Buscar en el registro

WHILE TIGHTENING THE NUTS THAT HOLD THE OUTER DOOR ON MILL HOUSING, THE 18"CRESENT WRENCH SLIPPED CAUSING THE WRENCH TO PINCH HIS FINGER AGAINST THE CONCRETE PILLAR.

AS THE EMPLOYEE WAS WALKING THROUGH THE SHIPPING DEPT THROUGH PALLETS THAT WERE PLACED NEAR THE DOOR, THE EMPLOYEE'S RIGHT FOOT GOT CAUGHT UNDER A PALLET CAUSING THE EMPLOYEE TO TRIP. THE RIGH T FOOT NEVER MOVED DURING THE FALL.

CLIMBING DOWN LADDER KNEE GAVE WAY AND FELT SHARP PAIN IN RIGHT KNEE.

WHILE GETTING READY TO FIRE UP KILN #1 ON OIL. CHANGING KILN #1 FROM GAS TO OIL, SMOKE FROM THE OIL GOT IN KILN #1. WHEN IT LIT IT BLEW BACK ON THE EE'S LEFT HAND.

WHILE CUTTING PIPE FOR DISCHARGE WATER LINE ON #2 SCRUBBER, WHEN GETTING PIPE IN PLACE THE PIPE SLIPPED PINNING FINGER BETWEEN CONCRETE PILLOW & PIPE.

EMPLOYEE WAS PULLING A 3-15/16" BEARING HOUSING UP TO THE TOP OF C-1 WITH A 1/4" ROPE BY HAND. THE ROPE SLIPPED OUT OF HIS HAND. REGRABBING THE ROPE CAUSED TENSION TO THE BACK MUSCLES.

THE EE WAS ABOUT TO ADJUST CONTROLS ON MOBILE GENERATOR WHEN A WASP NESTLING 1FT FROM CONTROL PANEL. SPRAY WAS APPLIED WAS BEGAN TO FLY EE RAN SAND SLIPPED IN THE MUD LANDING ON FACE & RIGHT SHOULDER

WHILE CARRYING HYDROLIC JACK TO KILN #2 STEPPED OUT OF THE SCOPPLES DOOR WHILE IT WAS RAINING FEEL SLIPPED OUT FROM UNDER THE EE LOST BALANCE HYDRALIC JACK FELL ON LEFT KNEE.

While returning from the shipping office back to the main office. ee while coming down a set of strairs got her heel on ther top step causing her to loose balance and fall. fractured left wais t

WHILE SPRAYING SLIDE RODS THE PRIMARY PUSHER STARTED ITS CYCLE, REMOVED HAND HITTING ARM ABOVE THE ELBOW CAUSING A PUNCTURE.

EE NEEDED TO REFMOVE 20 SLIP COVER FROM PALLET THAT WAS BEHIND ANOTHER PALLET, INSTEAD RMOVING THE PALLET IN FRONT HE HE DECIDED TO CRAWL OVER THE PALLET TO GET SLIP COVERS. ONCE HE GOT THE SL IPP COVERA AND STABLED CLIMB BACK OVER THE FRONTPALLET HE LOST HIS FOOTING AND FELL TO FLOOR.

WHILE REPLACING A BROKEN BAG FROM A PALLET BEING LOADED ON A TRUCK, EE REPORTED A SHARP PAIN GOING THROUGH HIS SHOULDER WHICH HAD BEEN INJURED ON THE JOB IN 1985. SURGERY ON 1/7/02.

WHILE WALKING TO A WORK STATION THE EE STAPPEN ON UNEVEN GROUND AND TUNNEL HIS LEFT ANKLE. THIS WAS RECOCURRENACE OF AHN NEUTRAL FROM 1999.

AT AROUND 9:00PM ON 10/13/00 ONE SECTION OF A UHMW LINER CAME OUT OF HP3 (CLAY HOPPER). THIS PLASTIC SHEET WAS PLACED ON THE FLOOR TO THE EAST OF THE CONTROL ROOM. AFTER HAVING PROBLEMS WITH THE FULLER DRYER ALL NIGHT THE OPERATOR WENT OUTTO FIRE THE DRYER AT 5:30AM. WHILE ROUNDING THE CORNER OF THE CONTROL ROOM, HE TRIPPED ON THE PLASTIC & FELL LANDING FACE FIRST ON THE CONCRETE.

EE WAS RCLEANING OUT CHUTE, HE REACHED TO PUSH THE GUARD FROM THE BELT AND PULLEY AND INGDRIENTENTLY GRABBED THE BELT AND THICK PULLED HIS HAND INTO THE SHEAVE, PINCHING AND RATTING HIS INDEX FINGER.

EE WAS TRYING TO STOP A LEAKING SCREW (SC47). HE TOOK A PIECE OF WET CLAY TO TRY TO PLUG THE HOLE WHEN HE INADVERTANTLY STUCK HIS FINGER IN SAID HOLE CUTTING THE TIP OFF.

EMPLOYEE WAS LIFTING A 40 POUND OF ADDITIVE TO PLACE IN FEEDER AT START OF HIS SHIFT. WHEN BAG WAS PARTIALLY EMPTY, THE BAG SLIPPED AND HE FELT PAIN IN HIS LOWER BACK WHEN REACHING TO CATCH TH E BAG. MUSCLE STRAIN. CHECKED BY A DOCTOR.

EMPLOYEE OPENED DOOR ON #5 R/M AND CAUGHT HIS FINGER BETWEEN MILL DOOR AND BEAM. EMPLOYEE CUT HIS INDEX FINGER ON LEFT HAND, WHICH REQUIRED STITCHES.

MECHANIC WAS REMOVING KILN ACCESS DOOR AND DROPPED IT ON TOP OF FOOT ABOVE STEEL TOE. FOOT BRUISED. XRAYS NEGATIVE. NO LOST TIME.

EE WAS LIFTING AN EMPTY WOODEN PALLET FROM STACKONE HAND SLIPPED OFF AND PALLET MASHED 3RD FINGER OF RIGHT HAND AGAINST PALLET BELOW LACERATION REQURING STITCHES. OPERABLE FORKLIFT PARKED 20'AWAY

EE WAS CLEANING A DOWN SPO9UT WITH A POKE ROD. CLAY FELL ON THE ROD CAUSING EE TO CUT HIS HAND ON THE METAL DOWN SPOUT.

EMPLOYEES WERE VACUUMING OUT HOPPER CAR. HE WAS STANDING ON LADDER INSIDE CAR SHOVELING CLAY OFF SIDES OF CAR. HE ASKED EE TO TELL ANOTHER EE TO SHUT OFF VACUUM. I.NAME COULD NOT HEAR HIM SO H E WENT DOWN AND SHUT OFF VACUUM HIMSELF. HE IMMEDIATELY WENT BACK UP ON TOP OF CAR TO CHECK ON FRANK. HE COULD NOT SEE HIM. THE CLAY HAD CAVED IN ON TOP OF HIM: HE COULD ONLY SEE HIS LANYARD.

EE WAS CLIMBING DOWN THE CAR LADDER TO LET THE CAR DOWN TO THE NEXT SECTION. HE SLIPPED & CUT HIS ARM ON TOP OF THE FLOOR RAIL.

EE TRIPPED & BIT TOP LIP SEVERE ENOUGHT TO REQUIRE SUTURES.

CRANE BOOM FAILED WHILE HOISTING SUSPENDED LOAD APPROX. 3 FT ABOVE GROUND. LOAD STRUCK EE AND KNOCKED HIM TO GROUND CAUSING INJURIES.

SLIPPED ON STAIRS AT TOOL SHED FELL AND LANDED ON HIS BACK.

EMLLOYEE WAS REMOVING AN AIRLOCK & PIPE A PIECE OF PIPE BECAME LOSOE AND FELL ON THE EMPLOYEE'S FINGER.

EE WAS ON THE LOADER MOVING RAILCARS THE LOADER WAS JOLTED AND HE STRUCK HIS KNEE.

EMPLOYEE WAS MOVING PUMP. HE HAD PLACED CHAIN AROUND THE PUMP AND WAS LOOPING THE CHAIN AROUND BUCKET TEETH OF THE BACKHOE BACKHOE OEPRATOR LIFTED PUMP TO MOVE IT TO ANOTHER LOCATION.

EE WAS POKING WET CLAY FROM PLANT 1 LIEN. HE WAS COMING DOWN FROM THE WALKWAY AND SLIPPED PULLING STRAINING HIS SHOULDER.

EE WAS POKING CLAY CLAY IN PLANT #1 FEED BIN USING A LONG ROD. HE REACHED TO GET THE ROD AND TWISTED HIS BACK.

EE WAS TRYING TO SET BRAKES ON A HOPPERCAR. WHEN HE SLIPPED OFF RAILCAR.

EE WAS STACKING 40# BAGS OF PRODUCT. HE REACHED FOR A BAG WITH A TWISTING MOTION & FELT PAIN IN LOWER RIGHT BACK. STRAINED BACK REQUIRING 3 DAYS LIMITED DUTY.

EE SET A WATER COOLER ON THE FLOOR. WHEN HE BENT OVER HE WAS UNABLE TO STRAIGHTEN UP.

EE WAS STACKING 50 BAGS AND STRAINED HIS BACK.

EMPLOYEE WAS HAVING CHEST PAIN AND DIFFICULTY BREATHING.

EE WAS TURNING CAR WASH HEAD AND EXPERIENCED A PAIN IN HER BACK.

EE WAS RUSHING TO REMOVE BUILDUP OF MATERIAL & BUMPED CONVEYOR STEEL WORK KNOCKING OFF HARD HAT. WHEN RETRIEVING HAT, HE BUMPED OTHER STEEL WORK CAUSING LACERATION TO SCALP. SUTURES REQUIRED. RETURNED TO NORMAL WORK BEFORE END OF SHIFT.

EMP WAS WALKING DOWN STEPS AND STEPPED INTO A PILE OF CLAY AT THE BOTTOM OF THE STEPS. A ROCK WAS IN THE CLAY AND ROLLED WHEN HE STEPPED ON IT.

EMPLOYEE WAS STANDING IN WORK AREA TALKIGN WITH LEADPERSON AND WAS STRUCK BY MOVING FORKLIFT CAUSING BRUISES AND SOFT TISSUE DAMAGE TO RIGHT FOOT. X-RAYS NEGATIVE.

THE EMPLOYEE WAS REMOVING SHAFT FROM THE ROLLER MILL WHIZZER. HIS THUMB BECAME CAUGHT BETWEEN THE SHAFT AND HOUSINGS.

EE WAS LIFTING EQUIPMENT ONTO A PALLET WITH ANOTHER EE. THE OTHER EE PUT HIS END DOWN SUDDEN AND DECISION EE S HAND WAS CAUGHT UNDERNEATH.

EE WAS ROLLING BELT ONTO SHEAVE TO ADJUST THE MOTOR MOUNT. HIS FINGER WAS PULLED BETWEEN THE BELT & THE SHEAVE.

EMPLOYEE SLIPPED ON ICE AND FELL INTO A RAILCAR HATCH DOOR OPENING. THE FALL CAUSED HIM TO SLAM HIS CHEST INTO THE SIDE OF THE DOOR CAUSING BRUISED RIBS.

EMPLOYEE WAS CHECKING ON THE FLOW OF CLAY IN BIN UNDER THE SHED. IT WAS WET AND MUDDY UNDER THE SHED AND THE EMPLOYEE SLIPPED AND FELL SUSTAINING A BRUISED HIP AND INJURED BACK.

THE EE WAS RE-HANGING THE PLANT #2 CAGE MILL DUST COLLECTOR. THIS REQUIRED LIFTING & PULLING FROM FLOOR LEVEL.

THE EMPLOYEE WAS OPERATING THE BRAKE ON A RAILCAR. WHILE DOING THE WORK, HE NOTICED A POP IN HIS SHOULDER AND PAIN.

EE WAS PICKING UP A DRUM OF GREASE, WEIGHING 120 LBS. HE PULLED A MUSCLE IN HIS CHEST.

THE EE WAS DRIVING A FORKLIFT & A HYDRAULIC HOSEBROKE, CAUSING HYDRAULIC FLUID TO GET INTO THE EE'S LEFT EYE.

THE EE WAS FILLING SUPERSACKS & HIS FINGERS BECAME CAUGHT BETWEEN THE FORKLIFT BLADES & THE SUPERSACK LOOPS. THE FORKLIFT DRIVER RAISED THE FORKS BEFORE THE EE STOOD UP CAUSING HIS FINGER TO B E SMASHED.