A 3-4 POUND HAMMER, THE HANDLE BROKE ON THE HAMMER. EE'S RIGHT HAND CAME IN CONTACT WITH THE SIDE OF THE DUST BIN.

EE WAS REPAIRING THE MORTAR BAGGER 2, AND WHEN HE WAS CUTTING THE NYLON STRAP OFF THE HOSE ON THE 2 BAGGER IN THE MORTAR PLANT THE UTILITY KNIFE HE WAS USING CUT HIS RIGHT THUMB KNUCKLE.

ALLEGED THAT WHILE SITTING ON THE REJECT SCREW CONVEYOR AND TIGHTENING THE BOLTS WITH A RATCHET AND SOCKET HE FELT A SMALL PAIN IN HIS LOWER STOMACH AREA WHEN HE HAD FINISHED. AFTER HE ATE LUN CH THE PAIN BECAME SEVERE. HE WENT TO URGENT CARE IN FOND DU LOAC THAT NIGHT AND THE DR. SAID ITMAY BE A PULLED MUSCLE. HE ALSO USED PIPE WRENCHTO TURN CONVEYOR & INJ. COULD HAVE OCCURRED THE

WHILE USING A KNIFE TO CUT THE CORE OUT OF A CABBAGE, THE KNIFE GOT STUCK SO HE APPLIE MORE PRESSURE CAUSING THE KNIFE TO CUT THROUGH THE CABBAGE AND CUT THE AREA BETWEEN HIS THUMB AND FIRST F INGER ON HIS LEFT HAND. HE IMMED CALLED THE SUPERVISOR AND HE WAS TAKEN TO THE ER FOR HIS INJURY. REQUIRED 5 STITCHES. EE EATS LUNCH DURING WORK.

WHILE POUNDING IN THE TABLE FEEDER ARM PIN, A PIECE OF METAL FLEW OFF AND IMBEDDED IN HIS RIGHT NIPPLE AREA.

THE COAL MILL AIRLOCK STOPPED AND HE USED A METAL BAR TO BREAK LOOSE THE COAL AND HE GOT HIS FINGER SMASHED BETWEEN THE BAR AND THE METAL STICKIN GOUT OF THE COAL MILL. HE WAS ALSO WEARING WE LDING GLOVES WHEN DOING THIS. LEFT INDEX FINGER AND KNUCKLE WAS BROKEN.

EE WENT DOWN IN THE PIT AREA TO POKE LOOSE THE LIME IN THE TANK. AS IT RELEASED, LIME SHOT INTO HIS FACE AND GOT IN HIS EYES.

WHILE CLEANING THE FEED CHUTE ON KILN #1, EMPLOYEE CAUGHT FINGER BETWEEN PIPE AND METAL DOOR OPENING.

EE WAS BREAKING DOWN A RING OF ASH THAT WAS BUILT UP IN THE LIME KILN. WHILE USING A CROWBAR TO BREAK A PIECE OVERHEAD, LIME POWDER FELL INTO HIS RIGHT EYE. THE POWDER CAUSED SEVERE BURNS TO T HIS EYE. EE WAS TAKEN FROMT HE HOSPITAL TO A SPECIALIST.

WHILE USING A UTILITY KNIFE TO CUT STRING ON A BULK BAG, HIS HAND SLIPPED & HE CUT HIS OTHER HAND JUST BELOW THE SMALL FINGER.

EMPLOYEE WAS POUNDING RAM PINS OUT WHILE IN A KNEELING POSITION. HE COULD NOT INITIALLY WALK THE NEXT DAY WHEN HE GOT OUT OF BED. HE DID NOT SEEK MEDICAL ATTENTION UNTIL 12/7/94.

HE WAS TRYING TO UNPLUG THE CHUTE THAT RUNS FROM THE GRINDER SCREW TO THE ELEVATOR. HE WAS USING A BAR TO TRY TO CLEAN THE CHUTE. WHILE POKING INTO THE CHUTE, THE BAR GOT CAUGHT ON A BUCKET AN D JAMMED HIS FINGER BETWEEN THE BAR AND HOUSING OF THE SCREW.

WHILE CHISELING OUT ASH RING INSIDE OF KILN THE ASH RING BROKE OFF & FELL ON EE BACK ALSO THE ASH CAUSED A RASH ON HIS BACK LATER ON IN THE MORNING HIS BACK BECAME STIFF & SORE

EMPLOYEE WAS USING A CROWBAR TO LOOSEN STONE THAT WAS FROZEN ONTO THE ELEVATOR SHAFT. A PIECE BROKE OFF & THE CROWBAR CAME ABOUT & HIT HIM ON LTHE LEG BY HIS KNEE.

WHILE INJURED WAS HOISTING A PIECE OF REVERSE AIR FAN DUCTING AROUND AND OVER FRAME OF THE CATWALK, HIS HAND WAS SMASHED WHEN SLACK IN THE ROPE LET GO AND CAUSED THE DUCTING TO DROP 4". IT PINCHED HIS RIGHT HAND BETWEEN THE DUCT AND THE CATWALK FRAME.

EMPLOYEE WAS POUNDING WITH A MAUL ON THE LONG BELT SCRAPER CHUTE HE FELT A PAIN IN HIS UPPER LEFT SIDE OF BACK

EMPLOYEE WAS USING RUBBER HAMMER TO POUND BAGGER BIN. W HILE POUNDING BIN, HIS RIGHT WRIST BEGAN TO HURT.

EMPL POUNDING ON BAGGER CHUTE WHEN RUBBER HAMMER SLIPPED THROUGH GRIP.RIGHT SIDE OF RIGHT HAND HIT AGAINST BOTTOM EDGE OF CHUTE.