BROOKSVILLE QUARRY Metal/Non-Metal

EE WAS PICKING UP ROCKS ON CATWALK. RIGHT FOOT SLIPPED THROUGH HOLE OF CATWALK SKINNING LEG & LEFT PAIN IN KNEE.

EMPLOYEE WAS HOLDING BOLT IN RIGHT HAND FOR ANOTHER EMPLOYEE TO HIT WITH A 20 LB HAMMER TO DRIVE OUT ANOTHER BOLT THAT WAS STUCK. HAMMER GLANCED OFF OF BOLT HEAD AND STRUCK HAND.

EMPLOYEE WAS CLIMBING DOWN THE STEPS OF THE DOZER. HE LOOKED UP TO SEE WHERE THE OTHER PAN WAS AND WHEN HE DID HE MISSED A STEP AND CUT HIS RIGHT SHIN ON THE STEP.

EMPLOYEE PULLING BIN GATE LEVER. LEVER MOMENTARILY STUCK AND HE JERKED ON IT, STRAINING BACK.

EMPLOYEE WAS APPROACHING EAST SIDE OF HOPPER WHILE PERFORMING MAINTENENCE. WHEN HE LIFTED HIS RIGHT LEG TO ENTER THE HOPPER HIS LEFT FOOT SLIPPED OUT FROM UNDERNEATH HIM ON THE SLIPPERY MATERI AL, AND BOTH FEET SLIPPED OUT FROM UNDERNEATH HIM. HE WENT DOWN WITH HIS LEGS APART AND HIS KNEES BENT. HE FELT PAIN IN LEFT ANKLE WHEN HE LANDED.

WHILE GETTING OFF FRONT END LOADER, EMPLOYEE SLIPPED OFF BOTTOM STEP.

REOCCURANCE OF OLD INJURY.

WHEN LIFTING COVER TO DRAIN AIR TANKS ON HAUL UNIT EMPLOYEE SAID BACK POPPED CAUSING PAIN TO LEFT LOWER SIDE AFTER MEDICAL ATTENTION EMPLOYEE WAS FOUND TO HAVE ACUTE CERVICAL & LUMBOSACRAL ST RAIN WITH SPASM

EMPLOYEE STEPPED UP ON 16" PIPE PUSHING OFF WITH RIGHT LEG. RIGHT KNEE BUCKLED.

EMPLOYEE WAS PUTTING PIN IN TRUCK BODY TO HOLD BED UP. WHEN PIN WENT IN HOLE, SHOULDER ON PIN MASHED THE END OF HIS LEFT PINKIE FINGER.

EMPLOYEE WAS OPERATING THE PAN. WHEN HE LOOKED BACK, THE STEERING CYLINDER HYDRAULIC LINE BUSTED AND SPRAYED OIL IN HIS FACE.

EE WAS AT THE SECONDARY CRUSHER SHOVELING ROCK WHEN HE ALLEGEDLY PULLED SOMETHING IN HIS RIGHT GROIN AREA.

EE WAS HITTING A WEDGE WITH A 4LB HAMMER A SMALL PIECE OF METAL CAME OFF OF THE WEDGE MAKING SMALL PUNCTURE TO INSIDE OF LEFT ARM.

EMPL ADJUSTING ENGINE GOVERNOR ON WELDER AND FINGERS GOT CAUGHT IN THE FAN BLADES.EMPL BROKE INDEX,2ND AND 3RD FINGER RIGHT HAND.ALSO RECEIVED STITCHES BETWEEN 2ND AND 3RD FINGERS.

WHILE MOVING A PIECE OF STEEL EMPLOYEES RT HAND SLIPPED ALLOWING THE PLATE TO FALL ON HIS LEFT MIDDLE FINGER

EMPLOYEE WAS LEANING AGAINST THE SHACK WHEN THE WIND BLEW THE SHACK DOOR AGAINST HIS HAND

EMPLOYEE WAS CLOSING THE GARAGE DOOR AT THE LOADOUT OFFICE. HE REACHED UP WITH RIGHT HAND TO PULL IT DOWN AND WHEN HE DID HIS RIGHT MIDDLE FINGER WENT BETWEEN THE DOOR SECTIONS WHICH CLOSE AS THE DOOR IS LOWERED, RESULTING IN PINCHED FINGER

EMPL WAS CROSSING 1A BELT TO DO SOME WELDING ON PIPE LINE. WHEN HE STEPPED ON BELT FEET SLIPPED FROM UNDER HIM. HE GRABBED HANDRAIL & STRAINED SOMETHING IN RIGHT SHOULDER.

EMPL WAS INSTALLING TOGGLE BOLT & SPRING ON PRIMARY CRUSHER. GUIDING SEATING PLATE INTO PLACE SPRING HUNG UP & WHEN IT CAME LOOSE IT THREW SEATING PLATE UP. WHEN IT CAME BACK DOWN IT PINCHED T WO RING FINGERS.

EMPLOYEE WAS KNOCKING A SPROCKET OFF OF A SHAFT WITH A 4 LB HAMMER A PIECE OF METAL BROKE OFF OF THE SPROCKET & CUT HIS LOWER LIP EMPLOYEE HAD TO GO TO EMERGENCY ROOM TO GET T HE METAL TAKEN O UT & GET TWO STITCHES

EMPLOYEE WAS TROUBLE SHOOTING DRILL FOR UNKNOWN OIL LEAK HE HELD UP THE HOSE SO HE COULD SEE BETTER & TOLD HIS H ELPER TO OPERA TE THE CONTROL WHENHE DID THIS OIL SPRAYED FROM THE H OSE & STR UCK EMPLOYEE ON LEFT INDEX FINGER APPARENTLY INJECTING OIL INTO FINGER ACCIDENT OCCURRED 092988 BUT THERE WAS NO MEDICAL TREATMENT RENDERED UNTIL 100788

EMPLOYEE WAS HELPING UNLOAD TRUCK WHEN HE APPARENTLY SUFFERED HEAT EXHAUSTION CAUSING HIM TO PASS OUT AND STRIKE HIS HEAD ON DELIVERY TRUCK BUMPER.

CREW EMP WAS WO9KING WITH HAD JUST FINISHED A JOB. HE WAS PICKING UP THE TOOLS TO LOAD ON THE TRUCK. HE GENT OVER AND PICKED UP A 1 1/2 TON CHAIN JACK AND 4 LB HAMMER. WHEN HE STARTED RAISIN UP, HIS BACK S7ARTED HURTING AND HE COULD NOT RAISE UP

EMPL PUSHING ON3PIECE OF TIN WITH SECTION OF ANGLE IRON.TIN FOLDED UP IN MIDDLE AND END OF IT SWUNG AROUND AND CUT EMPL FINGERS.

EMPLOYEE WAS TA5ING A BROKEN DRIVE SHAFT OUT OF A TRUCK WHERE IT BROKE IT WAS ALL JAGGED THE END OF THE DRIVE SHAFT WHIPPED AROUND AND MADE A LOT OF OTHER SHARP EDGES ON OTHER PARTS EMPLOYEE W AS HOLDING THE 9ND OF THE DRIVE SHAFT UP WHILE HE WAS LOOSENING SOME BOLTS AND HE CUT HIS LEFT THUMB ON SOMETHING

INJ WAS CHANGIN1 OUT SIDEBOARD RUBBERS ON #3 CONVEYOR WHERE #4 CONVEYOR MEETS IT. HE WAS WORKING ON OPPOSITE SIDE OF CONVRYOR WHERE THERE IS NO CATWALK. HE HAD ONE FOOT ON UPRIGHT POST AND TH E OTHER FOOT ON3THE CONVEYOR FRAME. MUD AND MOISTURE WERE BUILT UP ON THE CONVEYOR FRAME. HE MOVED TO GET A BETTER POSITION ANFD FELT HIMSELF SLIPPING. HE DIDNT HAVE A SAFETY LINE ON AT THE TI

EMP WAS COMING 6ACK FROM GEN PORT PROPERTY AND RAN INTO AND OVER THE BOULDER BARRICADE ALONG THE EDGE OF THE RADAR PIT AND A DISTANCE OF 145 FT BEFORE HE WENT THROUGH IT ACROSS A LEVEL CLEARD SPACE APPROX 303FT WIDE OVER SHALLOW EMBANKMENT ABOUT 15 FT HIGH ONTO ROCK LEDGE BELOW AND OVER THAT TO THE PIT FLOOR ABOUT 60 FT BELOW TRUCK LANDED UPRIGHT LEFT FRONT WHEEL WAS BROKEN OFF AND

EMPL KNOCKING W9DGE OUT OF CROWS FOOT ON DRAGLINE.PIECE OF STEEL CAME OFF HAMMER AND FLEW INTO UPPER LEFT ARM.

PICKING UP ROCK FROM UNDER BELT WHILE THROWING ROCK BACK ON BELT CAUGHT FINGER BETWEEN ROCK AND ANGLE IRON STEP SUPPORT. LACERATED LEFT INDEX DINGER.

HE WAS CLIMBING DOWN LADDER ON BOXCAR WITH T.V. ANTENNA IN HIS LEFT HAND. HE THOUGHT IT WAS NOT THAT FAR TO THE GROUND, SO HE JUMPED DOWN WITH BOTH FEET WHILE HOLDING ONTO THE LADDER WITH HIS HAND. IT WAS FARTHER TO THE GHROUND IT SLIPPED OFF THE LADDER AND FELL TO THE GROUND AND LANDED ON HIS BACK.

SHOVEL OPERATOR WAS ON OFF SIDE OF NW SHOVEL AND CAME BACK TO OP CAB.EMPL STANDING ON FRONT DRUNM WASHING SHOVEL BOOM.OP ENGAGED DRUM WHICH CAUSED CABLE TO MASH FOOT AGAINST DRUM.