Avant Mine Metal/Non-Metal

Employee was using wrench to loosen bolt on piece of equipment. When bolt broke loose, employee's hand slipped. Left ring finger was cut on piece of metal. Finger required 4 stitched.

Dump truck was having brake problems. Driver parked truck on the road next to the oil shed for the diesel mechanic to inspect. The mechanic crawled underneath the truck to inspect brakes. As he was backing out from the truck, the side wall of the front inner tire on the driver's side blew out. It caused cuts & swelling to the face, eyes & right hand & hand is broken.

EE WAS USING AN ACETYLENE TORCH TO REPAIR HANDRAILS ON A MUD CAT DREDGE. A CAN OF ETHER BASED STARTER FLUID WAS CONTACTED BY THE TORCH OR A SPARK RUPTURED AND FLASH BURNED THE EE HANDS, ARMS AND FACE

EE THOUGHT THE CLASSIFIER REJECT LINE WAS "STOPPED UP". EE PROCEDED TO INSERT RIGHT GLOVED HAND UP A PIPE ATTACHED TO A ROTOR LOCK THAT WAS NOT LOCKED OUT. THE TIPS OF THE 3 MIDDLE FINGERS WERE CUT OFF.

EE IS A PLANT OPERATOR. HE WAS HAVING PROBLEMS WITH A MILL OPERATED BY A 40 HP 480V ELECTRIC MOTOR. HE ATTEMPTED TO TURN THE MOTOR OFF WITH THE SAFETY KNIFE DISCONNECT LOCATED AT THE MOTOR IN STEAD OF USING ON/OFF SWITCH IN THE CONTROL ROOM 50'AWAY. HE APPARENTLY DISENGAGED THE KNIFE SWITCH SLOWLY RESULTING IN AN ELECTRIC ARC WHICH BLEW OUT AN INSTALLED AMP METER IN THE DOOR.

EE WAS TURNING ON A PUMP. OTHER WENT OUT THE DOOR TO SEE IF PUMP WAS TURNING WHEN THE BREAKER BOX TRIPPED AND FAILED CREATING A LOUD NOISE. THE NOISE WAS RIGHT IN FRONT OF EE CAUSING A HEADACH E LATER THAT EVENING.

EE WAS ON BASKET ON FORKLIFT, MISSTEPPED OFF, JAMMED RIGHT FOOT RESULTING IN FRACTURE.

AT THE TIME OF THE INJURY THE OPERATOR WAS ATTEMPTING TO START THE DOZER BY CROSSING OUT THE SOLENOID ON THE STARTER. THE DOZER WAS IN A REVERSE GEAR & THROTTLE OPEN, WITH SAFETY LEVER IN THE UP POSITION. THIS RESULTED IN THE OPERATOR FALLING & BEING RUN OVER BY DOZER.

THREE MEN WERE REPAIRING A DRYER FEEDER. THE FORKLIFT HUNG ON AN AUGER. HIS MIDDLE FINGER ON RIGHT HAND CAUGHT BETWEEN AUGER AND FORKLIFT. FINGER CUT IN 5 PLACES.

WHILE STEPPING DOWN FROM A 4' HIGH WORK PLATFORM, EMPLOYEE'S ANKLE TURNED FRACTURING A BONE.

EE WAS WASHING OUT BLUNGER WHEN SLIPPED & FELL & HIT GROIN AREA. EE DID NOT IMMEDIATELY REPORT INJURY

EMPLOYEE WAS CARRYING (PICKING UP) A 5 GALLON BUCKET OF LIQUID AND STRAINED HIS SHOULDER.

EE WAS HELPING TO DISCONNECT A PULL CABLE FROM AN OFF THE ROAD TRUCK WHEN THE CABLE HIT HIM IN THE MOUTH.