Clayvigo No. 1 Mine Coal

EE FELL FROM LADDER STEPPED ON ICE AND SLID DOWN SLOPE OF HOPPER.

LTA INJURY: EE WAS GETTING OFF OF A D-10 DOZER WHEN HE SLIPPED OFF OF THE PUSH ARM AND TWISTED HIS RIGHT LEG BREAKING THE BONES.

EE WAS USING A CUTTING TORCH WHEN THE HOSE IGNITED

EE WAS BACKING UP WHEN HE ALLEGDLY RAN OVER A ROCK AND HURT HIS BACK

HE STEPPED DOWN FROM THE PUSH ARM OF 580 D-10 GROUND TRACTOR, HIS LEFT FOOT STRUCK THE STEP ON THE BALL OF THE FOOT CAUSING A SPRAIN.

EE WAS IN THE CAGE UNDER THE BULK ANFO BINS WHILE THE POWDER TRUCK WAS MOVING UP. AFTER THE TRUCK WAS POSITIONED, SHE STEPPED DOWN ONTO THE TRUCK AND TURNED HER KNEE.

EE SKINNING ROCK ON PREBENCH AREA OF MUD AND ROCK. HE RAN INTO A FLOATER ROCK. THE ROCK JARRED THE DOZER.

EE BACKED DOWN A GRADE TO DUMP A LOAD OF TOPSOIL. AS HE PULLED AWAY FROM THE LOAD AFTER HE DUMPED WITH THE BED RAISED, THE BED RAISED ANOTHER 6" BOTTOMING OUT THE CYLINDER, CAUSING HIM TO BE T HROWN AGAINST THE BACK OF THE SEAT.

EE WAS OUT BY THE ENGINE CHECKING FLUIDS. WHEN SHE TURNED AND POT HER LEFT FOOT ON A PIECE OF 1" HIGH LIP ON THE WALKWAY IT CAUSED HER FOOT TO BE HIGHER ON THE WALKWAY, INSTEP AND PUSHED HER A NKLE TO THE OUTSIDE.

MEDICAL INJURY EE WAS WALKING DOWN THE WEST STAIRS TO THE 3RD FLOOR. AS HE STEPPED ONTO A WET & MUDDY SPOT, HIS FEET SLIPPED OUT FROM UNDER HIM.HE TRIED TO CATCH HIMSELF AND THIS RESULTED IN A SPRAINED RIGHT THUMB AND WRIST. A BRACE WAS APPLIED ON 7/31/98

EE WAS HOLDING A SHAFT STEADY WHILE THE OILER LOWERED THE OVERHEAD CRANE THAT WAS HOOKED TO THE SHAFT. THE CRANE BLOCK BUMPED THE SHAFT PINCHING THE EMPLOYEE'S FINGER.

A MECHANIC HANDED THE EE AN OIL NOZZLE. AT THAT TIME ANOTHER MECHANIC TURNED ON THE OIL PUMP. OIL SPRAYED FROM THE NOZZLE. THE EE JUMPED BACK TO AVOID THE SPRAY FROM THE NOZZLE, HE STRAINED HI S BACK.

EE WAS CHANGING A TIRE ON 026.19 LUBE TRUCK WHEN HE FELT A PAIN IN HIS LOWER BACK. TIRE SIZE 1000-20.

EE TRYING TO PIN THE RT. LIFT CYLINER ON THE BOTTOM BEHIND THE BLADE, SWUNG AGAINST LEFT HAND 2ND KNUCKLE.

EE WAS OPERATING A 992C #228.28 AND WAS STRIPINGROCK OFF OF #4 COAL IN THE WEST END OF THE 2570 PIT. THE FRONT WHEELS OF THE ENDLOADER DROPED OFF THE EDGE OF THE #4 COAL SEAM INTO AN 18" DEPRESSION. THE ENDLOADER TILTED FORWARD AND THE OPERATOR JUMPED APPROX 20' TO THE GROUND

EMPLOYEE WAS REMOVING A 3/8" TOW CHAIN FROM D-4 CRAWLER TRACTOR WHEN SHE PULLE DIT OFF THE HANGER TO OPPOSITE END WITH THE HOOK FLIPPED AROUND STRIKING HER LEFT WRIST.

EMPLOYEE WAS DRIVING A UNIT RIG HAUL TRUCK UP #2 INCLINE. THE TRUCK STALLED AND STARTED TO ROLL BACKWARDS. THE OPERATOR APPLIED THE BRAKES CAUSING THE FRONT WHEELS OF THE TRACTOR TO LIFT OFF T HE GROUND. WHEN THE WHEELS CAME DOWN IT CAUSED THE OPERATOR TO BE THROWN INTO THE STEERING WHEEL.

EE DISMOUNTED THE TRACTOR USING 3 POINT CONTACT WHEN SHE PUT HER FOOT ON THE GROUND SHE TURNED HER ANKLE.

THE MACHINE OILER WAS OPENING THE BIG DOORS(DOUBLE). THE SMALL PERSONNEL DOOR WAS NOT LATCHED. THE WIND BLEW THE DOOR CLOSED AND CAUGHT HIS THUMB (LEFT) BETWEEN THE DOOR AND THE FRAME.

EMPLOYEE WAS CUTTING A HOLE IN A 5 GAL PLASTIC BUCKET USING HIS POCKET KNIFE. THE KNIFE CAME THROUGH THE PLASTIC AND CUT HIS LEFT THUMB.

EE WAS TURNING CUTTING EDGES ON D-4 BLADE USING OLD BOLTS THAT HAD WORN HEADS. WHEN TIGHTENING BOLT, THE BOLT UNSCREWED AND WAS SPINNING CAUSING LACERATION TO FINGER (RIGHT MIDDLE).

EE WAS ASSIGNED TO HELP CLEAN THE DRAG TROUGHS AND SHOVEL DIRT WHEN HE FELT PAIN IN BACK.

EMPLOYEE WALKED UNDER THE AUGER. WHILE STOOPING, HE STUMBLED ON UNEVEN GROUND AND FELL TO HIS KNEES AND RESULTING IN BACK PAIN.

MECHANIC REMOVED THE A/CCOMPRESSOR ON 284.26 & SET IT ON THE EDGE OF THE FLOOR BOARD & BREAK LINKAGE. WHEN HE STARTED TO CLIMB OUT OF THE DOZER,HE HIT THE BRAKE PEDDLE, CAUSING THE BRAKE LINKA GE TO MOVE, CAUSING THE A/C COMPRESSOR TO FALL ON HIS FOOT.

THROWED A PIECE OF IRON ON TRIALER WITH A HINGE IN IT THEH HINGE CLOSED ON FINGER CUTTING THE END OFF OF IT.

THE EE WAS USING A 15 TON JACK, A 3/8" CHAIN AND PLATE TO STRAIGHTEN A 2 1/2" PIECE OF SQUARE STOCK FELL ON THE FRONT OF THE 16 G GRADER. HE PUT TENSION ON THE JACK AND HEATED THE SQUARE STOCK . THE JACK CAME OUT AND STRUCK HIS LEFT FORERAM.

EE WAS ON LADDER WHEN IT SLIPPED, CATCHING HIS LEFT MIDDLE FINGER BETWEEN THE LADDER & A PIPE INTHE BATHHOUSE. THE EE HAD THE FINGER X-RAYED ON 11-8-95 & IT WAS FOUND TO BE BROKEN.

EMPLOYEE STATED HE WALKED OUT OF SHOP DOOR AND DIDN'T SEE 3" STEP DOWN IN CONCRETE, SLIPPED AND HURT HIS BACK.

EE WAS CUTTING ROPE OFF OF POWER CABLE. KNIFE SLIPPED AND CUT INTO UPPER PART OF RIGHT LEG.

EMPLOYEE WAS THROWING SLIDE BOLTS OUT OF DRAGLINE SHOE. THE BOLTS ARE APPROX. 1 1/2' LOGN AND WEIGHT ABOUT 30 LBS. THERE WAS A NUT ON END OF BOLT. EMPLOYEE HAD HIS FINGER SON NUT & AS HE THR EW BOLT, NUT STRUCK BOTTOM OF SHOE HOLE CATCHING FINERS BETWEEN NUT AND PORT HOLE.

EMPLOYEE WAS ARC AIRING A PIECE OF LINER PLATE OFF THE BLADE ON 535.26 D-11 WHEN THE PIECE OF PLATE SPRUNG FORWARD ONE FOOT HITTING EMPLOYEE IN HIS WELDING HOOD AND KNOCKING HIM OFF A WOOD PAL LET HE WAS STANDING ON CAUSING HIM TO HIT HIS HEAD ON CEMENT FLOOR.

DISMOUNTING THE LN7000 SUPPLY TRUCK. EMPLOYEE STEPPED DOWN INTO A PUDDLE OF WATER. THE WATER WAS COVERING A HOLE AND EMPLOYEE STEPPED INTO THE HOLE. HE TWISTED HIS LEFT ANKLE AND FELL INTO THE GROUND.

EMPLOYEE WAS GETTING DOWN OUT OF HIS OB TRUCK WHEN HE MISSED THE CABLE STEPON THE BUMPER CAUSING HIM TO FALL ABOUT THREE FEET TO THE GROUND HE LANDED ON HIS LEFT BUTTOCK

EMPLOYEE WAS MOVING HYDRAULIC RAMS IN THE MAG BAY. HE FELT A PULL WHILE HE WAS MOVING THEM BY BUT HAD NO PAIN. LATER WHILE HE WAS BENDING OVER THE PAIN STARTED. HE LEFT WORK AND WAS ADMITTED T O REGIONAL HOSPITAL THE NEXT DAY.

EMPLOYEE WAS STANDING UNDER DRAGLINE TUB & WAS DRAGGING WELDING LEAD & SAID LOWER BACK POPPED OUT OF PLACE.

EMPLOYEE WAS HELPING INSTALL A BEARING RETAINER ON THE DRAG DRUM SHAFT. THE RETAINER SLIPPED INTO PLACE AND CAUGHT EMPLOYEE'S FINGER BETWEEN THE RETAINER AND THE DRUM CASE.

EMPLOYEE WAS GETTING ELECT BOX AND CABLE FROM VIRGIN FOR 2570 DRAGLINE. RAIN AND MUD VERY BAD SLIPPED IN MUD AND SPRAINED LEFT ANKLE.

EMPLOYEE WAS STRUCK BY MUD/GLASS WHEN MUD CAME THROUG FRONT GLASS IN RT 2 570 DRAGLINE OPERATORS CAB DRAGLINE WAS SPOILING MATERIAL & MUD SPLATTERED OFF SPOIL RICOCHETING INTO OPERATORS CAB ST RIKING EMOPLOIYEE AS HE STOOD TALKING TO CREW M EMBERS IN CAB

EMPLOYEE SAID HE FELT PAIN IN HIS LOWER BACK AFTER MOVING TRAILING CABLE BY HAND. EMPLOYEE DID NOT EXPERIENCE PAIN WHILE HE WAS MOVING THE CABLE.

DRIVER WAS FILLING DIESEL STORAGE TANK AS HE CLIMBED DOWN OFF THE TANK THE LADDER BROKE LOOSE FROM THE TANK. HE FELL ABOUT 8 FEET LANDING ON HIS SIDE AND ARM. ARM.

EMPLOYEE WALKED OUT ON THE 61-R WALKWAY ON THE LEFT SIDE OF THE DRILL TO TALK TO SUPERVISOR AND DID NOT SEE A LARGE HOLE IN THE WALKWAY WHICH HE STEPPED INTO.

EMPLOYEE WAS HOLDING METAL IN DRILL PRESS WITH VISE GRIP. METAL SLIPPED AND CUT LEFT FIRST FINGER.

WIND BLEW DOOR SHUT PINCHING FINGER BETWEEN DOOR LATCH COVER AND DOOR JAM

EE WAS CUTTING RUBBER WITH KNIFE WHEN KNIFE SLIPPED AND CUT LEFT LITTLE FINGER.

CLEANING CHUTE ON EAST SIDE OF ROTARY BREAKER. STARTED TO CLOSE DOOR, HANDS SLIPPED OFF OF HANDLE AND DOOR FELL DOWN AND HIT EMPLOYEE ON RIGHT SIDE OF FACE BELOW EYE CAUSING TWO INCH CUT.

CLEAN UP SPILL IN ROM TAILEND OF #6 BELT USING SHOVEL & PUTTING COAL ON BELT. DECISION TO REPORT EMPL WAS MADE AFTER WE RECEIVED COMPLETE REPORT FROM DOCTOR CONCERNING INJURY.

EMPL HAD BEEN IN DISCHARGE BOX FROM CYCLONES INSTALLING LOWER CONE SECTION.AS EMPL PULLED HIMSELF OUT,STRUCK LEFT KNEE ON FLANGE WHERE CONE SECTIONS BOLT TOGETHER.EMPL WAS RECOVERING FROM ABOV E INJURY BUT WHILE WORKING IN SQUATTING POSITION ON 9-7-90 SOMETHING POPPED IN KNEE CAUSING FURTHER DAMAGE.

EE WAS CLEANING THE FRONT LIGHTS ON A CAT D-7 AND WHILE STANDING ON PLATFORM ON LEFT SIDE OF TRACTOR REACHED ACROSS THE HOOD TO CLEAN THE LIGHT ON THE RIGHT SIDE. EE CLAIMS HE GOT AGAINST THE GRAB IRON AND FELT PAIN IN HIS LEFT SIDE.

EMPLOYEE DROPPED SIX (6) INCH HOSE FITTING ON RT FOOT HITTING LITTLE TOE (WAS WEARING HARD TOE0BOOTS)

STACKING 8" X 8" FLOORING FOR LOWBOY,FORGOT TO LET GO.CAUGHT MIDDLE FINGER LEFT HAND BETWEEN TWO OF THEM MASHING END OF FINGER.

EMPL LIFTING & LOADING SCRAP IRON FOR JUNK,STRAINED HIS BACK.HAD NO PAIN AT WORK.PAIN STARTED AT HOME.

EMPLOYEE WAS AT WORK BENCH WORKING ON ELEC PART FOR SHIFT TOWER OFF OF HAUL TRUCK.USED POCKET KNIFE TO CUT A PLASTIC TIE WRAP WHEN KNIFE SLIPPED AND CUT RIGHT THUMB.

PRYING ON LINK WITH PRY BAR. A D 9 N WAS PUSHING ON LINK.LINK PIN WENT IN POSITION CAUSING THE PRY BAR TO SNAP LOOSE HIT BUCKET CAME BACK STRUCK EMP ON R HAND BREAKING 2 MIDDLE FINGERS

BENT OVER TO PICK UP POWER CABLE AND FELT PULL IN BACK LATER ON HOME BACK PAIN STARTED AGAIN.

EMPLOYEE REPAIRING DOOR-STANDING ON A STEPLADDER AND A BENT OVER POSITION. WHEN HE STRAIGHTENED UP, HE MISJUDGED HIS DISTANCE FROM MIRROR BRACKET. THIS ACCIDENT WAS NOT REPORTED TO MANAGEMENT UNTIL 10-24-89. THE EMPLOYEE WENT TO CHIROPRACTOR SOMETIME IN THE MONTH.

STRAINED BACK WHILE LIFTING CABLE FOR #5 182 LOADER.

STRAINED BACK LOADING WATER JUGS IN TRUCK

OPER WTER VALVE PRESSURE HIT HOSE BLEW IT OFF CAUSING EMP TO GET WET TURNED BODY IN POSITION TO STRAIN BACK

HAUL TRUCK #109 AND #111 WERE ABOUT TO PASS EACH OTHER IN A CURVE ON THE 2570 HAUL ROAD TO #1 INCLINE. AS THEY PASSED, #109 JACK-KNIFED ON THE WET ROAD. THIS CAUSED 109 TO HIT THE TRACTOR TAND UMES OF #111.

EMPLOYEE WAS LIFTING A 40LB BOX OF EXPLOSIVES UP INTO BOX ON THE POWDER TRUCK AT THIS TIME HE STRAINED HIS BACK

EMPLOYEE WAS INSTALLING A LARGE BEARING OIN THE HOSIT GEARING. BEARING SLIPPED ON SHAFT AND EMPLOYEE FELL ABOUT SIX FEET LANDING ON HIS FEET AND SIDE. IF HE HAND NOT HAVE ACTED QUICKL;Y AND PARTIALLY JUMPED, HE WOU;LD HAVE BEEN HURT BAD.

EMPLOYEE WAS WALKING TO HER WORK AREA. SHE WALKED DOWN A SMALL HILL AT THE REAR OF THE SHOP. THE GROUND WAS FROZEN AND ICE COVERED. SHE SLIPPED AND FELL ON THE ICE CAUSING HER INJURY.

EMPL OPENING REFUSE GATE WITH PIECE OF 1 1/4'' PIPE-DO DAILY IN PM-PUSHING DOWN HIS SHOULDER WAS PULLED.DR DIAG-TENDONITIS WHICH APPEARS TO BE PRE-EXISTING CONDITION.ALSO QUESTION WHETHER EMPL COULDNT HAVE PERFORMED HIS JOB DUTIES AS PREP PLANT OPER.DR LEFT IT UP TO EMPL.I AM IN DOUBT WHETHER THIS IS REPORTABLE.

EMPLOYEE WAS HELPING THE SHOOTER LOAD THE POWDER TRUCK WITH POWERMAX 440 (60LBS/BOX)AND SAID HE STRAINED HIS BACK.

EMPLOYEE WAS WORKING UNDER A TEREX WATER TRUCK. AS HE WAS GETTING OUT FROM UNDER THE TRUCK, HE STRUCK HIS HEAD ON A SHARP ANGLE WHICH REQUIRED STITCHES.

THERE IS NO SPECIFIC EVENT WHICH CAUSED HIS INJURY. THE EMPLOYEE WORKED HIS NORMAL SHIFT WITH NO PROBLEMS. THE NEXT MORNING WHEN HE GOT UP, HE HAD BACK PAIN WHICH HE ASSUMES IS WORK RELATED. H E DIDN'T REPORT THE INJURY UNTIL 9-19-88. THIS EMPLOYEE HAS A HISTORY OF BAKC PROBLEMS AND IS TAKING CHIROPRACTIC TREATMENTS.

THERE IS NO SPECIFIC EVENT WHICH CAUSED THIS INJURY. EMPLOYEE STATES THAT THIS MACHINE RIDES ROUGH. EMPLOYEE HAD CHIROPRACTIC TREATMENT SOMETIME AFTER THE INJURY.

WHILE GOING DOWN RAMP TO BENCH LEVEL, #023 BULK TRUCK WENT OFF SIDE OF RAMP AND TURNED OVER ON LEFT SIDE.

WHILE GOING DOWN RAMP TO BENCH LEVEL, #023 BULK TRUCK WENT OFF SIDE OF RAMP AND TURNED OVER ON LEFT SIDE.

EMP WAS GOING TO USE A D-6 TRACTOR TO CHECK A PUMP THAT WAS NOT ACCESSIBLE BY TRUCK. WHEN HE UNLATCHED THE DOOR TO CLOW IT, HIS RIGHT THU B BECAME CAUGHT AS THE DOOR CLOSED. THE DOOR CL OSED ON HIS THUMB.

ROM BELT OVERLOADED BY WET COAL. WE WERE SHOVELING BELT OFF WHEN EMPLOYEE HURT HER BACK.

EMP. LIFTED QUICK FUEL HOSE NOZZLE ASSEMBLY ONTO FUEL TANK ON #228 GOB TRUCK. AS SHE LIFTED SHE FELT A SHARP PAIN THE CENTER OF HER NECK RADIATING TO HER SHOULDER. AGGRAVATED BY TRIP TO G OB DUMP HIT SEVERAL BUMPS IN ROAD.

EMP. WAS HELOPING BEND KEEPERS ON SPREADER BAR PINS. HE WAS USING A SLEDGE HAMMER AND STANDING IN STRAINED POSITION WHILE DOING SO CAUSING BACK STRAIN..

EMPLOYEE WAS MOVING HYDRAULIC CYLINDERS FROM SHOP TO WAREHOUSE AND STRAINED BACK.

EMPLOYEE HAD BULLDOZER STUCK ON BENCH IN MUD & APPARENTLY STRAINED BACK MOVING PULL CABLE IN MUD

EMPLOYEE SLIPPED ON ROCK AND JAMMED BACK WHILE WALKING AROUND TRACTOR.

EMPLOYEE WAS LIFTING TRAIL CABLE ON LOADER TO TOP OF BLADE ON RIPPER TRACTOR.

EMPLOYEE TWISTE8 NECK AND HAD SHOOTING PAIN DOWN RIGHT ARM-ACCIDENT OCCURRED WHEN OPERATING 187 SCRAPER ON SPOILS.FROZEN GROUND AND LOADING CONDITION CAUSED A RIDGE THAT HAD TO BE NEGOTIATED B Y THE PULL CAUS3NG THE OPERATOR TO TWIST WHILE BOUNCING.

EMPLOYEE WAS AT7EMPTING TO DISLODGE BROKEN DISC BLADE FROM AXLE WITH LARGE HAMMER. WHEN STRIKING THE BLADE, A PIECE BROKE FREE AND STRUCK EMPLOYEE ON LEFT UPPER THIGH CAUSING A LACERATION.

DUMPING TRASH B5RREL FROM WASH BASIN IN DUMPSTER AND STRAINED HIS BACK.

EMPLOYEE WAS GR9ASING PUMP AND RIDE STRUTS UNDER WATER TANK, RAISED UP AND BUMPED HEAD ON WATER MANIFOLD.

EMPLOYEE STATES3HE WAS REMOVING PINS FROM D9L RADIATOR FRAME USING A SLEDGE HAMMER AND B&O WHEN A CHIP OF THE HAMMER BROKE OFF HITTING EMPLOYEE IN LEFT ARM JUST ABOVE WRIST. STEEL WAS LOCATED UNDER HIS SKIN1

HE WAS LOOKING 6ACK AT BOWL OF HIS SCRAPER WHEN FRONT WHEELS DROPPED OFF IN A HOLE. THIS ACTION TOSSED HIS HEAD AROUND JARRING HIS NECK.

EMPLOYEE STATES3THAT HE WAS WALKING DOWN HILL TO SHUT OFF WASH PUMP AND STEPPED ON ROCK AND TWISTED ANKLE.

EMPLOYEE WAS WA8HING COMPANY PICK UP TRUCK USING A DIRTY RAG THAT HAD BEEN LAYING AT THE TRUCK WASH SITE AND WATER SPLASHED INTO THE CORNER OF EMPLOYEE'S RIGHT EYE.RAG MAY HAVE HAD A CHEMICAL OR OTHER SUBSTA3CE ON IT.

EMPLOYEE ALLEGE8 THAT HE HIT A ROUGH SPOT IN THE ROAD WHILE OPERATING SCRAPER AND STRAINED BACK

EMPLOYEE COMING3OUT #3 INCLINE AND HIT DEPRESSION IN ROAD WHERE SHOT HOLE HAD BEEN FILLED IN.JAMMED BACK,COMPLAINING OF LOWER BACK PAIN.NOTE:EMPLOYEE CONTINUED TO WORK INTO THE VACATION PERIOS SO HIS FIRST LO8T DAY DIDN'T OCCUR UNTIL JULY,25 1987.

EMPLOYEE WAS US3NG GRINDER TO TAPER A PIECE OF TOWNIPRENE PLASTIC TO SERVE AS A PLUG TO STOP ALEAK IN THE SLURRY TANK.EMPLOYEE WAS WEARING A GLOVE AND THE GLOVE BECAME ENTANGLED WITH THE GRIND ING WHEEL PULLI3G HIS THUMB INTO THE WHEEL.

EMPLOYEE WAS CU7TING WATER HOSE OFF PIPE NIPPLE, THE KNIFE SLIPPED AND CUT HIS HAND.

EMPLOYEE WAS HE5PING TWO OTHER MEN PULL A SUMP PUMP OUT OF A SUMP WITH COME-ALONG.

EMPLOYEE WAS LO5DING TOOLS TO GO TO FIELD TO WROK WHEN RIGHT CAB DOOR WAS CAUGHT BY WIND AND HIT EMPLOYEE IN HARD HAT AREA CAUSING HEAD AND BNAC PAIN.

EMP WAS STRUCK 0ROM BEHIND BY A SCRAPER HE HAD JUST FINISHED DOUBLE HITCHING WITH. HE HAD TO STOP TO LET ANOTHER SCRAPER PASS IN FRONT OF HIM AND THE SCRAPER BEHIND HIM COULDNT STOP IN TIME B UMPING HIS SCRA1ER IN THE R EAR

EMPLOYEE WAS LA3CING A PIN FROM FRONT END OF HAUL TRUCK. HAD JUST PUT A NEW ROD IN HOLDER AND STRUCK AN ARC. APPARENTLY THE HOLDER SHORTED THRU THE HEAVY GLOVE AND BURNED HIS LEFT HAND.

2 HAUL TRUCKS H3T HEAD ON IN STATE ROAD 42 BRIDGE.(BRIDGE GOES OVER HWY AND IS OWNED & MAINTAINED BY MINE).IMPACT BUCKLED CAB ON 1 TRACTOR CAUSING FIRE EXTINGUISHER & BRACKET TO BREAK LOOSE WH ICH HIT DRIVERS3ARM.BOTH BONES IN THE ARM JUST ABOVE WRIST WERE BROKEN.

EMPL PULLING ON31/4'' CABLE ATTACHED TO HINGED DOOR AT TAILEND OF WASHED COAL BELT TO OPEN DOOR.WHEN CABLE BROKE HE FELL TO FLOOR STRIKING HEAD AGAINST CEMENT WALL.INJ REQ 3 SUTURES.

EMPLOYEE WAS RE4OVING GEAR FROM PLANTARY AND STRUCK WITH SLEDGE HAMMER CAUSING PIECE OF STEEL TO BREAK OFF AND PENETRATE RIGHT THIGH.

EMPLOYEE WAS RE4OVING A HOSE FITTING FROM DIESEL PUMP STRIKING IT WITH A 16 OZ HAMMER HAMMER GLANCED OFF AND STRUCK HIM ON THE UPPER LIP CUTTING HIS LIP REQUIRING 4 STITCHES

EMPL HAD GOTTEN3INTO OPERATING CAB OF GRADER WHEN HE REACHED OUT TO PULL DOOR OF GRADER CLOSED.WHEN HE DID THIS HE GOT RIGHT THUMB CAUGHT BETWEEN DOOR AND DOOR JAM.THIS RESULTED IN SMASHING OF OF RIGHT THUMB3REQ REMOVAL OF THUMB NAIL.

EMPLOYEE STEPPI3G DOWN OUT OF TRUCK #105 OR #108 & STEPPED ON ROCK T WISTING RIGHT KNEE

EMP WAS UNLOADI3G DRUMS OF OIL ON WAREHOUSE DOCK AND APPARENTLY STRAINED BACK

EMPL USING 48''3PIPE WRENCH TO LOOSEN FITTING ON ELECTRIC PUMP-SLIPPED AND HIT WRENCH WITH RIGHT SIDE OF RIB CAGE.

EMPLOYEE WAS PU5LING HOSE ACROSS FLOOR TO HELP CLEAN OUT A CHUTE & STRAINED BACK DOING THIS

EMPLOYEE WAS CO4ING OUT OF TUB HOLE. HE WAS LIFTING HIMSELF OUT OF HOLE WITH HIS ARMS. HE HAD PAIN IN HIS LOWER BACK.

EMP WAS LIFTING3SUCTION PLATE TO THE TOP OF A SUCTION LINER WITH THE HELP OF TTWO OTHER PEOPLE THE IDEA WAS TO DROP TEH PLATE ON TOP OF THE S UCTION LINER I NAME DID NOT GET HIS LEFT HAND O OUT IN TIME TH9 TUFT OF SKIN ON HIS MIDDLE FINGER AND RING FINGERS WERE PINCHED OFF UNER THE WEIGHT OF THE SUCTION PLATE AGAINST THE SUCTION LINER

EMP WAS HOLDING3A PIECE OF METAL UP FOR TWO OTHER WELDERS TO WELD AT SOME POINT DURING THIS PROCEDURE EMP RECEIVED A FLASH BURN FROM UNDER HIS WELDING HOOD

WELDING TABLE T6RNED OVER WHILE CLEANING UP SHOP AND IT FELL ON HIS R FOOT BREAKING ALL HIS TOES. TABLE WAS SUSPENDED BY AN OVERHEAD HOIST. TABLE WEIGHT OVER 500 LBS. EMPLOYEE WAS WEARING STEE L TOE SHOES BUT3THE FORCE OF THE TABLE CRUSHED THE STEEL TOE

EMPLOYEES LEFT 7HUMB WAS ALREADY INJURED AND NAIL WAS IN PROCESS OF GROWING BACK, HE WAS USING A PRY BAR ON A BEARING WHEN IT SLIPPED. HIS HAND HIT THE SIDE OF THE TRACTOR REINJURING HIS THUM B NAIL 3

EMPLOYEE WAS BE5TING OUT A 2550 TOOTH BASE PIN WITH A HAMMER. THE PIN POPPED LOOSE AND FLEW UP IN THE AIR. THE PIN CAME DOWN AND STRUCK EMPLOYEE S HAND WHICH WAS ON TOP OF THE TOOTH. THE PIN W EIGHS ABOUT SIX3LBS.

EMP WAS CUTTING3PUMP HOSE AWAY FROM COUPL ER HE WAS CUTTING PULLING KNIFE TO HIM CUTTING HIS LEG. JUST HAD WARNED HIM ABOUT CUTTING THAT WAY

EMPLOYEE WAS KNEELING DOWN ON PUMP PLATFORM CLEANING COAL OUT FROM PUMP AND WHEN HE STRAIGHTENED UP HIS KNEE LOCKED.

EMPL REMOVING BELLY PAN FROM DOZER AND IT FELL AND HIT HARD HAT AND LEFT EAR WAS CUT FROM EITHER EDGE OF HARD HAT OR GLASSES.REC\D 9 STITCHES IN LEFT EAR.BROKEN BOLT IN BELLY PAN WAS CONTRIBUT ING CAUSE.EMPL WAS GOING TO LEAVE ONE BOLT INT I IT TO HOLD BEFORE JACK WAS PUT UNDER IT TO HOLD BELLY PAN UP.

COME-ALONG HANDLE BENT CAUSING PULLED NECK MUSCLE

EMPL SLIPPED OFF STEP OF POWDER TRUCK WHILE GETTING OUT AND STRUCK KNEE ON STEP OF TRUCK.

POLISHING STEEL WITH EMERY CLOTH.CLOTH CAUGHT ON STEEL AND PULLED THUMB INTO CLOTH.STEEL WAS ROUND ROD IN CHUCK ON DRILL PRESS AND DRILL WAS RUNNING.

EMPLOYEE LIFTED OXYGEN BOTTLE AND STRAINED HIS BACK.

HYDRAULIC HOSE WITH METAL ADAPTER ON END SWUNG & HIT EE ON FOREHEAD. EE WAS IN A HURRY & DID NOT TAKE TIME TO SECURE LOOSE HOSE.

EMPLOYEE WAS REMOVING A BEARING RACE FROM A LARGE SHAFT HE HAD ALREADY AIR ARCHED THE RACE AND WAS BEATING ON THE RACE WHEN A FRAGEMENT OF THE RACE BROKE OFF AND FLEW INTO HIS RIGHT EYE EMPLOY EMPLOYEE WAS WEARING SAFETY GLASSES BUT IMPROPERLY

EMPLOYEE WAS CLIMBING DOWN THE LADDER CARRYING HIS BUCKET OF TOOLS AT 2570 BUCKET SHED WHEN HE STEPPED OFF THE LADDER ONTO THE WHITE ROCK. HE TWISTED HIS LEFT ANKLE AND BROKE IT.

EMPLOYEE WAS USING AN ELECTRIC GRINDER ON A PIECE OF 1/8" STAINLESS STEEL, THE GRINDER KICKED BACK HITTING EMPLOYEE IN HIS LEFT WRIST PUTTING TWO CUTS IN HIS WRIST

EMPLOYEE WAS REMOVING A PIN FROM THE BUCKET LINKAGE IN THE ENDLOADER THERE WAS A BUMPER PIN LAYING ON FOLLR BELOW PIN THAT WAS BEING REMOVED THE PIN WAS IN TWO PARTS OF LINKAGE ONE PART WAS AN PART WAS AN ARM THE OTHER WAS THE HOSUING. WHEN PIN CAME OUT OF HOUSING THE ARM DROPPED DOWN PIN CHING FINGER BETWEEN THE PIN ON FLOOR AND PIN THAT WAS BEING REMOVED.

3 EES WERE TAKING A 6900 VOLT CBALE OUT OF THE #5-3 BREAK. ALL FORGOT TO TAKE THE POWER OFF THE BOX BEFORE THEY PULLED THE HEAD. AS THEY PULLED THE HEAD OUT IT FLASHED BEFORE BREAKER COULD TR IP. ALL RECEIVED FLASH BURNS.

3 EES WERE TAKING A 6900 VOLT CABLE OUT OF THE #5-3 BREAK. ALL FORGOT TO TAKE THE POWER OFF THE BOX BEFORE THEY PULLED THE HEAD. AS THEY PULLED THE HEAD OUT IT FLASHED BEFORE BREAKER COULD T RIP. ALL RECEIVED FLASH BURNS.

3 EES WERE TAKING A 6900 VOLT CABLE OUT OF THE #5-3 BREAK. ALL FORGOT TO TAKE THE POWER OFF THE B OX BEFORE THEY PULLED THE HEAD. AS THEY PULLED THE HEAD OUT IT FLASHED BEFORE BREAKER COULD TRIP. ALL RECEIVED FLASH BURNS.

IMPACT WRENCH SLIPPED OUT OF HIS HAND AND CLAMP ON AIR CHARGING HOSE CUT HIS HAND. CAUSED A DEEP LACERATION TO LEFT HAND WHICH REQUIRED SEVENTEEN STITCHES.

REPLACING RETURN ROLLERS ON BELT TO WASH COAL SILO A ROLLER STARTED ROLLING DOWN WALKWAY. EE STARTED AFTER IT & ANOTHER ROLLER CAME DOWN BEHIND HIM KNOCKING HIM DOWN ON GRATING CUTTING LEFT KN EE.

WALKING THROUGH SHOP AND STRUCK LEG AGAINST SHARP PIECE OF METAL

EMPLOYEE WAS HELPING REPAIR SWING BRAKE OILER WAS PRYING BRAKE SHOE TO LINE UP HOLES BRAKE SHOE SLIPPED OUT OF PLACE PINCHING VICTIMS FINGER BETWEEN BRAKE SHOE AND FRAME

EMP WAS FILLING OIL TANK ON 61 R DRILL WITH 5 GAL CAN OF OIL HIS FOOT SLIPPED WHEN THIS OCCURRED THE EMP REPORTS HE FELT A TWINGE IN HIS BACK EMP COMPLETED HIS SHIFT AND WHEN HE RETURNED TO WORK THE NEXT DAY HE REPORTED THAT HE WAS HAVING A PAIN IN HIS BACK

EMPLOYEE CAUGHT HIS HAND ON SOME MECHANICS WIRE WHILE CLIMBING THE MAST OF THE 2570 DRAGLINE THE WIRE CUT THROUGH HIS GLOVE PUNCTURING THE PALM OF HIS LEFT HAND THE INJURY WAS MINOR BUT A SERI OUS INFECTION SET IN THE NEXT DAY