Registro de la MSHA sobre Jonathan Limestone Mine (ID de mina 3303990). Muertes, incidentes no mortales agrupados por año, operador y controlador actuales, y contexto de la mina.
Avísenme cuando se presente un nuevo incidente de la MSHA en Jonathan Limestone Mine.
INJURED WAS USING FRONT END LOADER TO MOVE WATER AWAY FROM DRAIN, BUCKET CAUGHT RAILROAD RAIL CAUING DOOR TO OPEN & SWING BACK TO CLOSED POSITIO. DOOR HIT OPERATORS'S RIGHT ARM BRUISING ARM & SHOULDER.
INJURED WAS USING CHAIN TO REMOVE TRANSMISSION FROM D-9 DOZER. CHAIN CAME UNHOOKED AND FELL FROM CRANE HOOK, STRIKING EMPLOYEE IN BACK. TRANSMISSION WAS NOT YET HOOKED UP.
INJURED WAS USING TORCH TO CUT OFF BOLTS ON CEMENT ELEVATOR. A HOT PIECE OF METAL HIT HIM IN LEFT EAR.
EMPL WAS HELPING TO UNPLUG AIR SEPERATOR, RE- MOVED INSPECTION DOOR, CEMENT DISLODGED & SPILLED OUT DOOR HITTING EMPL IN FACE & EYES.
INJURED WAS INSTALLING DRIVE WHEEL ON CRANE, HE WAS LETTING AXLE DOWN INTO POSITION WITH CHAIN FALLS WHEN IT SPUN AROUND AND CAUGHT FINGER BE- TWEEN WHEEL AND JACK. SMASHING FINGER.
INJURED WAS USING SLEDGE TO REMOVE TRACK ROLLER FROM DOZER. WHEN HE HIT ROLLER WITH SLEDGE A PIECE OF METAL BROKE OFF AND HIT HIM IN THE FACE.
INJURED WAS PUTTING MILL LINERS ON FORKLIFT, HE STEPPED ON ANOTHER LINER AND HIS FOOT SLIPPED INJURING RIGHT LEG AND BACK.
INJURED WAS UNPLUGGING CEMENT CHUTE ON SILO CEMENT CAME LOOSE AND BLEW INTO EE EYES WAS WEARING GOGGLETS.
INJURED WAS GRINDING TEETH ON MILL GIRTH GEAR. A PIECE OF MATERIAL FLEW UNDER FACE SHIELD & STRUCK HIKM IN LEFT EYE.
INJURED WAS GETTING ON FORKLIFT, HIS FOOT SLIPPED, SCRAPED SHIN. LATER HE NOTICED INFLAMATION AROUN DIT. HE DID NOT SEEK MEDICAL ATTENTION UNTIL 2-18-93. INFLAMATION WAS DIAGNOSED AS CEMENT POSIONING
INJURED WAS INSTALLING DRIVE BELTS ON PULLEY OF GEAR REDUCER. HE WAS TURNING PULLEY BY HAND AND ROLLING BELT ONTO PULLEY. WHEN BELT WENT ON, HIS HAND SLIPPED AND WAS CAUGHT ON SHARP EDGE OF BO TTOM GUARD CUTTING LEFT HAND AND END OF LITTLE FINGER OF LEFT HAND.
INJURED WAS WELDING ON CEMENT KILN WITH ANOTHER WELDER. WHEN HE RAISED HOOD TO CHIP SLAG OFF, THE OTHER WELDER STRUCK AN ARC CAUSING FLASH BURNS TO HIS EYES.
INJURED EMPLOYEE WAS INSTALLING LINE SHAFT ON CRANE.HE WAS USING LEG TO POSITION SHAFT WHEN FOOT SLIPPED CAUSING HIM AND HIT LEG ON COUPLER BRUSING LEFT SHIN.NOTE: INJURED DID NOT SEEK MEDICAL ATTENTION UNTIL APPROX 12-16-92 HE WAS INSTRUCTED TO SEE DR ON 12-07-92.
INJURED WAS TIGHTENING BOLTS ON FVALVE & STRAINED BACK & LEFT GROIN AREA
INJURED WAS PREFORMING CLEARENCE CHECK OF KILN TRUNNION STRONG WINDS WERE PRESENT & BLEW CLINKLER DUST IN BEHING SAFETY GLASSES & INTO EYES
INJURED WAS WELDING KILN SHELL WITH OTHER EMPLOYEES; HE RECIEVED WELDING FLASH BURNS TO THE EYES.
19645D 7:45 PM A FLASH FLOOD OCCURRED ALONG SIDE OF THE #5 DRIVE PIER.THIS BUILDING HOUSES BOTH STARTERS AND CONTROL CIRCUITS FOR #5 AND #6 KILNS.WATER ROSE SOME 2'.THE LAST 10" ALLOWED WATER 36055TER THE BUILDING AND EVENTUALLY INTO #6 STARTER BOX.THE 2300 VOLT MAIN WAS PULLED TO THE ENTIRE PLANT.LOCAL FIRE DEPARTMENT CALLED.THE IRE LASTED 25-30 MINUTES.NO INJURIES OCCURRED.#6 STA
EMPLOYEE WAS HELPING TO BUILD SILO FOR FEEDER. EMPLOYEE WAS ENTERING THE CRANE WHEN HE HIT THE SIDE OF THE CRANE TRYING TO GET INTO SEAT.
95104SING CHAIN FALLS TO PICK UP VALVE. REACHED UP TO MOVE FALLS,FELT A BURNING OR STINGING SENSATION IN CHEST AND ARM. NOTE: INJ DIDNT SEEK MEDICAL ATTENTION TIL 7-27-92.
INJURED WAS REPLACING MOTOR ON CLINKLER EVELATOR. IN CARRING MOTOR TO ELEVTOR HE SLIPPED AND FELL INTO HAND RAIL BRUISING RIBS. INJURY WAS NOT REPORTED TIL 7-6-92 WHEN HE WENT TO EMEREGENCY ROOM AT HOSPITAL.
INJURED HAS WORKED OVERTIME AND HAD CLOCKED OUT HIS PERSONAL CAR WOULD NOT START DUE TO DEAD BATTERY IN THE PROCESS OF EITHER JUMPING THE BATTERY OR CHECKING THE CONNECTIONS THE BATTERY BLEW U P PUTTING ACID ON FACE AND TIN EYES.
INJURED WAS LEAVING INSIDE OF CLINKER COOLER AND TRIPPED AND FELL INTO PILE OF CLINKER. HE STRUCK RIGHT KNEE ON METAL FRAME AND LEFT FOREARM CAME IN CONTACT WITH HOT METAL CAUSING 2ND DEGREE B URNS.
INJURED WAS INSTALLING PLATES IN DUST PRECIPITATORS. WHILE LINING UP BOLT HOLES, DUST FELL FROM ABOVE AND COVERED FACE, FILLING EYES WITH DUST.
INJURED WAS CLEANING UNDER PORTABLE CRUSHER FOR MAINTENANCE TO INSTALL GUARD. HE HAD TO WORK ON KNEES BECAUSE OF LOW HEAD ROOM. IN DOING SO, HE BRUISED KNEES.
INJURED WAS WELDING SEAL RING ON KILN. IN CHIPPING SLAG OFF WELD, A PIECE HIT HIM IN EYE.
INJURED WAS TIGHTENING DRILL HEAD BOLTS, WRENCH SLIPED. HE STRUCK LEFT ELBOW ON CAB OF DRILL.
INJURED WAS WELDING PATCHES ON DRUM FEEDER AND DUST FELL FROM ABOVE INTO EYES.
INJ USING PIPE WRENCH TO REMOVE AIR LINE IN SLURRY BASIN. PLACED LEFT HAND ON TOP OF WRENCH. IT SLIPPED AND JAW CAUGHT LEFT THUMB TEARING AREA BETWEEN THUMB AND FIRST FINGER.
INJ MOVING BRICK RIG INTO KILN AND WIND BLEW CLINKER DUST INTO EYE.
INJURED WAS CLEANING OUT #1 BASIN WITH BOBCAT LOADER. TO GET TO LAODER HE CLIMBED OVER HOPPER AT REAR OF BELT WHEN HE SLIPPED AND TWISTED KNEE.
INJURED WAS INSTALLING LINER BOLTS IN MILL PROLONGED KNEELING CAUSED INFLAMMATION AND INFECTION OF RIGHT KNEE.
INJURED WAS WELDING ANGLE IRON SUPPORT UNDER CLINDER DUST CHUTE CLINKER DUST BLEW INTO LEFT EYE WHILE HE WAS REMOVING SLAG FROM WELD.
INJURED WAS REMOVING SCRAP PARTS AT MILL AREA AFTER REPAIR PERIOD INJURY DID NOT KEEP HIM FROM WORK UNTIL 4-20-92.
INJURED WAS WALKING TO JOB AND STEPPED IN PILE OF CEMENT ABOARD IN THE POLE FLIPPED UP THROWING CEMENT DUST IN FACE.
INJURED WAS REPLACING LINER PLATE IN RAW MILL. DRIED SLURRY CAME LOOSE & CAME IN CONTACT WITH RIGHT EYE.
INJURED WAS JACKING UP KILN & USING CHAIN FALLS TO PULL NEW TRUNION INTO PLACE METAL HOUSING CHAIN FALLS WERE HOOKED TO BROKE & FELL ON CALF OF LEFT LEG
INJURED WAS CHIPPING CEMENT AWAY FROM VALVE WHEN HE HIT VALVE WITH CHIPPING HAMME.R A PIECE OF METAL CAME OFF VALVE AND HIT HIM IN BACK OF RIGHT HAND.
INJ GRINDING PIECE OF METAL FOR WELDER.PIECE OF METAL CAME LOOSE AND HIT RIGHT EYE. INJ WAS WEARING SAFETY GLASSES WITHOUT SIDE SHIELDS.
INJURED WAS LIFTING A PIECE OF 1/2" STEEL PLATE. HE FELT HIS BACK "POP" THEN HIS LOWER BACK AND LEFT LEG STARTED TO THROB. WE DID NOT KNOW OF MEDICAL TREATMENT UNTIL 4-21-92 WHEN WE RECIEVED A REGUEST FOR WORKMENS COMPENSATION CLAIM # NUMBER.
DIRT HAD BUILTUP ON STEPS FROM CLEANUP OPERATON ON UPPER FLOOR AND HAD NOT BEEN REMOVED.
INJURED WAS LAYING BRICK OVERHEAD FROM BRICK RIG AND WAS KEYING BRICK. BRICK DUST FELL FROM BRICK & LODGED IN EYE INJURED TOOK GLASSES OFF & TRIED TO REMOVE DUST BY RUBBING EYE AND IMBEDDED PA RTICLE IN EYE.
EMPLOYEE WAS CARRYING TOOLS DOWN STEPS TO WORK ON AIR COMPRESSOR WHEN HE SLIPPED ON STEPS AND FELL INJURING LOWER BACK AND LEFT KNEE.
INJ PULLING FROZEN PLASTIC TARPULIN APART AND WHEN IT BROKE LOOSE LOST HIS FOOTING AND FELL OVER SMALL EMBANKMENT ONTO RIGHT LEG AND TWISTED IT.
CLEANING OUT RAW MILL SUMP, WITH SHOVEL LIFTED SHOVEL HE STRUCK SUMP INLET PIPE WITH L HAND CUTTING LITTLE FINGER
INJURED WAS USING ROD THRU HOLE IN GYPSUM BIN TO UNPLUG HOPPER MATERIAL FELL ON ROD INSIDE HOPPER FORCING IT DOWN AND RAISING OPPOSITE END AGAINST SIDE OF AHOPPER.RESULTING IN FRACTURE TO FING ER.
OPENED DOOR DUST FELL
INJURED WAS CLEANING UP SPILL TO GET BETTER FOOTING AND DUST PILE GAVE WAY CAUSING HIM TO FALL STRIKING LEG ON CAT WALK.
INJ WAS WALKING DOWN STEPS FROM 2ND LOOR TO FIRST FLOR IN FINISH MILL AREA. HE SLIPPED ON STEP OR CEMENT BUILD UP ON LANDING.
INJURED WAS CLEANING GROUT OUT OF A BOLT HOLE WITH HAMMER AND CHISEL.A PICE OF THE CHISEL BROKE OFF AND PENETRATED RIGHT WRIST.
INJURED WAS WORKING ON BRICK CREW IN CEMENT KILN AND WAS WALKING OUT OF KILN AND STEPPED IN HOLE IN MATERIAL LEFT IN BOTTOM OF KILN AND TWISTED HIS LEFT KNEE.
INJURED WAS CLEANING UP CLINKER SPILL AROUND #6 COOLER WAS GOING OUTSIDE TO GET COOLED OFF.HAD TO GO UP 3 STEPS WHEN HE SLIPPED AND FELL PULLING HAMSTRING OF RIGHT LEG.
EE WAS WALKING OUT OF 6 KILN TRANSPORTING A SECTION OF BRIDGE RIG. THE BOARD HE WAS ON GAVE AWAY AND HE LANDED ON HIS LOWER BACK AND TAIL BONE. THERE WAS NO MEDICAL ATTENTION OR LOST TIME TIL 4-16-90 OFF 6 DAYS AND BEGAN LOST TIME AGAIN 9-17-90 OFF 16 DAYS BEGAN LOST TIME AGAIN 8-19-=91 OFF 11 DAYS.
INJURED WAS USING AIR LANCE TO UNPLUG AIR SLIDE WHEN CEMENT BLEW OUT HITTING EMPLOYEE IN FACE- MEDICAL TREATMENT TO EYE.
WORKING AT BULK STATION ON EAST CHANGING ROTARY VALVE.ON BOTTOM OF VALVE IS FLANGE WITH 20 SCREWS THAT HOLD IT ON.EMPL SCREWING 3RD SCREW ..WHEN SCREWDRIVER SLIPPED OFF SCREW AND CAME UPWARDS STRIKING SAFETY GLASSES HITTING LEFT EYE.
INJ OPERATING FRONT END LOADER HAULING CLINKER TO CRANE.STEERING CAUGHT,BACKED LOADER UP TO CHECK IT AND BACKED INTO CONCRETE PIER HITTING HEAD ON BACK GLASS BREAKING GLASS.THEN DISMOUNTED FRO M LOADER AND FELL FROM LADDER INJURING LEFT LEG.
INJURED WAS CLEANING UP IN FINISH MILL AREA AND STEPPED IN CEMENT DUST GETTING DUST IN SHOES. LATER HE STEPPED IN WATER AND 1 HR. LATER NOTICED HIS FEET STARTED TO BURN 7 BLISTER.
EMPLOYEE WAS CLEANING UP AROUND FK PUMP IN FINISH MILL WHEN A PILE OF DUST SLID FROM AROUND PUMP. HE RAN TO GET AWAY FROM DUST AND FELL. INJURING LEFT THUMB.
INJURED WAS CLEANING MACHINERY PRIOR TO REPAIR WORK, USING AIR HOSE TO BLOW DIRT & SHAVINGS OFF OF EQUIPT. A PIECE OF METAL OR DIRT WAS BLOWN INTO EYE EITHER AROUND OR OVER SAFETY GLASSES.
INJURED WAS LOADING CEMENT BAGS ON PALLET FORT TOWMOTOR TO MOVE HE WAS OFF TO ONE-SIDE TO ALLOW OPERATOR TO REMOVE LOADED PALLET. AS TOWMOTOR TURNED-AWAY REAR WHEELS RAN OVER TOP OF LEFT FOOT.
INJURED WAS USING AIRLANCE TO UNPLUG CEMENT AIR SLIDE WHEN HE TURNED AIR ON IT BLEW MATERIAL OUT OF AIR SLIDE INTO HIS FACE & CHEST HE WAS WEARING GLASSES BUT MATERIAL BLEW AROUND & UNDER GLAS SES INTO EYES
INJURED WAS USING WHEELBARROW TO HAULBRICK INTO KILN. HE PICED UP TWO BRICK AND GLOVE CAUGHT ON OTHER BRICK CUASING HIM TO DROP BRUCK WHICH HIT HIS HAND HE DID NOT THINK IT WAS SERIOUS AND KEP T WORKING HE WENT TO DR THE NEXT DAY TO FIND THAT WAS BROKEN.
INJURED WAS SETTING UP ROLLER CONVEYOR FOR BRICK JOB IN KILN. HE STEPPED ON A NAIL OR PIECE OF WELDING ROD INJURING HIS LEFT FOOT.
INJURED WAS USING DUMP TRUCK TO HAUL DIRT THE TAILGATE CAME LOOSE ON ONE SIDE AND HE TRIED TO PUT IT BACK IN PLACE AND FELT A PAIN IN ABDOMEN.
HINJURED WAS CLEANING UP CEMENT SPILL AT DISCHARGE END OF FINISH MILL USING A BOBCAT LOADER CEMENT HAD BUILT UP ON LUBE PUMP PLATFORM STRUCTURE CAUSING CEMENT TO FALL THRU GRATING ONTO OPERATO RS ARMS & ABDOMEN
INJ WAS INSTALLING DOUBLE CABLESO NCLINKLER CRANE. HE HAD TO WORK OFF LADDER TO DO THIS. WHEN HE TIGHTENED CLAMP BOLTS HE FELT PAIN IN LOWER BACK. HE WORKED REST OF SHIFT & ALL OF NEXT SCHEDUL ED SHIFT.
INJURED WAS REMOVING BOLTS FROM HEAD OF COMPRESSOR & PULLED TOO HARD ON WRENCH
INJURED STARTED TO STEP ON A MANLIFT BELT AND LEFT FOOT SLIPPED OFF STEP. WE CONDITION.
THIS MAY BE A REOCCURRANCE OF INJURY OF 11-13-90 AND AGAIN ON 4-16-91. NO ACCIDENT REPORT WAS FILED BUT EMPLOYEE IS UNDER DOCTORS CARE AS OF 5-14-91.
INJURED WAS CLEANING UP SPILL UNDER CLINKLER BELT THAT IS APPOX 12 FT ABOVE GROUND. HE RAISED U PUNDER SUPPORT STRUCTURE HITTING HEAD, DRIVING HARD HAT OVER EYES. CAUSING GLASSES TO MAKE SMA LL CUT ON NOSE AND CHEEK BONE. ALSO MAY HAVE INJURY TO NECK.
BURNING OLD BOLTS PC OF HOT METAL FELL IN GLOVE, BURNED FINGER ON R HAND
INJURED WAS LOADING BAGS OF CEMENT ONTO PALLET JOB REQUIRES SOME TWISTING & TURNING
TRYING TO OPEN VALVE USING BAR FOR LEVERAGE IT SLIPPED OFF VALVE HE FELL IN ANGLE IRON
INJURED WAS LIFTING STEEL COVERS OFF DRAINAGE DITCH BELOW GROUND LEVEL AND STRAINED BACK.
EMPLOYEE STEPPED ON GRATING OVER 2' DEEP DRAINAGE DITCH GRATING MOVED & EMPLOYEE FELL IN DITCH, TWISTING RIGHT FOOT AND RIGHT LEG.
EMPL POURING CASTABLE IN COOLER AND HURT BACK BY TWISTING..NOT REPORTED UNTIL 4-29 WHEN EMPL WAS X-RAYED AT HOSPITAL..X-RAY REPORT NOT RECEIVED AS OF THIS DATE.
CLEANING TOP OF HOPPER AND FELL HITTING KNEE
MAN LIFTED OXYGEN AND FELT DISCOMFORT IN STOMACH.
INJURED WAS DISMOUNTING FROM BOBCAT LOADER 843.HE WAS ON FRONT TIRE PREPARING TO DISMOUNT TO FLOOR,WHEN HE STEPPED OFF TIRE TO FLOOR HIS ANKLE GAVE WAY.AREA WAS CLEAN AND CLEAR CONCRETE FLOOR IN SHOP AREA.
EE WAS CLOSING A LARGE WOODEN DOOR IN THE MAINTENANCE SHOP WHEN A BAR THAT LOCKS THE DOOR PINCHED HIS HAND BETWEEN THE HANGER AND THE DOOR. THIS RESULTED IN 5 STITCHES.
EMPLOYEE WAS REMOVING PIECES OF CASTABLE OUT OF THE COOLER SYSTEM AND A PIECE FELL ON HIS HAND.
LIFTING SCREENS AND THROWING THEM OUT OF MILL GOT SICK IN STOMACH.
EMPLOYEE WAS TAKING BEARINGS OUT A DRILL ROTATION AND PICE OF METALCHIPPED OFF AND LODGED IN HIS LEFT ARM.
EMPLOYEE WAS WELDING ON THE NOSE OF THE KILN & BURNT HIS EYES
EMPLOYEE WAS PICKING UP A LARGE ROCK & STRAINED MUSCLES IN HIS GROIN AREA
EMPLOYEE WAS WALKING DOWN STEPS AT THE MAINTENANCE SHOP AND HE SLIPPED AND FELL. WHEN HE LANDED HE HIT ON HIS LEFT SIDE AND LOWER BACK AREAS.
WELDING RAISED HOOD, GOT ARC FLASH IN BOTH EYES
WHILE WALKING TO REPAIR SHOP THIS EMPLOYEE STEPPED IN AHOLE AND SPRAINED HIS RIGHT ANKLE.
EMPLOYEE WAS CLEANING A BEARING HOUSING WITH AIR AND METAL CHIPS BLEW INTO HIS EYES.
EMPLOYEE WAS WALKING AROUND THE PLANT AND SLIPPED TWISTING HIS ABCK WHEN HE FELL.
EMPL CLIMBING INTO DRILL,SLIPPED BENDING LITTLE FINGER IN THE PROCESS.
EMPL HAD HEATED A BEARING AND WAS STRIKING IT WITH HAMMER,PIECE OF METAL FLEW AND STRUCK EAR ON OUTER EXTREMITY.
EMPL WAS HOLDING BAR WHILE ANOTHER EMPL WAS STRIKING TOP WITH HAMMER. HAMMER SLIPPED & HIT ON TOP OF HAND BETWEEN THUMB & INDEX FINGER.
EMPLOYEE WAS CARRYING A DROP COVER FOR A 992 LOADER AND TRIPPED FALLING ON SOME ENGINE PARTS ON A SKID.THIS RESULTED IN A BACK STRAIN.
EMPLOYEE WAS HELPING TO LIFT THE FRONT OF A WELDER AND STRAINED HIS BACK.
CLEANING TOP OF HOPPER FELL HITTING KNEE
EMPLOYEE WAS RUNNING UP STEPS AND WHEN HE GOT TO THE TOP HE FELT A PAIN IN HIS LOWER BACK. HE DID NOT REPORT THIS UNTIL 11/6/90.
EMPL WAS WALKING UPSTAIRS WHEN PULLED MUSCLE IN KNEE.
USING JACK HAMMER, SHAFT SLIPPED HIT HIM ON R FOOT
WALKING OUT OF KILN LANDED ON LOWER BACK AND TAIL BONE
EMPLOYEE WAS WALKING OUT OF #6 KILN TRANSPORTING A SECTION OF BRICK RIG. THE BOARD HE WAS ON GAVE AWAY AND HE LANDED ON HIS LOWER BACK AND TAILBONE. BEGAN LOST TIME AGAIN ON 9/17/90.
EMPLOYEE WAS STACKING CEMENT BAGS AND RAISED UP AND HIT HIS BACK ON A BEAM.
EE WAS STEPPING ONTO A MANLIFT AND PULLED MUSCLES IN HIS HIP.
EMPLOYEE WAS CLEANING ON A BELTLINE BY THE PORTABLE CRUSHER AND A ROCK ROLLED OFF FALLING ON HIS RIGHT FOOT.
EMPLOYEE WAS CLIMBING ONTO THE PORTABLE CRUSHER TO UNHOOK A CABLE THE BELTLINE SLIPPED & HE CAUGHT HIS FOOT BETWEEN TWO PIECES OF CHANNEL IRON
WORKING IN WATER GOT CEMENT IN BOOT. BURN ON L FOOT
EMPLOYEE WAS USING A RATCHET WHILE TAKING OFF A BOLT ON A COMPRESSOR. IN THE PROCESS THE RATCHET SLIPPED CAUSING HIS HAND TO GET SMASHED. THIS ACCIDENT REQUIRED FOUR STITCHES TO HIS RIGHT MID DLE FINGER.
EMPLOYEE WAS REMOVING A BOLT ON A COUNTER BALANCE ON A DOZER WITH A RATCHET WHEN IT SLIPPED AND HE STRAINED HIS NECK.
EMPLOYEE WAS WELDING IN THE KILN OVERHEAD. HE WAS IN THE PROCESS OF GRINDING THE AREA AND TWISTED WHILE REACHING ABOVE HIS HEAD. THIS RESULTED IN A BACK STRAIN.
EMPLOYEE WAS WEEDING ONT HE PLANT GROUND AND GOT INTO SOME POISON IVY.
EMPL WALKING DOWN SOME STAIRS WHEN HE SLIPPED & FELL CATCHING HIMSELF WITH HIS RIGHT HAND.
EMPLOYEE STEPPED ON A ROCK WHILE WALKING THROUGH THE FINISH MILL AREA. THIS RESULTED IN A SPRAIN TO RIGTH ANKLE.
EMPLOYEE WAS WALKING AROUND THE PLANT SERVICE WATER PUMP AND SLIPPED BUT CATCHING HIMSELF BEFORE FALLING TO THE FLOOR. THIS RESULTED TO AN INJURRY TO HIS BACK. *THIS EMPLOYEE BEGAN LOST TIME O N 05/02/90.
EMPL LIFTING WITH HOIST,JUMPED TO LOWER LEVEL LANDING ON A BOLT.
EE WAS CLEANING A GLASS BEAKER WHEN IT BROKE LACERATING HIS FINGER.
EMPLOYEE WAS WALKING OUT OF #6 KILN TRANSPORTING A SECTION OF BRICK RIG. THE BOARD HE WAS ON GAVE AWAY AND HE LANDED ON HIS LOWER BACK AND TAIL BONE.
EMPLOYEE WAS GOING TO THE TIME OFFICE TO CLOCK OUT AFTER HIS SHIFT AND HAD A HEAD-ON COLLISION WITH ANOTHER EMPLOYEE THAT WAS TRAVELING THE WRONG DIRECTION.
EMPLOYEE WAS GUIDING 1/2 KILN SEAL RING WITH THE HELP OF A CRANE ONTO THE KILN THERE WAS TENSION ON THE CHAIN & IT RELEASED PINNING HIM BETWEEN THE SEAL RING & THE KILN COOLING HOUSING
EMPLOYEE WAS HOLDING A TRIPOD FOR A MERCURY LIGHT AND REACHED TO GRASP AN ELECTRIC CORD REEL AND WAS SHOCKED(110V).IT WAS LATER DETERMINED THAT THE PLUG HAD BEEN CONNECTED IMPROPERLY.IN THE PR OCESS HE FELL TO THE GRATING AND LACERATED HIS HEAD.
EMPL HELPING WELDER ERECT REINFORCING FOR PIPE SUPPORT FORMS.THIS HAPPENED DURING 3-HR PERIOD.RECD FLASHBURN TO BOTH EYES.
EMPLOYEE WAS TAKING AN EXHAUST OFF OF A DOZER AND SLIPPED IN SOME MUD. HE FELL ABOUT 5 FEET AND SPRAINED HIS ANKLE.
EMPLOYEE WAS STEPPING OUT OF THE FUEL TRUCK AND SPRAINED HIS RIGHT ANKLE.
THIS EMPLOYEE WAS WELDING AND GOT FLASH BURNS TO BOTH EYES. WE DID NTO RECIEVE INFORMATION CONCERNING THIS ACCIEDENT UNTIL 12-28-89. AT THIS TIME WE RECIEVED HOSPITAL MEDICAL FORMS. THIS IN DIVIDUAL HAD NOT PLANNED TO TURN THIS IN AS A WORKMAN COMPENSTION CASE AND INTEDED TO PAY FOR THIS HIMSELF. HE CAME IN FROM A LAY-OFF ON 1-5-90 AND FILLED OUT AN ACCIDENT REPORT.
EMPL WAS USING CHAINFALL TO REMOVE GEAR REDUCER FROM SEPARATOR. BOLT THAT HELD CHAINFALL BROKE & UNIT HIT HIM IN BACK & ON HIPBONE.
OPER FRONT END LOADER WITH COAL. ON AN INCLINE AND IN 3RD GEAR TRIED TO DOWNSHIFT IN 2ND GEAR RESULT IN ENGINE DYING HAVING LIMITED BRAKES STRUCK STEEL BEAM STRUCTURE AND HAD FLAT TIRE ACC CA USED LUMBAR STRAIN IN BACK
EMPL WAS SHOVELING CLINKER BY CLINKER ELEVATORS & MATERIAL DROPPED ON HIM & GOT PARTICLES IN EYE.
EMPLOYEE WAS SHOVELING CLINKER & THE COOLER FAN BLEW DUST INTO HIS RT EYE
EMPLOYEE WAS SHOVELING INTO A WHEELBARROW AND THE MAN BESIDE HIM PICKED UP THE WHEELBARROW AND IT SLIPPED OUT OF HIS HANDS. THIS RESULTED IN THE WHEELBARROW HITTING HIM IN THE LEG WHICH CAUSED HIM TO REINJURE HIS BACK.
EMPLOYEE WAS LIFTING A COVER FROM A DRAINAGE DITCH AND PULLED MUSCLES IN HIS BACK.
EMPLOYEE WAS CLIMBING DOWN FROM WORKING ON A DUST COLLECTOR SYSTEM AND FELL LANDING ON HIS RIGHT WRIST AND HAND.
EMPLOYEE WAS CARRYING A BEARING AND SLIPPED ON UNSTABLE GROUND SPRAINING HIS FOOT. *LOST TIME IN THIS ACCIDENT DID NOT START UNTIL 9-23-89. IT WAS NOT REPORTED UNTIL 10-3-89 WHEN THIS EMPLOY EE BROUGHT IN A DOCTOR'S SLIP.
EMPLOYEE WAS USING A JACKHAMMER AND IT STRUCK HIS KNEE. THIS RESULTED IN A DISLOCATION OF HIS KNEECAP AND CAUSED HIM TO PASS OUT. HE THEN FELL TO THE GROUND SCRAPING HIS NOSE AND THE BACK OF H IS HEAD.
EMPLOYEE WAS USING JUMPER CABLES TO START DOZER AND GOT HIS LEGS CAUGHT AND FELL FROM THE TRACKS TO THE GROUND.
LOADING PALLETS WITH BAGS OF CEMENT, PULLED MUSCLES, IN SIDE AND BACK
EMPLOYEE WAS WALKING AROUND THE PLANT SERVICE WATER PUMP & SLIPPED BUT CATCHING HIMSELF BEFORE FALLING TO THE FLOOR THIS RESULTED IN AN INJURY TO HIS LOWER BACK
EMPL WAS USING A CHAIN FALL WHEN THE CHAIN BROKE THIS RESULTED IN AN INJURY TO HIS SHOULDER
EMPLOYEE WAS CLIMBING OUT OF A DOOR IN A BALL MILL (FINISH MILL #8) AND TWISTED HIS BACK IN THE PROCESS.
EMPL WAS RUNNING A BOBCAT LOADED WITH DIRT AND MADE A SUDDEN TURN RESULTING IN THE MACHINE ROCKING OUT OF CONTROL AS THIS HAPPENED HE HIT HIS HEAD CAUSING A LACERATION
EE WAS CLIMBING DOWN A LADDER AND SLIPPED APPROX. 2-3 FT. HIS FOOT FOLDED UNDER WHEN HE LANDED RESULTING IN FRACTURED BONES IN HIS LEFT FOOT.
EMPLOYEE WAS WALKING THROUGH THE KILN DURING A BRICK JOB AND DUST BLEW INTO HIS FACE GETTING IN HIS LEFT EYE.
EMPLOYEE WAS BENT OVER SHOVELING ROCK OUT FROM #1 BELT WHEN ROCK FELL FROM ABOVE AND HIT HIM IN THE BACK.
MAN WAS STANDING ON TOP OF A HOPPER WHEN HIS FOOT SLIPPED THROUGH THE GRATING THIS RESULTED IN A TWISTED R KNEE AND ABRASIONS TO THE SHIN RIGHT HIS FIRST LOST TIME DAY WAS NOT UNTIL 6/29/89
EMPLOYEE WAS LOOSENING A SWING VALVE, CHANGING FROM ONE SILO TO ANOTHER, AND STRAINED HIS BACK AND SIDE.
MAN WAS ON A BRICK CREW AND ONE OF THE ROWS LOOSENED WHILE MOVING THE RIG. HE TRIED TO PUT THE RIG BACK IN PLACE AND SOME BRICKS FELL ON HIS LEFT KNEE AND HAND.
MAN WAS STEPPING OVER A GUARDRAIL & BUMPED HIS LEFT KNEE CAUSING A SPRAIN
MAN WAS WORKING ON HOUSING FOR A DRAG CHAIN AND CEMENT DUST BLEW INTO HIS EYES. THE MAN MISSED ONE DAY OF WORK AND THEN THIS TO HIS FOREMAN.
EMPL BEATING ROLLERS ON RETURN BELT WITH ROLLER HANGER.BELT CAUGHT HANGER PULLING HAND INTO ROLLER AND BELT.
MAN WAS LAYING ON THE GROUND CUTTING OVERHEAD WITH A TORCH AND GOT SPARKS IN HIS EYE.
MAN WAS MAKING HYDRAULIC HOSE BY STRIPPING OFF THE CASING WITH A KNIFE THE HOSE BACKLASHED AND THIS RESULTED IN A PUNCTURE TO HIS HAND
EMPLOYEE WASINSIDE OF A WELDER PRYING WITH A SCREWSDRIVER. THE WEIGHT OF THE SCREWDRIVER CAUSED HIS HAND TO HIT A SHARP PIECE RESULTING IN A LACERATION OF HIS INDEX FINGER.
CHECKING COOLANT AND STEPPED ON TRACK OF DOZER CAUSING SLIP IN MUD.FELL LANDING ON RIGHT ARM AND SHOULDER.
EMPLOYEE WAS WALKING DOWNSTAIRS TO CHECK A LUBE PUMP.WHEN REACHING THE FIRST STEP BOTH OF HER FEET WENT OUT FROM UNDER HER.SHE LANDED ON HER BACK,SHOULDERS,KIDNEY AREA AND NECK.
MAN SLIPPED IN THE MUD THAT WAS UP TO HIS KNEE AND PUT HIS HAND OUT TO CATCH HIMSELF. HE PUNTURES HIS HAND IN THE PROCESS AND THIS RESULTED IN STICHES.
MAN WAS GETTING DOWN OFF A SUMP THAT HE HAD HOOKED LIFTING CABLES TO & SLIPPED IN THE PROCESS THE EDGE WAS SLIPPERY CAUSING HIM TO FALL LANDING ON HIS BACK & SCRAPPING HIS SHIN
MAN WAS USING AN AIR LANCE & GOT DUST IN HIS EYE HIS PRESCRIPTION GLASSES WERE NOT ENOUGH IN THIS PARTICULAR CASE & HE NEEDED GOGGLES ALSO
THE EMPL WAS USING A 5 TON CHAINFALL TO REMOVE A SCREW FROM #7 FINISH MILL FK PUMP WHILE PULLING ON THE 3/8" CHAIN IT BROKE CAUSING THIS MAN TO FALL INTO PUMP HOUSING THIS INDIVIDUAL DID NOT S EEK MEDICAL ATTENTION UNTIL 4-26-89
EMPLOYEE WAS HELPING REMOVE A DRIVE SHAFT OFF OF A 988 CAT LOADER.HE WAS LIFTING AND PULLED MUSCLES IN HIS LOWER BACK.
MAN WAS LIFTING AN OXYGEN BOTTLE APPROX 3 FT TO A DIESEL WELDER.IN THE PROCESS THE BOTTLE SLIPPED THROUGH HIS HANDS.HE WAS AFRAID THAT IT MIGHT EXPLODE IF IT HIT THE CONCRETE FLOOR,SO HE ATTEM PTED TO CATCH IT,THIS RESULTED IN A SEVERE STRAIN AND TEAR OF THE STOMACH AND LOWER BACK MUSCLES.THIS ACCIDENT WAS NOT REPORTED UNTIL 03-28-89.
CUTTING OLD PIECE OF METAL FROM KILN HOOD AND IT STARTED TO FALL.CATCHING IT PINCHED FINGER ON ANOTHER PIECE OF METAL.THIS RESULTED IN LACERATION THAT TOOK 10 STITCHES TO MEND.
EMPL SHOVELING IN #6 KILN AND AIRBORNE DUST GOT INTO EYE.
EMPLOYEE WAS JACKHAMMERING INSIDE OF KILN AND THE DUST FROM THE CLINKER BROKE HIS FACE OUT.THIS CONCENTRATED AROUND HIS MOUTH AND NOSE AREAS.LOST TIME DID NOT BEGIN UNTIL 01-06-89.
EMPLOYEE NOTIFIED KILN BURNER HE WAS GOING TO CLEAN OUT #5 SURGE BIN EMPLOYEE REMEMBERS FINDING PLUGGED AREA & REMOVING THE PLUG WITH A BAR THE LAST THING HE REMEMBERS IS HE STILL HAD THE BAR THE AREA & WAS READY TO QUIT BECAUSE HE HAD THE PLUG CLEARED IT WOULD APPEAR THAT AT THAT POINT SOMETHING ELSE STRUCK THE BAR WHICH THEN HIT THE EMPLOYEE ON THE HEAD EYE & ARM HE DID CALL TH
EMPLOYEE WAS CLIMBING INTO A WABCO TRUCK AND SLIPPED IN THE PROCESS. HE PULLED A LIGAMENT IN HIS LEFT ARM BY HOLDING ON AND THEN FELL APPROXIMATELY 5 FEET TO THE GROUND.
LAYING ON BACK WELDING BOLTS ON GRATES A PIECE OF WELD BURNT THROUGH PANTS DOWN INTO BOOT AND INTO HEEL AND ANKLE BURNED SKIN ON HEEL AND ANKLE APPROX A WEEK LATER IT GOT INFECTED
EMPLOYEE WAS WORKING INSIDE OF A DUST BIN AND HAD REMOVED THE SIDE PLATE TO GET THE CEMENT FLOWING INTO THE SCREW. WHILE ATTEMPTING THIS SURGE OF DUST BLEW INTO HIS EYES, SCRATCHING HIS RIGHT CORNEA.
EMPL WAS CLEANING AROUND A CEMENT LINE HOLE WITH HIS HAND WITHOUT GLOVES ATH THE BULK LOADING STATION WHILE DOING THIS HE CAUGHT HIS SMALL L FINGER ON A JAGGED EDGE AND LACERATED IT THIS RESUL ED IN 3 STITCHES
WELDING ON COAL MILL ROLL APPX 200-300 LBS IN SHOP ON BENCH.HAD TURNED AROUND TO LOOK AT SOMETHING AND ROLL ASSEMBLE FELL OFF BENCH HITTING LEFT ARM ON THE WAY DOWN.
EMPLOYEE WAS WALKING DOWN STEPS AT THE RAW MILL AND STEPPED ON A 11/4" NUT CAUSING HIM TO PUT ALL OF HIS WEIGHT ON HIS ANKLE. THIS CAUSED A SPRAINED ANKLE AND A SLIGHT FACTURE TO HIS RIGHT FO OT.
ADJUSTING PULLEY ASSEMBLY ON PUMP MOTOR.INJ STEPPED IN TO TUG ON BELTS ONE LAST TIME TO SEE THERY WERE ADJUSTED CORRECTLY.HELPER HIT SWITCH CATCHING INJ HAND IN PULLEY ASSEMBLY.ATTCH.
MAN WAS WALKING TO HIS DOZER FOR PRESHIFT INSPECTION AND STEPPED INTO A HOLE AND SPRAINED HIS KNEE.
MAN WAS LOADING 55 GAL DRUM OF ANTIFREEZE INTO A LOADER BUCKET AND THE BARREL STARTED TO FALL.UPON SEEING THIS THE EMPLOYEE TRIED TO CATCH IT BEFORE IT FELL AND PULLED MUSCLES IN HIS BAC K ABD SHOULDERS.
THIS EMPLOYEE WAS OPENING A TANK VALVE, THAT HAD JUST BEEN GREASED, AND HAD A HARD TIME PUSHING IT OPEN. HE STRAINED HIS BACK IN THE PROCESS.
MAN WAS CHECKING THE LUBE SYSTEM AND TURNED AROUND AND SLIPPED ON SOME LUBE. THIS CAUSED HIM TO FALL BACKWARDS AND INJURY HIS LEFT ELBOW AND RIBS. THE FIRST LOST TIME DAY THIS EMPLOYEE MISSED WAS 10 10 88.
EMPLOYEE WAS SHOVELING IN A CONFINED AREA (APPROX. 4 FEET HIGH) AND HAD TO DUCK AND BEND. THIS CAUSED STRAIN ON HIS BACK, NECK AND HIP WHICH RESULTED IN HIS VISIT TO A CHIROPRACTOR.
THIS INDIVIDUAL REPORTED TO WORK ON THIS DATE WITH A DOCTOR'S RELEASE STATING THAT HE HAS ACUTE BRONCHITIS. THIS STEMS FROM AN EARLIER CLAIM (12-9-87) IN WHICH THIS EMPLOYEE WAS AIRARC CUTTING AND BREATHED IN NORDBAK GASSES.
MAN WAS GETTING DOWN FROM HIS DOZER AFTER REFUELING AND SLIPPED AND TWISTED HISF OOT AND ANKLE.
EMPLOYEE WAS SHOVELING STONE OUT OF A DRAIN IN THE RAW MILL AREA AND PULLED A GROIN MUSCLE.
EMP WAS JACKHAMMERING IN FINISH MILL AREA OFF AND ON FOR APPROX 4 HRS. ON FOLOWING DAY HE WAS JACKHAMMERING IOFF AND ON FOR 2 HRS. AT THIS TIME HE COMPLAINED TO FOREMAN ABOUT PROBLEMS IN R. WRIST.
EMPLOYEE WAS UNPLUGGING AN AIR SLIDE AND CEMENT DUST BLEW OUT AND WENT UNDER HIS SAFETY GLASSES AND INTO HIS EYE.
MAN WAS CLIMBING DOWN A LADDER AND SLIPPED ON THE THIRD RUNG AND SPRAINED HIS ANKLE.
EMPLOYEE WAS SHOVELING UNDER #9 FINISH MILL AND SOMETHING HIT HIM ON THE BACK. AFTER INVESTIGATION, IT WAS FOUND THAT A PIECE OF CEMENT APPROX. 2" IN DIAMETER HAD STRUCK HIM.
EMPLOYEE WAS BENT OVER PUTTING A WHEELBARREL UNDER A TAILPULLEY TO FILL IT UP. HE GOT THE WHEELBARREL FILLED AND THEN PULLED IT PUT FROM UNDER THE TAILPULLEY AND SMASHED HIS LITTLE FINGER BETW EEN THE WOODEN HANDLE AND THE WALL.
EMPL WAS CHANGING A WATER VALVE AND WAS USING A PIPE WRENCH AND THE NIPPLE BROKE ON THE VALVE THIS CAUSED HIM TO FALL LANDING ON HIS BACK
EMP WAS WALKING THROUGH THE KILN AND THE KILN HAD JUST BEEN TURNED AND HE STEPED IN AHOLE . THIS CAUSED HIM TO FALL ONTO HIS KNEE AND RELUTED IN A PUNTURE WOUND. THIS ACC. DID NOT REQUIR E ANY STICHES.
EMPL PUSHING WHEELBARROW UPON BOARD 6'' HIGH ONTO HOPPER AND BOARD BROKE.MAN FELL LANDED ON SHOULDER.CONTUSION ON SHOULDER AND TWISTED BACK ALSO.
MAN WAS CLEANING AROUND DUST SCREWS AND STEPPED OFF OF ONE AND STRAINED HIS KNEE THIS INDIVIDUAL HAS HAD PRIOR KNEE PROBLEMS AND EVEN SURGERY ON THIS KNEE
EMPL WAS LEANING DOWN TO PULL OUT AN AIR HOSE OUT OF A DRAINAGE DITCH THE LID FOR THE DITCH WAS PROPPED UP WITH A 2X4 AND THE AIR HOSE CAUGHT THE 2X4 ALLOWING THE LID TO HIT THE MAN ON THE H EAD HE WAS WEARING A HARDHAT AT THE TIME
MAN WAS TAKING BAGS OF CEMENT OFF A BELT AND PLACING THEM ON A SKID. DUE TO THE HEAT (100 F) THAT DAY AND THE RUBBING OF THE BAGS ON HIS ARMS AND STOMACH, IT CAUSED CEMENT BURNS IN THESE AREAS .
EMPLOYEE WAS CLEANING AND JACKHAMMERING IN THE FINISH MILLS AND GOIT DUST INTO HIS EYES THROUGH HIS GLASSES.
EMPLOYEE WAS USING A JACK HAMMER IN THE FINISH MILL AREA AND BENT OVER TO PICK UP HIS GLOVES AND HIS BACK WENT OUT THIS INDIVIDUAL HAS HAD BACK PROBLEMS PREVIOUSLY THAT DID NNOT STEM FROM HIS JOB AT THIS LOCATION HE HAS BEEN SEEING A CHIROPRACTOR FOR SEVERAL MONTHS
MAN WAS WORKING ON FINISH MILL #8 REPLACING DOOR & SLING THAT WAS BEING USED TO GUIDE DOOR ON LET GO. SLING HIT HIS RIGHT HAND & CAUSED LACERATION.
MAN WAS SUPERVISING A BRICK CREW AND A PIECE OF COATING FROM KILN (APPROX 100 LBS) STRUCK HIM ON THE HEAD AND SHOULDER AREAS
MAN WAS SHOVELING CEMENT INTO A WHEELBARROW AND LIFTED THE WHEELBARROW AND STRAINED HIS GROIN MUSCLES.
EMPLOYEE WAS REMOVING A DISCAHRGE LINE FROM ASLURRY PUMP AND HOT SLURRY SPLASHED OUT ONTO BOTH WRISTS AND FOREARMS.THE MAN STATED THAT HE DID NNOT REALIZE THAT THE SLURRY COULD BE THAT HOT.
THE AREA KNOWN AS THE EAST PACK HOUSE HAD BEEN VACATED BY EMPLOYEES AT ABOUT 4PM AT APPROXIMATELY 5 PM FOUR EMPLOYEES THAT HAD BEEN WORKING IN ANOTHER AREA WENT TO THIS AREA TO TAKE A BREAK UP ON ARRIVING IN THIS AREA THE MEN NOTICED THAT THE BUNDLES OF CEMENT BAGS WERE ON FIRE AT THIS TIME THEY CALLED THE FIRE DEPARTMENT BECAUSE THE FIRE WAS OUT OF THEIR CONTROL OR CONTROL OF A FI
EMPLOYEE WAS PUTTING A FAN HOUSING ON THE FLOOR AND WHEN HE BENT OVER TO SET IT DOWN HE STRAINED HIS MID BACK.
EMPLOYEE WAS ON TOP OF THE SILOS WALKING THROUGH SOME CEMENT DUST AND DID NOT SEE A PIPE THAT WAS BURIED AND TRIPPED AND FELL. WHEN HE FELL HE HIT HIS LEFT THUMB AND STOVED IT.
EMPLOYEE WAS STANDING ON A LADDER SHIPPNG CASTABLE OFF THE COOLER WALLS. THE LADDER KICKED TO ONE SIDE AND HE FELL APPROX. 12 FT ANOTHER EMPLOYEE WAS HOLDING THE LADDER AT THE TIME.
MAN WAS USING A PORTA-POWER JACK AND HAD USED A PIECE OF 12"X2" STEEL AS A WEDGE AND IT KICKED OUT HITTING HIM IN THE FOREHEAD CAUSING A LACERATION, RESULTING IN STITCHES.
MAN WAS WALKING DOWN INTO THE PIT TO START A PUMP AND LOST HIS FOOTING IN THE MUD AND TWISTED HIS KNEE.
MAN WAS IN THE 4A BELT CONVEYOR AREA SHOVELING ONTO THE BELT AND STRAINED HIS BACK
A dated report covering the 26-year penalty trail, line-item violation pattern, contest and docket posture, rate-normalized peer benchmark, and full fatality history. Delivered as a PDF with the underlying data as CSV.