Helotes Quarry Metal/Non-Metal

On 10/29/24, an employee was walking in the surge tunnel when EE slipped and fell. The employee sought medical attention and was diagnosed with a left elbow and left shoulder sprain. EE was issued restrictions and OTC medications.

In the process of removing a 990 loader bucket tooth with a soft metal hammer, a fragment of the tooth superficially entered the employee's chest. In order to remove the metal fragment, surgery is required.

While washing material from a plugged crusher, the material flowed into the employee's legs, causing employee to fall to the same level. Diagnosed with concussion without loss of consciousness, strain to neck muscles, and contusion on arm and scalp.

While drilling out a cable fitting the drill bit pierced the employees glove and the outer portion of their left thumb. The employee received stitches.

EE was changing segments on 988K loader with impact gun when EE lost control of the bolt causing laceration to the left hand.

EE was operating CAT 775 Haul Truck when felt a pop in right elbow.

A bar weighing an estimated 500 pounds fell 2 feet and landed on employee's left foot while doing maintenance on a feeder. Employee fractured EE's toe and received stitches. EE is currently out of work.

Employee was lifting a 50 lb ring on the VSI crusher when it slipped out of his hand, injuring his right index finger. He sought medical attention and was released to work modified duty.

After grinding metal, while washing hands to eat, employee noticed something in his eye. Requested to see doctor 2 days later.

Employee was cutting toward himself

While fueling equipment employee was dismounting ladder and slipped off last rung twisting knee. Employee did not seek medical attention until 11/06/2013.

Employee was tightening a hose clamp when wrench slipped off clamp striking employee in the forehead resulting in one stitch

While removing a filter housing using a 24" ratchet and socket, the socket slipped off the bolt and struck the employee in the mouth, cutting his lip and knocking out his top left front tooth.

The employee was part of a crew changing the blow bars on the base crusher. While working on placing a bar in the rotor, a small amount of material fell from the crusher bonnet above his work area. The material fell between his forehead and glasses and got into his left eye.

Miner was using chain to hoist equipment. Chain swung and struck miner in upper mouth, breaking a tooth.

Employee was assisting in changing out the blow bars in a Sandvik HSI crusher. He was repositioning the rotor in order to bring the next worn bar into position for removal. The rotor "free-wheeled" and in the process his right forearm became caught between the blow bar and the crusher side wall. He suffered a compound fracture to his forearm.

Employee was cutting on crown rubber with a razor-blade-type knife.The knife struck against a metal support. Knife jerked back and cut emplyee above the cuff of his gloves. Needed a doctor to stitch the wound.

Note:Late report by employee+originally denied as Workers' comp claim. He claims to have strained his back while lifting an 80-pound screen while attempting to access smaller screen behind it. He says that he lifted awkwardly.

Man attaching roof had fall protection on but not attached and he fell 22 feet.

EE WAS DISMOUNTING THE RENTAL WATER TRUCK. AS HE WAS DESCENDING THE TRUCK DOWN THE STAIRS-LADDER, HE FELT SHARP PAIN IN LOWER BACK. THE INCIDENT WAS NOT REPORTED TO MANAGEMENT UNTIL 2-12-02.

EE WAS CUTT9ING A CONVEYOR WHEN THE KNIFE SLIPPED. HE RECEIVED A 4" CUT TO HIS ARM WHICH REQUIRED STITCHES.

EMPLOYEE PULLED A MUSCLE IN HIS LEG JUMPING OFF A TRAILER (FLOAT- 3' TO 4' HIGH). THE PAIN INCREASED DURING THE FOLLOWING WEEKEND AND ON MONDAY.(3-4-96). EMPLOYEE WENT TO SEE A DOCTOR, EXAMINA TION REVEALED THE INJURED AREA HAD DEVELOPED CELLUITES AN INFECTION.

EMPLOYEE WAS CLIMBING ONTO A FRONT END LOADER WHEN HE SLIPPED OFF THE LADDER ONTO HIS BACK.

EMPLOYEE HAD A PERIODIC SCREENING CHEST X-RAY READING BY TWO "B" READERS USING THE ILO PROCEDURES. THE X-RAY WAS CHARACTERIZED AS CONSISTENT WITH PNEUMOCONIOSIS WITH BOTH READINGS OF 1/1. DAMA GE OR IMPAIRMENT CANNOT BE DETERMINED BY CHEST X-RAYS.

THE 13 YR OLD YOUTH WAS WADING THE WATER ALONG HELOTES CREEK ON QUARRY PROPERTY WHEN HE SAW A SMALL WHIRLPOOL CREATED BY THE WATER FLOWING INTO A 6 1/2" BORE HOLE. THE HOLE HAD BEEN DRILLED TO ASSESS QUARRY STONE RESERVES. THE YOUTH CURIOUSAS TO THE STRENGTH OF THE WATER STUCK HIS FOOT INTO THE HOLE. HIS BOOT FILLED WITH WATER. THE WEIGHT OF THE BOOT AND THE PULL OF THE WATER APPAR

EMPL LEANED OUT OF CAB OF HIS QUARRY HAUL TRUCK WHILE IT WAS BEING LOADED A ROCK SPILLED OVER THE SIDE OF TH TRUCK AND STRUCK HIM HON THE HEAD

EMPLOYEE WAS ADJUSTING IMPACT CRUSHER AND HIT THUMB WITH SLEDGE HAMMER.

EMPL WAS LOADING POWDER BAGS INTO HOLES & STRAINED BACK.

EMPLOYEE JUST FINISHED WELDING ON CHUTE WAS CMOING DOWN SLIPPED AND FELL ABOUT 7 FT TO THE GROUND HITTING RIGHT SHOULDER AND HEAD.

EMPLOYEE JUMPED FROM LOADER CAB TO GROUND AFTER SEEING THAT THE LOADER WAS ON FIRE.

EMPL WAS WORKING ON DRAAGLINE WHEN INSPECTION DOOR FELL & GRAZED ARM.

EMP STEPPED DOW3 FROM TRUCK, STEPPED ON UNEVEN AREA, STRAINED LEFT KNEE

EMP WAS DISMOUN7ING FROM OPERATING POSITION. HIS FOOT SLIPPED OFF THE STEP AND HE FELL TO THE GROUND. HE WENT TO DR 6-9-86 AND RETURNED TO WORK UNTIL 7-15-86. HE THEN COMPLAINED OF BACK PROBLE MS AND HAS BEEN3ON WORKMANS COMPENSATION