Nugent Sand Plant #1 Metal/Non-Metal

The employee was changing a 440 volt starter. Turned power back on to check starter after replaced. Checked the on/off button and determined new starter worked. He did not shut power down again, elected to hook up motor leads and in the process came in contact with the relay which in affect pulled starter into position causing flash back injuring him.

Fell on an upright unopened tube of silicone.

Employee sanding using a wire brush on a drill and wind blew metal into eye.

At this time it appears the employee had a heart attack.

Employee fainted.

Employee walking down ramp and pulled muscle in right calf

Employee assisting in putting in dryer trunion wheel; chain holding come along came loose sending come along into the employees' nose.

Employee shoveling and loading wheelbarrow and hauling sand, strained back moving wheel barrow.

Employee fell when new deck board on stair stringer broke causing employee to fall catching wrist on nail.

Employee told foreman he was not feeling well. Foreman assigned replacement loader operator and brought employee to employee locker room/restroom area. Employee was drying his hands when he suddenly passed out. CPR was started and 911 called. Employee was not able to be saved.

Employee changing shive on motor and cut fingers on shive.

Pulling stand out from under trackmobile, strained stomach.

LIFTING DOOR ON MAINTENANCE BUILDING.

UTILITY KNIFE SLIPPED WHILE CUTTING BELTING.

EE GETTING INTO BACK OF TRUCK PICK UP AND FELT HIS KNEE POP.

PULLING ON DIVERTER AT WASH PLANT.

PULLING LONG HOSE OFF PUP TO UNLOAD AT CUSTOMER.

EMPLOYEE INHALED TOO MUCH CO2 WORKING ON DRYER ROOM NEAR BURNERS.

LIFTING WHEEL BARROW AND PULLE DMUSCLE IN BACK.

PULLING ON DREDGE ROPES AND CLIMBING SAND HILL STRAINING GROIN AREA.

HITTING BEARING AND A PIECE OF METAL BROKE OFF AND CUT NECK.

PULLING DREDGE ROPE OUT OF MUD, ROPE SLIPPED OVER BANK AND HIT HIM IN THE LEGS.

EE WAS OVERCOME BY CARBON MONOXIDE GAS, MAN BECAME LIGHT HEADED AND NAUSEATED, WAS TAKEN TO HOSPITAL AND GIVEN OXYGEN. WAS ABLE TO RETURN TO WORK THE SAME DAY BUT JOB FOREMAN WOULD NOT ALLOW H IM TO.

EE WAS TURNING SAND PUMP WITH A PIPE WRENCH. WHILE TURNING THE SHAFT GOT CAUGHT BETWEEN THE WRENCH AND THE PUMP BASE.

SLIPPED ON SNOW COVERED STEPS IN SHIPPING TUNNEL AND CAUGHT HIMSELF WITH LEFT HAND.

CLIMBING OVER RAIL CAR COUPLING AND STEPPED DOWN AND LEG TWISTED AND JAMMED.

MOVING SAND IN DRYER ROOM WITH WHEEL BARREL AND SHOVEL.

LIFTING STEEL AND FELT A PULL IN STOMACH AREA.

MOVING SHEET METAL AND THE HOOK FROM THE LIFT SLIPPED OFF AND HIT HIM IN THE HEAD.

HE STEPPED FROM A FRAME ONTO DECK OF DREDGE WITH ARMLOAD OF STEEL BANDING AND TWISTED RIGHT KNEE.

PULLING ON PIPE WRENCH.

EE WAS CUTTING WITH A RAZOR BLADE, IT SLIPPED CUTTING FINGER

HE CAME OUT FROM UNDER SUMP, TURNED AND RAN INTO STEEL TANK.

LIFTING PIPE.

GETTING OUT OF FRONT END LOADER, STEPS WERE WET & HE SLIPPED.

EMPLOYEE SLIPPED ON FROZEN SAND WHEN SHOVELING.

SLIPPED ON ICE CLIMBING ONTO LOADER LADDER

PUSHING WHEELBARROW FULL OF SAND OUT DOOR AND FOOT SLIPPED.

PUTTING NEW ROLLERS ON 150' BELT AND HIT KNEE ON CATWALK.

WALKING UNDER NORTH DRYER AND HIT HEAD ON DRUM BELT.

EE WALKING BEHIND MAINTENANCE PERSONNEL THAT DROPPED HOT WELDING ROD FALLING ON EE.

TURNING OVER SHEET OF STEEL AND LEFT SHOULDER GAVE OUT.

HE WAS LEANING OVER 51 BELT BREAKING FLEXCOS WHEN HE FELT A SHARP PAIN IN LOWER BACK.

OPERATING SCAT-BACK AND IT WOULD NOT GO INTO FORWARD OR STOP: STAYED IN REVERSE FORCING HIM BACKWARD INTO DEWATERING SCREW.

EMPLOYEE WAS WALKING TO BACK OF DRYER ROOM AND TWISTED HIS KNEE.

PICKING UP SCREEN IN TUNNEL TO PUT IN PLACE, FELT SOMETHING PULL.

EE PINCHED RIGHT HAND BETWEEN STEEL & RACK.

MOVING DREDGE AND DEADHEADS, CABLE WAS CAUGHT ON SOMETHING AND WHEN IT BROKE LOOSE IT STRUCK THE EMPLOYEE.

PUTTING NEW ROLLERS ON WET TANK INCLINE WHEN DIRT UNDER ROOF FELL INTO EYE.

PICKING UP PALLET AND FELT BACK PAIN.

EMPLOYEE WELDING OVERHEAD AND A PIECE OF SLAG DROPPED ON WRIST AND WATCHBAND.

PINCHED FINGER BETWEEN PUMP HOUSING AND WEAR PLATE.

TWISTED KNEE WHILE WALKING BACK AND FORTH ON CATWALK IN MIDDLE OF DRYERS.

DISASSEMBLING PUMP ON TOWER #4.

HAULING WASTE SAND OUT OF DRYER ROOM WITH WHEEL BARROW WHEN IT TIPPED STRAINING HIS BACK.

EMPLOYEE WORKING AT WASH PLANT AND GOT SOMETHING IN HIS EYE SCRATCHING THE CORNEA.

EMPLOYEE TWISTED ANKLE UNDER NORTH DRYER.

EE CHANGING BEARING ON DREDGE AND WRENCH SLIPPED CAUSING HIM TO BUMP ELBOW.

REPLACING PACKING ON DREDGE, HE SLIPPED ON GRATING AND TWISTED KNEE.

WORKING ON SHIPPING INCLINE BEARING, LOST FOOTING AND FELL.

MAN GRINDING A PIECE OF STEEL. STEEL GOT CAUGHT IN GRINDING WHEEL AND BETWEEN REST, GRINDING HIS FINGERS.

PULLING IN CONVEYOR BELT ON 180' CONVEYOR AT WASH PLANT.

SLIPPED WHILE GETTING DOWN FROM TRACKMOBILE.

EMPLOYEE OPERATING FRONT END LOADER TOO FAST FOR CONDITIONS AND SLID INTO LEG OF SILO CAUSING SILO TO COLLAPSE ON FRONT END LOADER.

EE'S FINGERS CAUGHT BETWEEN 2 PIECES OF 10" PIPE. TIP OF FINGER PULLED OFF.

GRIDNING PIPE FLANGE CONTACTED FRINDING WHEEL CUTTING EDGE WHILE GRINDER WAS STRAC SPINNING.

EE ATTEMPTING TO RESTART DREDGE AND FELL DOWN INTO THE PUMP ROOM STRIKING HEAD ON PUMP. IT WAS DISCOVERED EE WAS TAKING A PRESCRIPTION DRUG ON THE JOB WITH SIDE EFFECTS OF POSSURE PREVIOS 24 H OUR PERIOD.

STANDING ON HAND RAIL TO PRIME JET & SLIPPED OFF RAIL HURTING RIBS

EMPLOYEE WALING DOWN STAIRS IN HOT PIT & STAIR GAVE WAY CAUSING EMPLOYEE TO FALL

EMPLOYEE WAS AIR ARCING SOME METAL PARTS(HE HAD FULL LEATHER ARMS,SHOULDER,CHEST AND UPPER BACK PROTECTION ON) WHEN A HOT SPARK GOT BETWEEN LEATHERS AND HIS CLOTHING.WHEN HE REMOVED LEATHERS A NS SHIRT HIS BACK WAS BURNED.

PIPE BROKE SCAFFOLD FELL LANDING ON HIS BACK ON STEEL

HAND CAUGHT BETWEEN BUCKET AND STEEL.

CUT HAND WHILE GRINDING.

SHOVELING SAND,TWISTED BODY AND FELT PAIN IN HIP

SLIPPED ON WET CEMENT WHILE PULLING MANNIERE IN TO LOAD RAIL CARS AND FELL.

CHANGING LIGHT BULB AT HEAD PULLEY ON 100' BELT SLIPPING & FELL TO GROUND BREAKING HIP.

WORKING ON CONVEYOR AND WHILE WALKING ACROSS THE CONVEYOR I,NAME SLIPPED AND TWISTED ANKLE.

INSPECTING TAIL3PULLEY OF FABCO CONVEYOR AND APPARWNTLY FELL ONTO CONVEYOR

SLIPPED ON STEP8 AT WASH PLANT.

HYDRAULIC HOSE RUPUTURED SPRAYING FLUID ON HOT ENGINE CAUSING COMBUSTION.

CLOSING DOOR ON R/R/ CAR & PULLED BACK OUT- DOOR WOULD NOT CLOSE.

LIFTING SPEED REDUCER.

LIFTING SHIEVE.

CLIMBING ON SURGE SUMP TO REPLACE BALL ON FLOSS LEVER, TWISTED LEG HEARD & FELT KNEE POP.

FELL FROM STEPS IN SCREEN AREA, TIRED TO BREAK FALL LANDING ON LEFT SIDE OF BACK AND BACK.

LIFTING LIDS ON TRAIN CARS LID WOULDN\T OPEN AND SOMETHING SNAPPED IN BACK.

TAKING OUT HEAD PULLEY ON STEEL TANK CONVEYOR-LIFTING WITH PRY BAR AND IT FELL AND PULLED SHOULDER OUT.

REPLACINE EXCESS DOOR ON NORTH DRYER A PIECE OF HOT SLAG FELL INTO RIGHT EYE

FOREIGN MATERIAL IN EYE.

EMPLOYEE SLIPPED ON ICE AND OVERTURNED ANKLE