Atmore Sand and Gravel: 120 MSHA citations Metal/Non-Metal

Installing return roller (plant 7-grit belt)-employee struck roller with hammer to make it line up with bracket, little finger got pinched between roller and bracket, cutting finger.

DROVE VOLVO THROUGH PLANT 7 WITH BED UP. STRUCK POWER LINE & TORE POWER LINE DOWN. TAKEN TO COMMUNITY HOSPITAL TO BE CHECKED. NO INJURY, WAS DRUG TESTED AS WELL. *EMPLOYEE TERMINATED*

OPERATOR WAS REPAIRING FLOATING PIPELINE & LOST FOOTING IN WORK BOAT AND FELL. HE STRUCK HIS WRIST ON FLOATING PONTOON. BROKE LEFT WRIST.

EE WAS HELPING LOADER OPERATOR MOVE DREDGE TAIL LINE ROPE. EE'S FOOT SLIPPED ON LOADER CAUSING RT LEG SHIN TO STRIKE FRAME OF LOADER. DEEP BRUISE OF RT LEG SHIN.

HE HAD TO GO TO THE HOSPITAL OVERNIGHT BECAUSE HE WAS HOLDING WIRES WITH A PVC PIPE AND HE TOUCHED A LIVE ELECTRICAL WIRE.

HE WAS WORKING A PIPE; THEY PICKED UP ON THE PIPE A COUPLE OF TIMES. WHEN HE PICKED UP THE PIPE THE THIRD TIME, THE RUBBER CAME LOOSE AND THE RUBBER PUSHED THE PIPE, AND HIS HAND GOT CAUGHT B ETWEEN THE TWO.

LOADER BUCKET WAS RAISED UP AND HE WAS WORKING ON A PIPE. A 2 BY 4 CAME DOWN AND SQUASHED TWO FINGER.

TAKING A ROLLER OFF WITH A WRENCH, ROLLER FELL AND CAUGHT FINGERS BETWEEN FRAME AND ROLLER. BUSTED THE FOURTH FINGER AND PINKY OF LEFT HAND.

EE WAS WELDING ANGLE IRON ON PLANT. EE STEPPED UP TO ANGLE BRACE. HIS LEFT FOOT SLIPPED CAUSING RIGHT SHIN TO STRIKE ANGLE CUTTING RIGHT SHIN.

LOADER OPERATOR LOADER TRUCK. TRUCK PULLED AHEAD APPROX 30 YDS & STOPPED. LOADER OPERATOR THEN STARTED TRAVELING IN SAME DIRECTION AS TRUCK & WAS BLINDED BY SUN & DID NOT SEE ATRUCK STOP. TRUC K DRIVER WAS GETTING OUT OF TRUCK AT IMPACT CAUSING DRIVER TO FALL TO GROUND. BRUSIED JAW, 2 BROKE RIBS.

2 EMPLOYEES WERE CHANGING A ROLLER ON CONVEYOR BELT. THEY WERE SLIDING THE ROLLER INTO PLACE WHEN ONE END DROPPED DOWN AND OTHER END MASHED INJURED EMPLOYEE'S 3RD FINGER ON RIGHT HAND, RESULTI NG IN BRUISED TENDONS AND LIGAMENTS.

EE WAS HELPING 2 OTHER EE'S LIFT A FRESH WATER PUMP OFF DREDGE, WHEN HIS HANDS SLIPPED AND PUMP FELL ON LEFT HAND AND MASHED THE 2 MIDDLE FINGERS ON HIS LEFT HAND BREAKING THEM.

EE WAS GOING TO LOWER DECK OF DREDGE TO TIGHTEN LOOSE PACKING ON DREDGE. PUMP SHELL. HIS FOOT SLIPPED ON TOP STEP AND BENT RIGHT LEG UP BEHIND BODY, RESULTING IN PULLED MUSCLES IN GROIN AREA.

EMPLOYEE WAS REMOVING STICKS FROM GRAVEL STOCK PILE WHEN ANOTHER EMPLOYEE WAS ADDING GRAVEL TO STOCK PILE AND A ROCK CAME OUT OF LOADER BUCKET AND STRUCK 1ST EMPLOYEE IN HIS RIGHT EYE RESULTIN G IN BRUISED EYE BALL.

AT THE END OF WORK SHIFT THE EMPLOYEE WENT BELOW IN THE DREDGE TO SHUT DOWN ENGINE. AS HE WAS DECENDING 4 METAL GRATE STEPS INTO THE ENGINE ROOM, THE VERTICLE BANK NEAR FRONT OF DREDGE CAVED A ND CAUSED THE DREDGE TO PITCH SUDDENLY. EMPLOYEE LOST HIS HOLD ON HAND RAIL AND SLIPPED DOWN STEPS, BUMPING HIS ELBOW.

950-E CAT LOADER WAS SHOWING HOT ON TEMP GUAGE. OPERATOR REMOVED CAP WITHOUT COOLING RADIOTOR WITH WATER HOSE, AS IS POLICY. EMPLOYEE REMOVED CAP CO MPLETELY AND DID NOT VENT OFF PRESSURE AS IS POLICY. HOT WATER FROM RADITOR BLEW UP INTO FACE AND CHEST AREA, CAUSIGN BURNS.

DESCENDING STEPS SLIPPED AND FELL ON BACK LANDING ON STEPS BRUISE AND FRACT VERTIBRAE

KNIFE CUT ON TWO FINGERS,TRIMMING FALP ON CONVEYOR BELT.

WHIEL REPLACING ROTARY SCREENS INJURED ATTEMPTED TO KICK SCREEN INTO PLACE. ROTARY SCREEN KICKED BACK AND CAUSED SPRAINED ANKLE.

WHILE DRIVING DEFECTIVE BEARING OFF SHAFT CHIP 9OF HAMMER FLEW OFF & PENETRATED LEFT THIGH OF EMPL.

WHILE CLIMBING UP STEPS ON 966-D CAT LOADER EMPLOYEE STATED THAT HE PULLED MUSCLE IN HIS LEFT SHOULDER.

WHILE SERVICING CONVEYOR BELT EMPLOYEE SLIPPED AND LOST FOOTING.HE THEN ROLLED UNDER HAND RAILS AND FELL APPROXIMATELY 10' TO THE GROUND.EMPLOYEE RECEIVED A BACK STRAIN IN THE FALL.

CHANGING SCREEN8 IN GRAVEL SEPARATION TOWER EMPL LET SCREEN SLIP IN HIS HAND CAUSING CUT IN PALM.AFTER 1ST AID COMPLETED COULD RETURN TO WORK.AFTER SHIFT EMPL DECIDED HE NEEDED TO SEE DR.