Nazareth Plant 2 Metal/Non-Metal

Employee was setting up job at primary crusher apron feeder. While throwing a welding lead down into the apron feeder, the employee felt a sharp pain in his shoulder and lower left arm.

Employee was moving the godwin water pump at quarry #3. As he was walking up the gravel road, he slipped on the wet gravel falling to the ground. He suffered a cut on his LT wrist which required some stitches.

Temporary EE was trying to close elevator door when he pinched his right index finger between the doors, resulting in a number of stitches.

Annual Hearing test indicates a recordable shift change (w/age correction) Employee

Employee was cleaning up the area under the head of #4 belt with the bobcat. As he was going down the ramp, a rock flew into the cab of the bobcat and hit him in left ankle area.

Employee's left hand was pinched when the flog gate fell to the side.

EE SIMPLY PULLED CAP OFF SILO TO MAKE A MEASUREMENT & EE'S NECK GOT JOLTED OUT OF ALIGNMENT.

EE WAS PUSHING A WHEELBARROW TURNED CORNER & PULLED GROIN AREA LIFT SIDE

EMPLOYEE WAS WALKING ON CATWALK AND HE STEPPED ON A CHAIN THAT WAS COVERED WITH DUST AND TWISTED RIGHT ANKLE.

EMPLOYEE WAS REMOVING THE CHAIN GUARD ON THE BRIDGE DRAG TO REPLACE THE SHEAR PIN. EMPLOYEE FELTA PULL ON THE RIGHT ARM INSIDE OF THE ELBOW.

EMPL TAPPING CEMENT AT #7 SILO AND CEMENT FLUSHED THROUGH HOLE GETTING INTO EMPL EYES.RIGHT EYE WAS IRRITATED FROM CEMENT.

EMPL WORKING IN3PREHEATER SHELF AREA WITH AIR LANCE WHILE KILN WAS DOWN FOR BRICK WORK.HIS AIR LANCE JAMMED INTO PIECE OF HARD COATING STRIKING HAND AGAINST PREHEATER.

EMPLOYEE USED H3S SWISS TYPE POCKET KNIFE WITH A THREE INCH BLADE TO CUT THE PLASTIC BAND ON THE PALLET OF BAGS KNIFE CUT THRU THE BAND SWIFTLY & WITH THE AMOUNT OF PRESSURE HE USED THE KNIFE CUT INTO HIS LE0T FOREARM

EE MASHED HIS LITTLE FINGER ON H IS LEFT HAND WITH A RAW-HIDE BRICK MALLET WHILE INSTALLING A KEY BRICK IN PLANT #1 KILN.

EMPL OPERATING TRACTOR TRAILER BETWEEN PLANTS IN EGYPTYT AND NAZARTH PA.DROVE TRACTOR TRAILER TO M.T.S. GARAGE PARKING LOT TO HAVE FLAT TIRE REPLACED ON TRAILER.ENTERING CAB,FOOT SLIPPED ON FU EL TANK TYPE STEP BUMPING KNEE AND STRIKING RIGHT HAND ON STEP.(M.T.S.-MATERIAL TRANSPORT SERVICE-LEASED TRUCKS.)

CHANGING A ROLLER ON #7 BELT LINE.EMPLOYEE WAS ALIGNING A HOLE IN THE SHAFT WITH THE HOLE IN THE CHANNEL TO PUT THE BOLT IN.EMPLOYEE WAS UNABLE TO USE THE STEEL DRIFT PIN TO ALIGN THE HOLE AN ALIGN THE HOLE AND USED HIS FINGER.THE SHAFT MOVED INJURING HIS FINGER.

THE EE HAD JUST COMPLETED SHOVELING A STONE CHOKE OFF THE RADIAL STAKER BELT. WHEN THE BELT WAS RETURNED TO T HE UNLOCKED POSITION & STARTED THE EE THOUGHT THE BELT STOPPED BECAUSE OF SPILAG HE BEGAN TO SPRAY BELT DRESSING ON THE BELT AT THE TAIL PULLEY. HE PUT HIS RIGHT HAND ON SPRAY CAN NEAR THE BELT & GOT HAND CAUGHT BETWEEN THE BELT & TROUGH IDLER.

EMPLOYEE WAS APPLYING GREASE TO THE GREASE FITTINGS ON A MANLIFT ELEVATOR SHAFT BEARINGS HE THOUGHT THAT ONE OF THE FITTINS WASNOT GETTING ANY GREASE SO HE STEPPED DOWN INTO THE PIT 36IN DEEP TO CLEAN AROUND FITTING THIS FITTING LOCATED BETWEEN THE WALL AND MANLIFT HE LOST HIS BALANCE AND REACHED FOR FRAME FOR SUPPORT HE ACCIDENTLY PULLED ON CABLE WHICH ACTIVATED START UP SWITCH ST

THE EMPLOYEE WAS OPERATING A TRACTOR TRAILER ON COMPANY PROPERTY AT PLANT #1, NAZARETH. AS HE WAS ENTERING THE CLINKER STORAGTE FIELD, A FRONT SHEEL WENT INTO A POT HOLE. THIS CAUSED THE STEE RING WHEEL TO SPIN AROUND. HIS LEFT HAND WAS STRUCK BY ONE OF THE INNER SPOKES OF THE STEERING WHEEL.

A LARGE PIECE OF CEMENT ROCK LODGED ITSELF INSIDE THE STONE CRUSHER CAUSING A CHOKE THE EMPLOYEE ALONG WITH 2 OTHER MILLWRIGHTS HAD PLACED A STEEL CABLE AROUND THE STONE SO THAT IT COULD BE M ANIPULATED INTO A POSITION TO BE BROKEN UP THE EMPLOYEE WITH THE UPPER PART OF HIS BODY REACHED INTO THE INSPECTION DOOR OF THE CRUSHER THE ROCK MOVED AND PINNED HIS BODY IN THE INSPECTION

THE EMPLOYEES RIGHT LEG WENT THROUGH THE STEEL GRIZZLEY UP TO HIS KNEE WHEN HE AND ANOTHER MILLWRIGHT, WERE MAKING A RESUE ATTEMPT TO FREE ANOTHER EMPLOYEE WHO HAD GOTTEN HIMSELF PINNED IN THE INSPECTION DOOR.