Viburnum #28 Mine/Mill Metal/Non-Metal

EE WAS CUTTING A 2 INCH PIPE CLAMP BOLT WITH ANACETYLENE TORCH. WHEN HEAT WAS APPLIED TO BOLT, RUST WAS BLOWN INTO EE LEFT EYE. EE WAS TAKEN TO COMPANY DR ON 8-1-02, TO REMOVE FOREIGN OBJECT. DR APPLIED AN ANTIBIOTIC CREAM ON EYE MAKING THIS A REPORTABLE.

EE GOT OFF #73 JUMBO TO TIGHTEN A HOSE ON THE BOOM. HE LOST HIS FOOTING ON THE ROUGH FLOOR & BEGAN TO FALL, CATCHING HIMSELF WITH HIS HANDS. HISHANDS CAME IN CONTACT WITH SOME SHARP ROCKS, CUT TING BOTH HANDS WHICH REQUIRED STITCHES.

EE WAS DRIVING A 30T MOXY TRUCK ON THE EXIT HILL OF THE #28 QUARRY. THE HILL HAD ROCK ON IT AND EE ATTEMPTED TO STRADDLE SOME ROCKS THAT HAD BEEN LOST ON THE PREVIOUS LOAD. THE FRONT FRAME OF TRUCK CAUGHT THE LOOSE ROCK AND THREW IT UNDER FRONT TIRE CAUSING CAB & BED TO TWIST. EE EXPERIENCED BACK/HIP PAIN & TAKEN TO CO. DR. THEN WENT TO OWN DR & TOLD TO BE OFF WORK 2 WEEKS & THERAP

A CONTRACTOR HAD WASHED A 980 LOADER IN SHOP AND LEFT WITHOUT CLEANING THE FLOOR. A TRACTOR WAS PULLED IN WITH A FLAT & WHILE EE WAS CHANGING TIRE HE SLIPPED ON GREASE ON CONCRETE & FELL LANDI NG ON HIS RIGHT SHOULDER AREA. EE WAS TAKEN TO DR THAT DAY. STILL EXPERIENCING PAIN & HAD MRI 5/11. SAW NEW DR ON 5/22 & WAS INSTRUCTED TO GO TO PHYSICAL THERAPY. 7000-1/THERAPY. NO LOST TIME

EE WAS OPERATING #20 ST8 LOADER IN REMOTE. HE WAS MOVING A LARGE BOULDER OUT OF LOADING AREA. HE WAS STANDING ABOUT 10' FROM PILLAR AND ABOUT 10' FEET FROM LOADER. HE BACKED LOADER OUT WITH BO ULDER IN DIPPER AND STARTED FORWARD WHEN THE REAR OF THE LOADER CAME OFF THE GROUND AND SWUNG AROUND AND HIT HIM, KNOCKING HIM UP AGAINST A PILLAR.

EE WAS WELDING ON HAND RAIL ON VOLVO LOADER. EE STRUCK ARC BEFORE HOOD WAS FLIPPED DOWN. AS EE FLIPPED HOOD DOWN, IT HIT A PIPE NEAR HIS HEAD, AND THEREFORE DID NOT COMPLETELY CLOSE. EE HAD TO MOVE HEAD BACK TO CLOSE HOOD. THE EVENT PROBABLY TOOK 2-3 SECONDS. A FLASH BURN TO BOTH EYES RESULTED. EE RETURNED TO WORK ON HIS NEXT SCHEDULED SHIFT.

EMPLOYEE WAS WALKING ACROSS ROADWAY AT UNDERGROUND SHOP WHEN HE TRIPPED OVER A ROCK. NO MEDICAL TREATMENT SOUGHT BUT AFTER 2-3 HOURS, EMPLOYEE REPORTED SEVERE PAIN IN HIS LOWER BACK AND IT WAS GETTING WORSE. HE WAS TRANSPORTED TO EMERGENCY ROOM WHERE HE WAS GIVEN A PAIN INJECTION. HE WAS LATER DIAGNOSED WITH A SPRAINED SACROILIAC JOINTAND SCHEDULED FOR PHYSICAL THERAPY.

THE EE REPORTED T0 HIS SUPERVISOR THE HE HAD BEEN HAVING MUCH HURTING IN HIS LEFT & RIGHT ARMS & HANDS. PROBABLY MORE SO IN HIS LEFT. HE REPORTED THAT HE HAD WENT TO HIS PERSONAL DR & TH AT CARPAL TUNNEL HAD BEEN DIAGNOSED. THE EE WAS TAKEN TO DR HUDSON 8/5/99 WHO RECOMMENED A NERVECONNECTION TEST AND TO MAKE AN APPPT WITH AN ORTHOPEDIC SPECIALIST AFTER THE TEST RESULLTS CA

WHILE DOING ELECTRICAL WORK, EE INHALED SOME SULFUR DIOXIDE. ON HIS WAS HOME EXPERIENCED A COUGHING SPELL, DIZZINESS, AND CHEST PAINS. FELT HIMSELF PASSING OUT, AND TRIED TO CATCH HIMSELF. SPR AINED SHOULDER. TRANSPORTED TO ER AND TREATED. GIVEN A STEROID INJECTION FOR SPRAINED SHOULDER.

HOIST, OFFICE, SURFACE SHOP AND STRORE ROOM POWER WENT OFF AT 8:00 AM. FOUND 2400 VOLT BREAKER TRIPPED IN SUB STATION AND SMOKE COMING FROM CABLE TRENCH. FEEDER CABLE HAD BLOWN IN TWO PLACES UNDER THE SUB STATION AND 20 FEET UP THE CABLE TRENCH. PEOPLE WERE INFORMED THE HOIST WAS DOWN BECAUSE OF A POWER OUTAGE. ESCAPE HOIST WAS OPERATABLE.

EE WAS PREPARING TO MAKE REPAIRS TO NO.2 VIBRATING SCREEN AT MILL CRUSHER BUILDING. WHEN DUST PARTICLES BLEW INTO EE'S RIGHT EYE. EYE BECAME IRRITATED AND EE WAS TAKEN TO SALEM MEMORIAL HOSPIT AL ER. EYE WAS FLUSHED OUT AND EE WAS GIVEN EYE DROPS CORTISTORIN TO USE 5 TIMES A DAY FOR 3 DAYS FOR A MINOR SCRATCH TO RIGHT EYE.

EE WAS ASSISTING ANOTHER WORKER TO UNCLOG A PUMP DISCHARGE LINE IN MILL. EE WAS SWINGING METAL BAR OVERHEAD STRIKING THE DISCHARGE LINE IN AN ATTEMPT TO DISLODGE STUCK MATERIAL. SEVERAL HOURS LATER, THE EE BEGAN SUFFERING LOWER BACK PAIN ANMUCH DISCOMFORT. THE EE RETURNED TO THE JOB ON WED. SEPT 23, WHEN HE REPORTED FOR WORK, THE EE CONTINUED TO COMPLAIN OF BACK PAIN. THE EE WAS TA

EE REPORTED STRAINGING HIS LEFT SHOLDER WHEN USING AN UNSAFE METHOD OF PULLING HIMSELF UPON A MOTOR TO ACCESS AN ELECTRICAL BOX.

EMPLOYEE WAS PREPARING TO REPLACE CAUTION STROBE LIGHT ABOVE MAINTENANCE SHOP LUBE PIT, USING WORK BASKET ON #63 HC2000 HYDRO CARRIER. EMPLOYEE WAS RAISING WORK BASKET,UTILIZING BASKET CONTROL S. AS EMPLOYEE POSITIONED BASKET, A HYDRAULIC HOSE RUPUTURED, SPRAYING EMPLOYEE WITH FORIEGN MATTER. EMPLOYEE IMMEADIATELY SHUT OFF THE CONTROLS AND SECOND EMPLOYEE LOWRED INJURED TO GROUND..

EMPLOYEE WAS AIR ARCHING LINES OUT OF #2 BALL MILL. WHILE WEARING A RACAL RESPIRATOR UNIT. EMPLOYEE HAD COMPLETED HIS JOB, HE LIFTED THE FACE SHIELD AND A SMALL PARTICLE OF DUST BLEW IN HIS LE FT EYE. EMPLOYEE RETURNED TO WORK ON 8-2-97.

EE WAS IN DOWN GRADE DEVELOPMENT AREA 28 MINE 213 DEV. STOPE AT APPROX. 930 AM EE ATTEMPTED TO UP RIGHT A 2 1/2" FLYGT DEWATERING PUMP. EE PULLED ON ROPE ATTACHED TO PUMP HANDLE AND FELT PAIN IN ABDOMEN AREA. PUMP WEIGHTED APPROX. 70 LBS. EE WAS SEEN BY DR DRONEY ON 6-27-97. DR REFERRED HIM TO ANOTHER DR 6-30-97 DR CRECELIUS DIAGNESED HERNIA NAVAL AREA, GOING TO HAVE SURGERY 7-22-

COMING FROM CASTEEL MINE TO VIBURNUM MILL DRIVING A ORE TRUCK EMPLOYEE BIT A DIP IN THE ROAD. HIS RIGHT ARM PULLED TO THE RIGHT ABRUPTLY CAUSING PAIN IN RIGHT ELBOW. TOOK EMPLOYEE TO DR. BOARD WINE, HE MADE A INCISION IN RIGHT ELBOW AND PACKED ELBOW WITH GAUZE.

WHEN EMPLOYEE BEGAN DRILLING PROSPECT HOLE IN BACK, LOOSE FELL FROM BACK STRIKING EMPLOYEE ON HEAD, SHOULDERS AND HANDS. DR PUT 4 STITCHES IN RIGHT HAND. X-RAYS WERE NEGATIVE.

EE WAS PUMPING UP #2 BALL MILL BEFORE STARTING MILL, WHEN HE FELT A PULL ON HIS RIGHT SIDE. EE WAS TAKEN TO DR DRONEYS OFFICE ON 5/5/97, AND WAS DIAGNOSED WITH A PULLED MUSCLE ON HIS RIGHT SIDE. EE WAS REFD TO DR BOARDWINE ON 5/28/97 RECOMMENDED PHYSICAL THERAPY ON 5/30/97. NO LOST TIME

EE WAS CUTTING OFF A 3/8 INCH BOLT WITH A HAND BOLT CUTTER. HIS HAND SLIPPED OFF HANDLE AND THE END OF THE CUTTER HIT HIS CHIN CUTTING IT. REQUIRED 3 SUTURES TO CLOSE CUT. EE RETURNED TO WORK 4-16-97.

EE WAS PULLING ON A 4" DISCHARGE HOSE, HOSE WAS FULL OF WATER, AND PUMP WAS STILL ON. EE PULLED MUSCLE IN LEFT SIDE LOWER BACK. EE WENT TO DR OFFICE ON 4-9-97. DR TOLD EE TO GO TO PHYSICAL THE RAPY ON 4-16-97 FOR ONE VISIT ON BACK SAFETY.

EMPLOYEE WAS CLIMBING DOWN A LADDER. WHEN HE GOT TO THE BOTTOM, HE TURNED TO STEP OFF ONTO A PIPE AND TWISTED HIS LEFT KNEE.

EMPLOYEE WAS RUNNING EMINCO IN SHAFT BOTTOM WHEN HE GOT HIS HEAD CAUGHT BETWEEN EMINCO AND CEILING. HE WA STHROWN FROM THE MACHINE AND GOT HIS HEAD CUT AROUND TEMPLE AREA. NEEDED 12 SUTURES TO CLOSE CUT.

EMP WAS INSTALLING GREASE HOSE ON A PUMP BARREL. HOSE NEEDED TO BE SHORTENED.EMP WAS USING A POCKET KNIFE. KNIFE SLIPPED, LACERATING LEFT PALM OF LEFT HAND. TWO SUTURES WERE PUT IN. EMP WAS RE LEASED TO RETURN TO WORK.

WHILE EMP WAS RUNNING THE MILLING MACHINE, THE MACHINE KICKED OFF AND KICKED OVERLOAD. TABLE CONTINUED TO FEED. GRABBED CONTROL WHEEL ON END OF TABLE TO STOP IT. AS HE TURNED WHEEL TO STOP MAC HINE, FINGER GOT CAUGHT BETWEEN WHEEL AND TABLE.IT WAS X-RAYES AND HAD HAIRLINE FRACTURE ON MIDDLE FINGER OF LEFT HAND. SPLINT WAS APPLIED BY DR

EE WAS CUTTING GRIZZLY FRAME, WHEN PIECE OF SLAG ROLLED DOWN INTO THE BACK OF HIS HIGH TOP SHOE. EE TREATMENT-FIRST AID. FOLLOWUP TO A ST LOUIS DR ON 08-27-96 SAID EE NEEDED SKIN GRAFTS "MEDICAL TREATMENT." (LOST TIME BEGAN 8-28-96)

EMP WAS FILLING 50 TON ORE TRUCK WITH DIESEL FUEL. THE NOZZLE WAS HIGHER THAN HEAD. DIESEL FUEL FELL IN EMPLOYEE'S RIGHT EYE. DR PRESCRIBED EYE WASH.

EMPLOYEE WAS REPLACING METAL PLATE ON RAILROAD SCALE AND PINCHED END OF MIDDLE FINGER ON RIGHT HAND. FRACTURED THE TIP.

EE WAS PULLING ON DISCHARGE HOSE, TRIPPED ON ROCK & HURT KNEE. ORTHASCOPIC SURGERY WAS PERFORMED ON 2/28/96.

EMPLOYEE WAS LOADING A TRUCK WITH A 980C REMOTE.A ROCK BOUNCED OUT OF THE TRUCK HITTING EMP ON CHIN, CUTTING THE SKIN UNDER HIS CHIN. IT TOOK FIVE SUTURES TO CLOSE WOUND.

EMPLOYEE WAS WRAPPING A LEAK ON HE FLUSH WATE RLINE. HE SLID HIS HAND OVER A WET HOSE CLAMP AND SLICED HIS RIGHT AND AT THE BASE OF THE LITTLE FINGER. THE DR APPLIED FIVE STITHCES.

WITH MANCAGE SPOTTED BELOW MINE LEVEL LANDING, EE UNDERGROUND CALLED FOR CAGE. HOISTMAN MISJUDGED LOCATION OF CAGE AND RAN HOIST FULL POWER IN WRONG DIRECTION CAUSING SUPPLY CAGE ON OPPOSITE R OPE TO CRASH INTO STEEL WORK SUPPORTING GUIDE RAILS AT TOP OF HEADFRAME HOISTMAN WAS REPLACED BY ANOTHER EXPERINECED OPERATOR. TOP OF CAGE AND GUIDE WHEEL BRACKETS WERE REPAIRED REPLACED CONV

DURING TESTIN GOF HOIST SAFETY SYSTEMS, THE LILL OVERWIND SWITCH WAS JUMPED OUT TO CHECK HEADFRAME OVERTRAVEL SWITCHES. DUE TO MALADJUSTED GUIDE WHEEL BRACKETS, THE SKIP MISSED TRIPPING THE O VERTRAVEL SWITCH AND THE SKIP WAS STOPPED JUST INCES ABOVE THE END OF THE GUIDE RAILS. WHEN ATTEMPTING TO BACK IT OUT, THE WHEEL BRACKETS CAUGHT ON TEH GUID RAIL END. SKIP WAS GUIDED BACK IN

EMPLOYEE WAS IN PROCESS OF REMOVING A SCRAPER. THE SCRAPER CAME LOOSE ON INJURED'S END. WHEN HE REACHED TO STEADY HIS END OF SCRAPER IT CAME UP CATCHING INJURED'S THUMB ON HIS LEFT HAND BETWEEN BEAM AND SCRAPER. EMPLOYEE WAS INJURED ON SAT. OVERTIME SHIFT, RETURNED TO WORK ON REGULARLY MON. SCHEDULED SHIFT.

FUSE BLEW ON EMERGENCY HOIST. HOIST WAS DOWN ONE HOUR & A HALF. PORTABLE HOIST WS TAKEN TO GOLF COURSE VENT HOLE & SET UP. COULD FIND NO REASON FOR BLOWN FUSES.

EE WAS REMOVING OLD BUSHING FROM A 980C LIFT ARM ASSEMBLY USING A HAMMER AND CHISEL. A PIECE OF METAL FROM THE CHISEL BROKE OFF AND EMBEDDED IN HIS STOMACH. DR. REMOVED PIECE OF METAL.

EE WAS DRIVING 50 TON ORE TRUCK OVER ROUGH ROAD & FELT PAIN IN HIS BACK. ALSO FELT POP IN BACK. THERE WERE POT HOLES IN THE ROADWAY. WENT TO DOCTOR & STARTED PHYSICAL THERAPY 6/23/94, HE CONTI NUED THERAPY ON 6/27 & 6/30/94.

EMPL INSPECTING STAIRS AND WALKWAY PREPARING TO REPAIR LOOSE STEPS.WALKWAY COLLAPSED ALLOWING EMPL TO FALL 7' TO FLOOR. TROUGHING IDLER STRUCK EMPL ON ANKLE INJURING LIGAMENTS.LOST TIME BEGAN 7-14-92.

WHILE PRYING OFF RETAINING STRAP ON SCREEN RODS, BAR SLIPPED PINCHING FINGER BETWEEN BAR AND SCREEN RODS.

DOOR ON CAB WOULD NOT LATCH. WHEN EMPLOYEE TRIED TO SLAM DOOR, HE CAUGHT HIS FINGER BETWEEN FRAME AND DOOR PINCHING HIS FINGER. (DR. PUT A FINGER SPLINT ON FINGER).

THE #1 EMPLOYEE WAS RETURNING FROM CASTEEL WITH A LOAD AND THE #2 EMPLOYEE WAS RIGHG BEHIND HIM.AS THE #1 EMPLOYEE WAS GOING AROUND THE LAST TURN GOING INTI #28 THE #2 EWWMPLOYEE CONTACTED THE #1 EMPLOYEE ON THE RADIO AND GOT HIM STOPPED AT THE DUMP SITE.#1 EMPLOYEE QUICKLY GOT OUT OF TRUCK AND WITH THE HELP OF OTHERS ALMOST GOT THE FIRE OUT. UNFORTUNATELY THE ENGINE WAS STILL RUNN

EMPLOYEE WAS STACKING BRUSH ON A HILL SIDE, SLIPPED AND FELL STRIKING RIGHT KNEE ON TREE STUMP.

I NAME WAS CUTTING A PIECE OF ANGLE IRON THE BLADE CAME OFF OF THE PIECE HE WAS CUTTING & FORWARD MOTION CUT THE TOP OF HIS THUMB

I,NAME WAS CHECKING VOLTAGE AT A SWITCH BOX, WHEN HIS TESTER CONTACTED A LOOSE CONNECTION, A FLASH RESULTED, BURNING HIS LEFT HAND.

CRAWLING OUT OF END OF MILL PUT HAND ON FAN TO SUPPORT SELF HIMSELF WHILE GETTING OUT FAN FELL OVER ANC CUT HIS INNER EAR TO FAN AS HE FELL TO FLOOR

INJURED WAS UNLOADING 1 12" PIPE OFF OF A FOUR WHEEL WAGON,THE PIPE SLIPPED CATCHING HIS LEFT RING FINGER BETWEEN THE WAGON AND THE PIPE.

EMPLOYEE WAS SPREADING BUCKET ARMS WITH HYD. RAM AND WOODEN BLOCK, THE BLOCK FELL HITTING HIM ON THE LEFT FOOT SMASHING LITTLE TOE ON LEFT FOOT.

EMPLOYEE WAS INSTALLING A NEW HOIST CYLINDER ON WAGNER WHEN THE HOIST CYLINDER PIN WAS PULLED. HIS FINGER WAS CAUGHT BETWEEN PIN AND FENDER OF STS.

EMPL WAS REBUILDING PUMP HE REACHED DOWN TO PICK UP BOWL & PULLED MUSCLE IN BACK.

EMPLOYEE WAS SURVEYING A HEADING WHEN A BOULDER SLID ON A ROCK PILE STRIKING MAN'S FOOT.

HE WAS WALKING DOWN THE SPILLWAY AT THE OLD SLIME DAM WHEN HE TWISTED HIS R KNEE

I.NAME WAS MIXING SODIUM CYANIDE, A LARGE WAD FELL OUT OF THE BARREL AND SPLASHED A SMALL PORTION UNDER HIS FACE SHIELD, EMPLOYEE HAD A MILD BURN TO THE LEFT SIDE OF HIS FACE.

TRUCK HAULING ORE FROM MINE TO PLANTSITE.TRUCK CAUGHT ON FIRE,OPERATOR JUMPED FROM VEHICLE.TRUCK BURNED -TOTAL LOSS.OPERATOR OK.

EMPLOYEE WAS DRIVING A ORE TRUCK FROM MINE #35 TO VIBURNUM MILL. THE TRUCK CAUGHT FIRE, AND HE WAS FORCED TO JUMP FROM THE CAB TO THE GROUND. HIS BACK WAS SORE.

WHILE PLACING BLOWER ON F RAME INJUREDS HAND WAS CAUGHT BETWEEN BLOWER & FRAME.

EMPL WAS LETTING CLOTHS BASKET DOWN IN #28 MINE CHANGE ROOM PIECE OF RUSTY STEEL CAME OFF OF CHAIN FALLING INTO HIS EYE.

EMPLOYEE WAS LIFTING FULL CORE TRAYS UP AND OVER PLACEING THEM ON ROLLER RACKS WAIST HIGH AND FELT A PULL IN HIS RIGHT SHOULDER.

EMPLOYEE WAS CUTTING BRUSH, WHEN SHE CAME IN CONTACT WITH A POISON IVY PLANT, RESULTING IN A RASH ON HER LEFT FOREARM.

WHILE MOVING A DESK UP STEPS IN MINE #28 OFFICE AREA, THE DESK SLIPPED OFF A DOLLY CAUSING INJURED TO STRAIN HIS RIGHT HIP.

I.NAME WAS CHECKING TRANSMISSION UNDER SCALER & HE ASK I.NAME TO START IT UP THE SCALER JUMPED FORWARD THE LEFT TIRE HIT THE EMPLOYEES LEFT ARM

BRAKE WEAR LIMIT SWITCH TRIPPED SHUTTING DOWN HIOST. BRAKE ADJUSTING DRAWBAR IN PIT FOUND BROKEN. DRAWBAR WAS REPLACED AND MEN HOISTED TO SURFACE AT 7:30 PM.

EMPLOYEE WAS SC5LING AN AREA WITH A DRILL, WHEN A ROCK FELL HITTING EMPLOYEE ON THE RIGHT HAND.

HOISTMAN REPORT9D HOIST MOTOR WOULD NOT LIFT LOADED SKIP COIL ON MAIN 2300 VOLT CONTACTOR WAS BURNED OUT REPLACED & HOIST RETURNED TO OPERATION AT 1150AM

MAN WAS REMOVIN1 OLD TRUCK BED WITH A WRECKING BAR HE WAS PULLING TOWARD HIS BODY, THE BAR SLIPPED HITTING HIM IN THE RIBS. MAN DID NOT GO TO DR UNTIL 10 23 87

EMPL POSITIONIN1 MOTOR ON FRAMEWORK OF NEW 8'' GALIGHER PUMP IN ANNEX BLDG. CABLE SUPPORTING MOTOR CAME IN CONTACT WITH 440V ELEC LINE CAUSING ELEC SHOCK TO EMPL.

EMP 3 L POSITIONING MOTOR ON FRAMEWORK OF 8'' GALIGHER PUMP IN ANNEX BLDG.CABLE SUPPORTING MOTOR CAME IN CONTACT WITH 440V ELEC LINE CAUSING ELEC SHO CK TO EMPL 3

EMPLOYEE LIFTED3A HEAVY FEEDER CHAIN OUT OF A VIBRATING FEEDER AND PULLED A MUSCLE IN HIS LEFT FOREARM.

I.NAME WAS LOAD3NG A PIECE OF STEEL ON A TRUCK THE STEEL GOT STUCK THEN HE SLIPPED JERKING HIM OFF BALANCE CAUSING HIS BACK TO HURT

EMPLOYEE WAS US3NG A 10 FT PIECE OF 3/4 IN PIPE ON THE END OF A HOSE TO UNCHOKE FINE ROCK CHUTE BEHIND DRUM GRIZZLEY AT CRUSHING PLANT DUST FROM AIR CAUSED EMPLOYEES THROAT TO BECOME SORE

I NAME WAS STAN8ING ON LINER BOLTS PROTRUDING THROUGH THE MILL,TAKING OUT GUARD BOLTS WHEN HIS FOOT SLIPPED AND HE FELL 5 FEET,STRIKING MOTOR GUARD.(AT THE TIME,THE EMPLOYEE SAID HE WASN'T HUR T AND DID NOT W3SH TO SEE A DOCTOR.EMPLOYEE WAS TAKEN TO A DOCTOR ON 7/28/879

I.NAME GOT ON F2RKLIFT,ON LOADING DOCK AND MOVED SOME PALLETS AND WHEN HE GOT OFF FORKLIFT HIT SFOOT SLIPPED AND GOT A CATCH IN HIS LOWER BACK.IT WAS RAINING AND THE DOCK WAS WET.

I.NAME WAS CUTT3NG THE CHANNNELS OFF A 950 LOADER WHEN HIS TORCH FLAME EXPLODED A CAN OF PENETRATING OIL SITTING BEHIND HIS WORK FIRST DEGREE BURN LEFT SIDE OF FACE

I NAME WAS BRIN1ING SCALER INTO SHOP TO BE REPAIRED WHEN WELD BROKE LOOSE ON CANOPY AND BOOM PUSHED CANOPY DOWN ON ROOF MAN HEAD HE STRAINED MUSCLES AROUND HIS NECK.

THE MAN WAS STR3PPING POWER CABLE FOR COPPER ROUGHER FROTH PUMP, WHEN HIS KNIFE SLIPPED CUTTING HIS MIDDLE FINGER AND I NDEX FINGER ON LEFT HAND

EMPLOYEE WAS WA5KING OUT OF THE MILL AREA TALKING TO I.NAME WHEN HE WALKED INOT A LADDER

EMPLOYEE WAS PI7KING UP TOOLS & ROLLING UP A AIRLINE HOSE THE AIR LINE HOSE WAS UNDER PRESSURE AIR LINE CAME INTO & QUICK DISCONNECT STRUCK EMPLOYEE OVER THE EYE

WET SPOT ON CON5RETE FLOOR AND THE WATER HAD SOME ZINC SULPHATE AND STARCH IN IT. EMPLOYEE FELL, INJURED HIS LOWER BACK.

LIFTING A BAG O0 CHEMICALS TO DUMP INTO A MIXING VAT.

WEDGING TWO PIE7E OF METAL APART, DEVELOPED TOO MUCH PRESSURE BETWEEN THE TWO PIECES AND WEDGE BECAME A PROJECTILE.

SWITCH WAS TURN9D OFF BUT SECOND SWITCH TO SET OF OIL POTS WAS NOT TURNED OFF. STARTED TO MAKE SPLICE IN 2300 VOLT CABLE WHEN HE SUFFERED FLASH BURNS TO FACE AND EYES.

DILODGING OVERS3ZE ROCK BETWEEN TAIL PULLEY AND BELT. HOLDING LENGTH OF STEEL BAR WHILE ANOTHER MAN USED A 6 LB. SLEDGEHAMMER. THE HAMMER MISSED THE BAR AND HIT HIS LEFT MIDDLE AND RING FINGER S CAUSING LACER5TION AND POSSIBLE FRACTURE.

HOIST MAN WASHE8 DOWN FLOOR. WATER PENETRATED EMERGENCY BRAKE ELECTRICAL COIL SHORTING IT OUT. COIL WAS REPLACED, HOIST RETURNED TO OPERATION AT 10:45PM.

HAND SHOVELING 8PILLAGE ROCK IN BOTTOM OF SHAFT INTO MUCK BUCKET AND CLAIMS HE OVEREXERTED HIMSELF. PAIN IN UPPER BACK.

WHILE TIGHTENIN1 BOLT IN 12" OPIPE FLANGE THE WRENCH SLIPPED OFF BOLT HEAD & H E RECEIVED SMALL CUT & BUMP ON HEAD. HAD STITCHES.

POWER LINE FEEDING BALL MILL MOTOR SHORTED OUT.WHEN IT DID IT CAUSED VOLTAGE DIP ON WHOLE POWER SYSTEM. TWO 2300 VOLT FUSES FEEDING HOIST MOTOR OPENED UP.THEY WERE REPLACED AND HOIST RETURNED TO SERVICE AT 11:00 PM.

WAS LOADING ROCK U/G WHEN BRACES ON BACK OF SEAT BROKE POPPING HIS NECK.

WAS CHANGING TRIKING BAR ON MACHINE USING A BALL PEIN HAMMER TO BREAK COUPLING LOOSE WHEN HE STRUCK BY A PIECE OF STEEL INT HE CHEST.

HAMMERING ON RETRACT PIN TRYING TO PUT A NEW PIN IN WHEN PIECE OF METAL CHIPPED OFF AND LODGED IIN FRONT OF NECK

HOIST LOST ALL POWER. WE FOUND 2 HIGH VOLTAGE FUSES BLOWN ON MAIN INCOMING POWER. THE CONTACTS ON THE HIGH VOLTAGE HOIST CONTACTOR HAD BEEN CHANGED ON 4-23. ONE OF THE TAPPED HOLES IN FRAME T HAT RECEIVES TJE BOLT FOR CONTACT IN HAD BAD THREADS. WHEN THE BOLT TIGHTENED IT ONLY STRIPPED OUT LEAVING CONTACT LOOSE. REPLACED CONTACTOR RETURN HOISTING 4:42 PM.

HOIST FAILED TO MOVE WHEN CONTROLLOR POSITION MOVED. ELECTRICIAN FOUND ONE TOTALLY ENCLOSED AUXILARY CONTACT SHUT & STUCK. HE FREED IT & HOIST RETURNED TO OPERATION AT 8:55PM.

SOUTH SKIP HAVE IN HEADFRAME SOUTH ROPE UNCOLLED WHEN HOISTMAN NOTE LOOSE ROPE HE ATTEMPED TO STOP HOIST. BRAKE DID NOT HOLD SENDING NORTH SKIP BACK TO BOTTOM OF SHAFT. THIS SNAPPED SOUTH RIPE INTO AS I T BECAME ENTRANGLED WITH NORTH ROPE. HOIST REUTRNED FTO NORMAL OPERATION 11:30 P.M. 104-10-85

HYDRALIC HOSE FEEDING HOIST BRAKE SYSTEM BROKE.SYSTEM LOST PRESSURE AND BRAKE SET.POWER ON HOIST UNTERRUPTED BY SWITCH SENSING LOSS AT BRAKE PUESSURE.HOSE WAS REPLACED AND HOISTING RESUMED AT 9:05 PM

HYDRAULIC HOSE FEEDING CONTROL VALVE ON HOIST BRAKE BURST. BRAKE IMMEDIATELY SET AND HOIST POSER WAS STOPPED BY LACK OF BRAKE OIL PRESSURE. A NEW HOSE WAS MADE AND INSTALLED. HOIST OPERATIONAL AT 3:10 P.M.

WHILE DRIVING PIN OUT OF DIPPER BOOM WITH 8 LB SLEDGE HAMMER AND PRY BAR, HE MISSED THE BAR WITH THE HAMMER AND HIT FINGER BETWEEN BAR AND HAMMER HANDLE, BREAKING INDEX FINGER ON RIGHT HAND.

HOIST LOST ALL POWER, TWO RELAYS THAT ENERGIZE THE MAIN CONTACTORS THAT HOIST AND LOWER WERE OPERATING ERRATICALLY. AT 11:00 AM AFTER REPAIRING A COIL AND MAKING SURE ALL SAFETIES WERE FUNCTIO

EMPLOYEE WAS PUNCHING ON BOULDER IN CRUSHER WHILE GRIZZLY WAS RUNNING.ROCK HIT PUNCHING BAR FORCING HAND INTO METAL RAILING,CUTTING RING FINGER AND BREAKING TIP OF FINGER.

A SMALL RETAINE9 CLIP ON THE MECHANICAL INTERLOCK LINKAGE ON THE MAIN HOIST CONTRACTOR BROKE. THE LINKAGE CAME APART PREVENTING OPERATION OFTHE CONTRACTOR. THE LINKAGE WAS REASSEMBLED THE CL IP REPLACED AND3HOIST RETURNED TO OPERATED AT 12:50 AM.

CHARGING FACE WITH AN-FO EXPLOSIVE WHEN STRUCK ON BACK BY FALLING PIECE OF LOOSE ROCK CAUSING BRUISE THE LOWER BACK.

WAS STRUCK BY A COFFYING HOIST HANDLE WHILE HELPING TO CHANGE RAIL IN VIB #28 SHAFT CUT ON LEFT SIDE OF HEAD THAT REQUIRED 5 STITCHES

CLEARING BRUSH FOR A SURVEY LINE WITH CHAIN SAW, WHEN THE SAW SLIPPED AND CAME IN CONTACT WITH HIS LEFT LEG, CAUSING LACERATION JUST BELOW KNEE. REQUIRED STITCHES.

EMPLOYEE WAS WALKING DOWN STAIRS BY #1 CONVEYOR AND STEPPED ON SMALL ROCK ON FLOOR AT END OF STEPS. HE TURNED HIS LEFT ANKLE. HAS SPRAIN AND POSSIBLE AND SMALL BONE FRACTURE.

WHILE HAULING ORE FROM #29 MINE ON THE SURFACE, IN A 50-TON WABCO TRUCK, HE MET AN EMPTY 50-TRUCK ON A SECTION OF THE HAULAGE ROAD THAT WAS TOO NARROW FOR THE TWO TO SAFELY PASS. THEY COLLID ED RESULTING IN CUTS ON HEAD AND LEFT ELBOW THAT REQUIRED STITCHES.

EMPLOYEE ACCIDENTLY HIT UP CONTROL IN BASKET OF HYDRO CARRIER WHILE DRILLING HOLE IN BACK FOR EYE BOLT TO HANG A FAN BASKET CAUGHT HIS RIGHT HAND AGAINST ROCK DRILL HANDLE LACERATING TENDON AN D FRACTURING INDEX FINGER OF RIGHT HAND

LEAVING CHANGEHOUSE,TRIPPED ON STEP AND FELL OVER TRASH CAN.WEARING NEW PAIR OF SAFETY SHOES WITH HIGHER HEEL THAN USUAL.CUT UPPER LIP AND BROKE OFF LOWER FRONT TOOTH.

USING POCKET KNIFE TO CUT SMALL PIECE OF RUBBER.WAS PULLING KNIFE TOWARD HIMSELF AND CUT PALM OF LEFT THUMB-REQ A FEW STITCHES.

OPENING ELEC OVERHEAD DOOR,LOST BALANCE AND PUT LEFT HAND BETWEEN DOOR AND DOOR GUIDE CUTTING AND BRUISING LEFT INDEX FINGER.LOSS OF NAIL.PALLET OF CYLINDERS IN FRONT OF SWITCH,HAD TO LEAN OVE R TO REACH SWITCH.

INSTALLING PIPE NIPPLE ON DISCHARGE OF 8\\ PUMP.USING COFFING HOIST TO PULL PIP IN PLACE.HAD TIGHTENED PIPE AND REACHED BACK TO GET HAMMER TO MOVE PIPE INTO PLACE.WHEN HE REACHED OVER TO BACK SIDE OF PIPE,HOIST SUDDENLY RELEASED,HANDLE STRUCK ABOVE RIGHT EYE.

SOME ROCK REMAINED IN SKIP WHEN DUMPED INTO SURFACE ORE BIN.THIS PREVENTED SKIP BOTTOM FROM CLOSING AND SKIP HUNG IN HEADFRAME.UNAWARE OF HUNG SKIP HOISTMAN PULLED LOADED SKIP 100\ UP SHAFT BE FORE REALIZED ERROR.THIS UNREELED ROP INTO HOIST PIT CAUSING SLACK ROPE CONDITION ON SKIP THAT WAS HUNG IN HEADFRAME.

REPLACING ENGINE HEADS ON CHEVROLET 1/2 TON PICK UP , WHEN HE JUMPED OFF TRUCK TO CONCRETE FLOOR. ON 7-13-83 HE REPORTED THAT HE HAD HURT HIS RIGHT KNEE, ON 7-18-83 HE WENT TO DOCTOR.

OIL WAS PRESENT ON THREE FOOT STEP LADDER. EMPLOYEE WAS WORKING ON 631 TRUCK AND FOOT SLIPPED OFF OF LADDER, CAUSING HIM TO FALL STRIKING HIS BACK AND BUTT AND ALSO SKINNED HIS RIGHT ELBOW.