Rilite Aggregate Metal/Non-Metal

Operator with fully loaded haul truck traveled down from upper loading area, along approximately a 1,000' long haul road with an approximate 15% grade. Operator noticed a situation with the brake system on truck. As EE approached lower storage area EE was unable to stop. Operator diverted truck against stored material, contacting stored boulders, overturning dump bed and stopping.

While servicing water truck grease hose ruptured sending grease thru latex glove and injuring the right index finger.

Wind blew hard hat off employee head. While picking hard hat off the ground employee hit his head on the sand wash plant.

Loader operator slipped while descending equipment ladder, spraining right foot.

While setting steel deck plate into position, contractor lost control of plate, allowing plate to shift/slide into ladder. This sudden movement dislodged worker off ladder, individual fell approx. 6'8" to ground.

While changing out a damaged gear box, cleaning the shaft with a grinder, grinder bounced off the head pulley, kicking back and making contact with his left index finger. The incident opened a one inch gash which required 4 stitches to close.

Mechanic, after repairing /replacing screens on screen deck at old plant, had his finger (right pinky) push thru screen. Finger hit screen deck assembly and was broken. Emergency room visit was required where finger was isolated & splinted. On 7-20 surgery was performed on finger.

CLEANING PLANT AND HIT LEFT SHIN ON A LEG OF PLANT.

CUTTING BELT BAND WITH KNIFE AND CUT LEFT THUMB.

TRIPPED BACKWARDS OVER A BOARD. (NOT REPORTED UNTIL 9/16/01).

LOOKED INTO REAR VIEW MIRROR WHILE BACKING UP TRUCK WHEN WIND BLEW DIRT INTO EYE.

WHILE CHANGING BUCKET ON BOBCAT EMPLOYEE LOCKED THE LEVER IN PLACE AND BEFORE HE COULD REMOVE HIS HAND THE OPERATOR PULLED THE BUCKET BACK SMASHING HAND.

WIND BLEW DIRT INTO RIGHT EYE.

PULLING DEBRIS OUT OF MATERIAL-WHEN GETTING BACK INTO LOADER FELT PAIN IN GROIN AREA.

CLEANING YARD AND WAS STUNG BY A BEE.

WHEN LIFTING A SCREEN INTO PLACE IT SLIPPED OUT OF HAND AND FELL ON LEFT LEG CUTTING THE LEG.

CHECKING PLANT FROM CONCRETE PLATFORM--LOST FOOTING AND FELL ONTO GROUND, INJURING RIGHT ANKLE AND FOOT.

SHUTTING OFF MOTOR.

CHECKING CRUSHER SLIPPED ON A RUNG ON THE LADDER AND FELL BRUISED LEFT THIGH CHEEK AND EAR.

DRIVING WATER TURCK AROUND PIT AND HIT A HOLE. THE TRUCK WAS FULL OF WATER AND IT SHOOK VERY VIGOROUSLY. EVEN THOUGH THE DRIVER DID HAVE HIS SEATBELT ON, HE WAS STILL THROWN ABOUT THE CAB.

WAS LOOKING UNDER TRAILER TO CLEAN OFF SOME EXCESS MATERIAL. LOOKED UP AND HEAD HIT A PIECE OF EXPOSED STEEL CAUSING A LACERATION TO THE FOREHEAD.

CHANGING FILTERS ON D9 SLIPPED OFF D9 AND FELL TO GROUND.

ROCK STUCK IN JAW.

WRENCHED BACK PULLING ROCK OUT OF PRIMARY GRIZZLY

BACKING UP LOADER AND RAN INTO TRUCK AND CUT HEAD.

JUMPING FROM ONE TRAILER TO OTHER SETTING CHAINS AND TWISTED ANKLE.

KNEELING DOWN CLEANING DRAIN METAL CABLE CUT KNEE