Kosse Plant Metal/Non-Metal

EE missed a step and felt a pop and twist in his knee when he landed. EE refused to seek medical treatment at the time. I received documentation of EE's treatment and restrictions on 12/1, which, at that time, made it reportable. Upon further investigation, I will determine if EE's absence during this time is a result of his injury.

Employee became ill and was subsequently transported to Limestone Medical Center

Silicosis diagnosis

Employee was descending a fixed ladder when he slipped and fell. Fall resulted in broken bones (heel, rib, scapula, vertebrea). Impairment level is unknown.

Employee was using a pipe to unplug the silo when he jammed the palm of his right hand on the pipe, causing a contusion which eventually became infected and swollen. Approximately seven days after the accident, the employee punctured the swelling to relieve the pressure and the puncture became infected. Therapy for wound care was done: debridement of the skin.

Employee was preparing to wash down the scale aisle. He bent over to pick up water hose and got a sharp pain down the right side of his back.

EE was pulling a pallet by hand when it hung on a nail causing the EE to jerk his neck, shoulder, and arm resulting in a strain.

Employee was getting off forklift when his foot got stuck on the step and he stumbled and hurt his right knee.

EE was replacing 1b baver mill when he attempted to reposition the rotor. The rotor shifted and caught his left hand between the mill housing and rotor.

EE WAS REMOVING 2X2 FT DOOR FROM NORTH DUST HOPPER ON GMD DUST COLLECTOR AT CALCINE BUILDING. WHEN LAST BOLT WAS REMOVED DUST POURED OUT DOOR & PUSHED DOOR ASIDE. EE TURNED TO MOVE OUT OF THE WAY AND HIS FOOT CAUGHT AGAINST THE PLATFORM TOEPLATE, TWISTING HIS KNEE.

EE WAS TRYING TO UNPLUG A PIPE ON THE HUMMER SCREEN DRAIN WHEN HIS RIGHT FOOT SLIPPED OFF THE PIPE. AS HE TRIED TO CATCH HIMSELF, HE BENT TOO FAR ON HIS KNEE.

WHILE UNPLUGGING A PIPE, HE IMPROPERLY LIFTED IT AND FELT PAIN IN RIGHT GROIN AREA RESULTING IN HERNIA.

EE WAS STANDING ON THE INCLINDED GRATING ON THE SOUTH SIDE OF THE TRASH SCREEN AND WAS PUSHING BUILDUP FROM THE SCREEN DOWN TO THE CHUTE WITH ASHOVEL. AS HE PUSHED HE LOST HIS BALANCE & FELL FORWARD & SIDEWAYS DOWN THE SLOPE. HE LANDED ON HIS SIDE ON AN INCLINED SECTION OF GRATING WITH HIS HEAD DOWNHILL, SPRAINING & BRUISING HIS RIBS& BACK.

EE SEVERED HIS RIGHT INDEX FINGER AT THE HAND KNUCKLE WHILE ATTEMPTING TO GREASE THE NORTH HEAD PULLY ON THE MAIN ORE BELT. A PIECE OF HEAD PULLEY LAGGING HAD SLID NORTH 3-4" AS ONE OF THE HOL D DOWN CLIPS HAD BROKEN THE END OF THE LAGGING WAS BENT ON 1 CORNER IN A HOOK FASHION AS THE EEATTEMPTED TO INSTALL THE GREASE GUN LINE ON THE BEARING FITTING THE LAGGING SNAGGED HIS COTTON G

EE AND ANOTHER EE WERE CHANGING OUT ATTRITION CELL IMPELLERS. THIS REQUIRES LIFTING, PULLING, AND TUGGING. LATER IN THE DAY, HIS BACK BECAME SORE.

EMPLOYEE WAS TRYING TO PLUG UP A WATER PUMP TO DEWATER AN AREA, WHEN HE STEPPED IN A HOLE. HE TRIED TO JERK HIS FOOT OUT OF THE HOLE AND IN DOING THIS, HE FELT A BURNING SENSATION IN HIS LOWER BACK.

EE WAS WORKING IN THE SCALE AISLE CHANGING BUCKETS ON E-1 ELEVATOR. DUST AND CLAY HAD GOTTEN IN HIS EYES CAUSING BOTH EYES TO SWELL (RIGHT ONE MORE SO THAN THE LEFT).