Eden Plant Metal/Non-Metal

Rip Rap Chute plugged up, employee reached in to pull on rock. Rock jam broke lose, and pinched right hand middle finger. Finger was cut, hospital cleaned the wound and stitched the cut.

2 PEOPLE LIFTING GRINDER FROM BACK OF TRUCK AND LOWERING TO CONCRETE PAD.

EE WAS WALKING FROM ONE AREA TO ANOTHER AND TRIPPED WHILE TRYING TO PREVENT A FALL, HIS HAND SLIPPED OFF CENTRAL CONTROL PANEL AND HE FELL ON LT. HAND, ELBOW, SHOULDER, HIP, TWISTING HIS LOWER BACK.

INSTALLING BOWL ON CRUSHER. LIFTING LUG (ATTACHED TO BOWL) CAUGHT AND PULLED PANT LEG BETWEEN LUG AND HYDRAULIC RAM. LEFT LEG MASHED BETWEEN RAMAND CRUSHER BOWL.

THE WEATHER WAS VERY WINDY. EE WAS DIPPING PIT IN 952 ENDLOADER. WHILE LIFTING BUCKET OF HOT MATERIAL, WIND BLEW STEAM ONTO HIM THROUGH DOOR.

EE WAS TRYING TO HIT ADJUSTING WEDGE: HE WAS CHOKING HAMMER CLOSE TO THE HEAD & HIS FINGER GOT BETWEEN WEDGE & HAMMER CAUSING HIS FINGER TO BE CAUGHT & SMASHED.

TRYING TO LINE UP SCREW THAT OPENS THE DOOR ON SURGE TANK SO IT COULD BE WELDED. ANOTHER EE ENERGIZED SYSTEM TO EXTEND SCREW SO IT COULD BE WELDED. SCREW EXTENDED & BOLT ON COUPLING CAUGHT BOTTOM OF PANTS PULLING LEFT FOOT UP. BOLT WENT DOWN INTO BOOT BESIDE ANKLE & PULLED FOOT UP.

EE ALLEDGES HE TRIPPED ON CATWALK WHILE WALKING.TOE OF RT. BOOT CAUGHT ON OVERLAPPING PIECE OF CATWALK. EE CAUGHT HIMSELF ON HAND RAILINGS, PULLING LEFT SHOULDER, TO AVOID A FALL.

EE FELL AGAINST LINES AS HE WAS THREADING FLEXIBLE LINE THRU 2 METAL LINES WHEN FLEXIBLE LINE JAMMED BETWEEN METAL LINES. FELL FORWARD-LEFT INDEX FINGERTIP MASHED AND LACERATED BETWEEN METAL L INES ON SMALL METAL PIECE.

EE WAS MAKING HIS ROUNDS. STEPPED DOWN 1 STEP TWISTING ANKLE (RT.) FALLING ON LT. SIDE. EE SAWWATER HOSE BUT DOES NOT THINK HE TRIPPED ON IT.

DESCENDING STEPS AT KILN DECK WHILE CARRYING EQUIPMENT IN ARMS. SLIPPED ON SOLITE ON STEPS AND FELL ON BACK AND SHOULDER AND TWISTED RIGHT KNEE.

RIGHT FOOT SLIPPED ON FROST COVERED LADDER RUNG. TRIED TO CATCH HIMSELF FROM FALLING RE-INJURING RIGHT SHOULDER. RIGHT ROTATOR CUFF RE-INJURED.

HOLDING WATER LINE IN LEFT HAND. TRIED TO CUT LINE WITH KNIFE IN RIGHT HAND, KNIFE SLIPPED AND CUT LEFT FOREARM.

EE BECAME OVERHEATED, BECAUSE OF HIGH TEMP AND HUMID CONDITIONS, BECAME DEHYDRATED. WAS WORKING OUTSIDE.

HE IS A DIABETIC AND HSI MEDICINE HAS JUST RECENTLY BEEN CHANGED THIS AM. HIS BLOOD SUGAT DROPPED AND HE FELL WHILE IN THE CHANGING ROOM, HITTING HIS HEAD AND NOSE. (POSSIBLE BROKEN NOSE) HE H AD 13 STITCHES ON A CUT HE RECEIVED FROM THIS FALL.

GOING DOWN GRADE UNDER KILN - LOST CONTROL OF THE CRANE. ELECTRICAL AND MECHANICAL FAILURE TURNED INTO THE BANK TO STOP CAUSING CRANE TO OVER TURN.

WHILE POURING CONCRETE ON #4 KILN HE PULLED HIS BACK OUT.

EE HIT HIS STOMACH ON THE STEERING WHEEL KNOB WHEN THE LOADER HIT A ROCK.

HE WAS REMOVING A CUTTING EDGE FROM LOADER & THE CUTTING EDGE DROPPED ON HIS LEFT FOOT.

WAS WALKIGN AND FOOT SLIPPED BETWEEN TWO PIECES OF METAL. CUT RIGHT AND LEG ANKLES.

WAS BRICKING NO.1 KILN. BRICK SLIPPED AND CAUGHT LEFT RING FINGER BETWEEN SHIELD AND BRICK.

ATTEMPTING TO START ELECTRIC MOTOR. STARTER ARCED AND FLASHED. BURN TO RIGHT ARM.

HE WAS STANDING ON THE CAT WALK - A ROCK FELL FROM THE SCREEN & HIT HIS HAND - MASHING HIS PINKYFINGER ON THE RIGHT HAND.

WAS WALKING AND FELL OVER A SMALL ROCK. HURT HIS LEFT FOOT.

EMPLOYEE WAS RUNNING THE SHOVEL. HE PULLED THE WINDOW UP AND DID NOT SECURE IT. THE WINDOW FELL ON HIS LEFT HAND AND HE CUT IT.

HE WAS WELDING ON 4 KILN HOOD AND FELL.

HE WAS PICKING UP A BAG OF CASTABLES & HURT HIS BACK.

HE WAS CUTTING PIECE OF METAL AND PUT HIS ARM DOWN AND HIT THE METAL. A PIECE OF THE METAL WENT INTO HIS LEFT FOREARM.

ROLLING WHEELBARROW IT TURNED OVER HURT INDEX FINGER

ENERGINZING A DISCONNECT AND IT SPARKED

WAS WALKING & A METAL SCREEN FELL ON HIM METAL SCREEN HIT HIS ARM

REACHED UP WHEN WALKING AND CAUGHT RING ON METAL TOP OF ROOF.

WAS WALKING DOWN A HILL IN THE FINISHING DEPT AND TURNED ANKLE RIGHT ANKLE.

WELDING ON #1 KILN AND BURNT EYES.

ASSISTING ON REPAIR OF #1 KILN ELEVATOR AND FELL ON SOME ROCKS AND HURT HIS BACK.

WAS HAMMERING ON A PEN AND THE PEN BROKE AND A PIECE OF METAL WENT INTO HIS FINGER ON HIS LEFT HAND.

REPAIRING CONVE2OR SYSTEM WHEN SOMETHING GOT INTO LEFT EYE.