Marble Falls Plant Metal/Non-Metal

Injured employee was opening hatch lids on top of trucks when they strained their back. Employee was working with case management for remedies when they decided to be seen by a doctor which then elevated case to reportable.

Grinder angle was incorrect, causing it to bind up on a narrow area on angle iron. Grinder bounced at employee causing lacerations on chin and neck.

Employee jumped from loader ladder into soft berm and rolled EE's left ankle. Requested to see doctor on 3/26/2024 and was given restrictions.

EE was using an pneumatic air hammer to chip lime scale away from the truck side loading scale. The EE reached out over head while lying on the ground and over extended, causing an acute pain in the right shoulder and numbness in the right hand.

We were in man lift boomed out over elevator. A Lhoist employee entered and began operating elevator. The elevator made contact with the man lift boom that I, and my employee, were in. My employee received a broken nose and slight fracture in right knee.

Winter storm caused the water pipe to freeze that is located on the exterior wall. EE used a propane pear torch burner to thaw the metal water pipe. EE returned the burner and upon EE return, noticed smoke coming from the lab. Extinguishers were used to put the fire out. It was around 38 minutes that all signs of fire was not present in the wall. No injuries or entrapments.

EE slipped and fell on snow and ice and was place on restricted duty following the incident. EE landed on their RT side including hip and elbow, however when medical treatment was sought it involved EE's right foot.

Employee was air lancing around a lime silo when lime came in contact with eyes. EE immediately flushed eyes for 10 minutes at an eye wash station, they used 2 bottles of saline solution. Eyes felt better however they wanted medical treatment. Employee was sent to urgent care this morning. EE received 3 prescriptions, one of which was tylenol with codeine.

EE was stung by a bee while working on Kiln Level 2 at LNA Marble Falls superstructure project. The EE was transported to Urgent Care. From there the EE was being transported to a Medical Center, when the EE went into anaphylactic shock. The EMS had EE transported by helicopter to a Medical Center in Austin Tx. for treatment.

EE was lifting a railcar vibrator into place when EE felt a pop on the inside of the elbow. The EE experienced soreness, but did not report the injury to management until December 15th. It was at that time, the employee sought medical treatment and was placed on restricted work duties.

An employee working in the Stone Tunnel replacing a sump pump with another employee, when they were overcome by carbon monoxide gas.

An employee working in the Stone Tunnel replacing a sump pump with another employee, when they were overcome by carbon monoxide gas.

I pulled on the handle of a sand blasting pot to check the sand volume. The pot was completely empty and tipped back. I attempted to step back and tripped, pulling the pot down with me. The handle of the sand pot came down across my left ankle and caused a fracture.

An employee was lifting an end of a screw flight, when employee felt pain in lower back. The employee was placed on restricted duty by a medical provider.

Employee was leaving work when wind blew lime in eyes.

Working on the drive of a screw conveyor. One employee was jogging, when another grabbed the belt and tried to manually jog. His thumb was caught by the belt and his right thumb was amputated.

Employee was standing on ladder when ladder slipped out from under him and his tools hit him in the lip. The ladder possibly slipped from dust material under legs of ladder.

Employee was laying brick and went to hit the brick with a brick hammer to lodge it into place. Instead of hitting the brick he hit the metal shim beside it and the hammer slipped off the shim and hit his finger.

Multiple welders in same area; redness in left eye with moderate discomfort. Employee notified supervisor of discomfort at 9:30 AM 05/13/2009; received medication from doctor. Noticable relief within a couple hours, will return to doctor for check-up 05/15/2009; employee was released with no limitations or restrictions 05/13/2009

Employee was cleaning up lime & dirt accumulated on the ground. He was wearing shaded safety glasses & pulled them down to see better. Lime & dirt blew into the employee's face & eyes. Employee stated this caused irritation to both eyes even after flushing with water.

EMPLOYEE WAS CLOSING MAN ELEVATOR. THE INSIDE DOOR WAS DIFFICULT TO CLOSE. ATTEMPTING TO CLOSE THE OUTER DOOR, THE UPPER DOOR AND LOWER DOORS CLOSED TOGETHER WITH THE EMPLOYEE RIGHT HAND IN BE TWEEN THEM CAUSING BRUISING AND A SLIGHT FRACTURE TO THE MIDDLE FINGER. RIGHT HAND BELOW THE TOP KNUCKLE AND BOTTOM OF THE THUMB NAIL.

WHILE SHOVELING ROCK AT 2319 FEEDER. EMPLOYEE FELT PAIN IN LOWER BACK. EMPLOYEE WASN'T PLACED OFF OF WORK UNTIL 9/4/01 BY HIS TREATING PHYSICIAN. HE WAS NOT PLACED ON LIGHT OR MODIFIED DUTY UN TIL THAT TIME.

EE WAS GRINDING WITH AN ELECTRICK GRINDER WHEN HE STRUCK A BURR, THE GRINDER KICKED BACK STRIKING THE EE IN THE AREA BETWEEN HIS MOUTH AND CHIN WITH CASE OF THE GRINDER. CAUSING A LACERATION AND A LOSS OF A TOOTH.

EE WAS BLOWING DUST OFF THE PAVEMENT AREA NEAR BAGHOUSE. DUST GOT UNDER HIS GLASSES AND INTO HIS EYE.

EMPLOYEE WERE SETTING A CONVEYOR COVER BACK INTO PLACE. HE LOST HIS GRIP AND THE COVER SLIPPED. HIS FINGER WAS CRUSHED BETWEEN THE COVER AND THE HANDRAIL.

EMPLOYEE WAS SHOVELING LIME DUST INTO A CONTAINER WHEN THE WIND BLEW THE DUST UP UNDER HIS GLASSES AND INTO HIS EYE.

I.NAME AND ANOTHER EMPL LIFTING FEEDER LID BACK INTO PLACE AND I.NAME STRAINED HIS BACK.

HE WAS IN THE PLANT AREA NEAR THE DISCHARGE FEEDER AND GOT DUST IN HIS EYE. IT REMAINED IRRITATED AND THREE DAYS LATER HE WENT TO THE DOCTOR, WHO GAVE HIM A PRESCRIPTION FOR SALVE TO SOOTH HI S EYE.

I NAME WAS CLEANING A DISCHARGE WATER DITCH HE STEPPED INTO THE DITCH & GOT SCRUBBER DISCHARGE WATER IN HIS RUBBER BOOTS HE CONTINUED TO WORK & WHEN HE REMOVED HIS BOOTS LATER HIS FEET WERE BU RNED & IRRITATED

EMPLOYEE WAS REMOVING BOLTS USING A HAND WRENCH AND STRAINED WRIST BUT DID NOT REALIZE THAT THERE WAS ANY DAMAGE UNTIL IT BEGAN TO SWELL AFTER CONTINUED USE FOR SEVERAL DAYS.

WORKER WAS OBSERVING OPERATION OF ROLLER CURSHER & GOT LIME DUST IN HIS EYE. TWO DAYS LATER HE WENT TO DOCTOR FOR IRRITATION OF LEFT EYE. HE WAS TREATED WITH SALVE & RELEASED.