Longhorn Cement Division Metal/Non-Metal

FORKLIFT OPERAT2R WAS PICKING UP PALLETS FROM EAST CORNER 1ST FLOOR PACKHOUSE. HE WAS LOOKING OVER HIS SHOULDER BACKING UP TOWARDS THE NORTH DOOR WHEN I NAME WAS WALKING FROM SOUTH SACKING MAC MACHINE AND WAL9D INTO FORKLIFT WHILE IT WAS IN MOTION AND WAS KNOCKED DOWN. THE BACKUP ALARM WAS SOUNDING. REAR WHEEL RAN ONTO HIS FOOT. OPERATOR STATED THAT VICTIM DID NOT MAKE ANY INDICAT

EMPL OPERATING 0ORKLIFT WHEN GETTING OFF HIT ELBOW AGAINST STEEL BAR.

EMPLOYEE WAS SI7TING IN 769B CAT HAUL TRUCK.LOADER WAS LOADING TRUCK WITH CLINKLER AND A LARGE CHUNK OF CLINKER FELL FROM LOADER BUCKET STRIKING TRUCK ON SIDE OF BED CAUSING TRUCK TO JERK VIOL ENTLY.EMPLOYEE 3OTICED PAIN IN BACK OF NECK.SAME AREA AS RECENT SURGERY.

EMPLOYEE WAS CH9CKING BELT CONEYOR #1 AND SLIPPED ON INCLINED WALKWAY-DID NOT FALL CAUGHT HIMSELF.

THERE WAS NOT A3 INJURY REPORTED, ON 5-7 87 THE EMP TOLD HIS FOREMAN THAT HIS BACK WAS HURTING AND THAT HE MAY HAVE KIDNEY PROBLEMS BECAUSE WHEN HE WOULD GO TO THE RESTROOM HIS BACK PROBLEMS W OULD BE RELIEVE8. ON 5-13-87 I.NAME CALLED I.NAME AND AFTER QUESTIONING HIM. I.NAME ALLEGED THAT HE WAS CLEANING A CHUTE WITH AN AIR HAMMER ON 4-26-87. WHEN A BIG CHUNK OF CEMENT HIT THE BAR

EMPLOYEE WAS CL3MBING DOWN FROM D9L AND HIS FOOT SLIPPED CAUSING HIM TO BRUISE THE BALL OF THE FOOT.

EMPLOYEE WAS MO5ING DUST WITH THE BOBCAT AND THE DUST WAS VERY SLIPPERY. THE BOBCAT SLIPPED QUICKLY TO ONE SIDE AND EMPLOYEE S ELBOW HIT THE CAGE.

EMPLOYEE WAS RE1LACING BAGS IN COMPARTMENT #7 OF 5-DC-1 ALKALI BYPASS DUST COLLECTOR

EMPLOYEE WAS RE7EIVING SACKS FROM THE SOUTH SACKING MACHINE CONVEYOR BELT AND STRAINED HIS BACK.

EMPLOYEE WAS RE7EIVING SACKS FROM THE SACKING MACHINE CONVEYOR BELT AND STRAINED HIS BACK.

EMPLOYEE WAS RE4OVING HOUSING AND BEARING FROM TAIL PULLEY OF DRAG CHAIN. EMPLOYEE DID NOT WANT TO SEE AT DR. AT THE TIME OF THE INJURY. HE DID NOT SEE A PHYSICIAN UNTIL 7-17-86. ON THE 7-17-8 6 VISIT THE DR 7HE EMPLOYEE TO STAY OFF WORK. WE ARE WAITING FOR A REPORT FROM THE PHYSICIAN.

EMPLOYEE WAS ST5NDING ON SOUTHEAST CORNER OF CLINKER BREAKER PLATFORM AND CONCRETE BASE. HIS RIGHT FOOT WAS ON THE CONCRETE BASE 18" BELOW THE FLOOR PLATE SUPPORT CHANNELS. HIS LEFT FOOT WAS O N THE FLOOR PLA7E SUPPORT CHANNELS. HE WAS GETTING READY TO USE CUTTING TORCH. TORCH WAS HUNG AND HE PULLED ON IT ATTEMPTING TO FREE IT. IT CAME LOOSE SUDDENLY AND HE LOST HISBALANCE AND FELL

EMPLOYEE WAS DI8CONNECTING THE HOIST HOOK FROM THE PALLET LIFT WITH HIS LEFT HAND AND HIT THE CONTROL BUTTON WITH HIS RIGHT HAND AND HIS FINGERS GOT CAUGHT BETWEEN THE HOOK AND FRAME.

EMPLOYEE WAS CL9ANING AROUND COOING TOWER, SLIPPED AND FELL. HE WAS TRYING TO KEEP FROM FALLING ON HIS BACK AND PUT HIS HAND DOWN TO CATCH HIMSELF. ACUTE RIGHT WRIST SPRAIN, CERVICAL SPRAIN.

EMPLOYEE WAS CU7TING DISCHARGE GRATES FROM 2 FINISH MILL AND DROPPED ON HIS LEFT 5TH TOE.

EMPLOYEE WAS CL9ANING NORTH SIDE OF BC-1, SLIPPED, FELL, TWISTING HIS BACK.

WORKING ON PIPI3G INSTALLATION THREAD BURR. ON PIPE JABBED INTO HIS KNUCKLE.

EMPLOYEE WAS RE4OVING THRUST PLATE FROM EAST TRUNION. HE WAS AWARE OF THRUST PLATE BEING LOOSE, HOWEVER, PLATE HIT PIPE AND GLANCED OFF PIPE HITTING EMPLOYEE S LEFT FOOT.

EMPLOYEE WAS US3NG A WHEELBARROW TO MOVE MATERIAL. THE WHEELBARROW BECAME OUT OF BALANCE, EMPLOYEE TRIED TO KEEP IT FROM FALLING BUT IT WAS TOO HEAVY.

EMPLOYEE WAS WO9KING INSIDE DUST COLLECTOR CHANGING DUST BAGS AND ALLEGES HE DEVELOPED A RASH ON BOTH FEET FROM THE CEMENT DUST. HE WAS WEARING SAFETY BOOTS.

EMPLOYEE WAS LI0TING A PIECE OF CEMENT CHUNK AND FELT PAIN IN LOWER BACK.

EMPLOYEE WAS TO3INSTALL CURRENT TRANSFORMER ON FINISH MILLS. FOR SOME UNKNOWN REASON EMPLOYEE DID NOT PULL THE POWER OFF AND STARTED TO REMOVE THE "LOAD" LEAD OFF THE CIRCUIT BREAKER. HE HAD S CREWDRIVER IN R7. HAND ANDLEFT HAND ON SCREWDRIVER SHANK PERHPS TO STABALIZE OR GUIDE IT. CONTACTED ENERGIZED TERMINAL THUS CARRYING CURRENT THROUGH SHANK ONTO HIS LEFT HAND.

EMPLOYEE WAS RE4OVING 5 X 30 SECTION OF PIPE IN PREPARATION FOR REMOVING BLOWER AND TWISTED HIS BACK.

EMPLOYEE WAS REMOVING HOT MATERIAL AWAY FROM P-2 AND APPARENTLY THE WIND BLEW THE MATERIAL INTO THE EMPLOYEES EYES

EMPLOYEE WAS LIFTING DIVISION HEAD GRATE AND METAL PLATE.WHEN HE LIFTED THE PLATE IT FELL ON HIS FINGER.WHEN HE PULLED HIS FINGER OUT FROM UNDER THE PLATE IT CAUSED A LACERATION.

EMPLOYEE WAS INSTALLING CLUCH ON #3 BALL MILL. CLUCH WAS HUNG BY CABLE AND GOOKED TO HYDROCRANE HOOK. EMPLOYEE WAS TWISTING CLUTCH WITH BOTH HANDS WHEN CABLE NEAREST RIGHT HAND FLIPPED OVER T THE CLUTCH EDGE PINNING FINGER IN BETWEEN. EMPLOYEE SHOULD KEEP HANDS CLEAR OF POTENTIALLY MOVABLE OBJECTS.

EMPLOYEE WAS GUIDING 1ST STAGE OF AIR OIL SEPARATOR DOWN INTO COMPRESSOR WITH BOTH HANDS.ROPE THAT WAS ATTACHED TO THE 1ST STAGE CUT AND BROKE WHICH LET IT DROP CATCHING THE EMPLOYEE\S RIGHT H HAND CAUSING A DEEP LACERATION.

EMPLOYEE WAS USING A HAMMER AGAINST BEARING RACE TO REMOVE BEARING RACE FROM SCREW BUSHING EMPLOYEE HAD BEEN WARNED NOT TO DO THIS THEY WERE INSTRUCTED TO REMOVE USING A DIFFENRENT METHOD

EMPLOYEE WAS STANDING ON LADDER ATTACHED TO PLATFORM AND WHILE DESCENDING HE TRIPPED. WHEN HE STARTED TO FALL HE PUT HIS RIGHT HAND OUT TO BLOCK FALL.

EMPL REMOVING 94 LB CEMENT SACKS WITH ASSISTANCE OF ANOTHER EMPL FROM 3\ HIGH CONVEYOR BELT TO PALLETS AND STRAINED HIS BACK.HE WOULD WORK 45 MIN THEN BREAK FOR 1 HR THEN REPEAT AND DID THIS-W ORK,BREAK,WORK,BREAK FOR TOTAL OF 4 HRS.EMPL REPORTED INJURY THE FOLLOWING DAY.

EMPLOYEE WAS PUSHING BURNER PIPE INTO FIRING HOOD.

EMPLOYEE WAS USING FRONT END LOADER/CLEANING OUTFROM UNDER BC-6 AND ALLEGES THAT HE STRAINED HIS SHOULDER.

EMPLOYEE WAS AIR LANCING 3RD STAGE EAST WITH AIR LANCE. HOT MATERIAL BLEW UNDERNEATH HIS SLEEVE - THE EMPLOYEE WAS NOT WEARING THE CORRECT GLOVES.

EMPLOYEE CUT INDEX FINGER ON LEFT HAND PUTTING RAMP INSIDE OF KILN.

EMPLOYEE WAS RIPPING HIGH LIME ROCK WITH D-10 RIPPER AND ALLEGEDLY BUMPED HEAD IN CAB OF DOZER. EMPLOYEE WAS NOT WEARING HIS SEAT BELT.

EMPLOYEE WAS DOING GENERAL CLEANUP ON PLANT SITE AND DEVELOPED A CHEMICAL REACTION, CHEMICAL BURNS OF HAND; SECONDARY INFECTION.

EMPLOYEE FAILED TO CUT VALVE OFF BEFORE WORKING ON DAMPER. EMPLOYEE WAS REPALCING PIN ON D AMPER 67. HE MASHED FINGER IN DAMPER CAUSING A SCRAPE. THE SCRAPE DEVELOPED INTO EARLY CELLULITIS.

EE ALLEGES HE WAS TAKING A CHAIN OUT OF A 55 GALLON DRUM & INJURED HIS BACK.

EMPLOYEE WAS REMOVING PICKHEAD FROM HANDLE. HEAD CAME DOWN AND SMASHED FINGERS AGAINST CRANE TRAMISSION.

CLEANING BC-1 AREA.WALKING UP STAIRS TO ROOF AND HIT HEAD ON SUB FLOOR.

EMP WAS POKING DOWN RISER DUCT WITH A BAR WHEN A CHUNK OF CLINKER FELL STRIKING THE BAR KNOCKING IT AGAINST HIS FACE

EMPLOYEE WAS WORKING ON MILWAUKEE CRANE WITH KNOCKER WRENCH AND SLEDGE HAMMER.

HITTING POKE BAR WITH SLEDGE HAMMER,MISSED BAR AND HIT FINGER.

EMPLOYEE WAS WALKING INTO THE CENTER SCALE OFFICE AND SLIPPED ON SOME LOOSE CLINKER EMPLOYEE WAS NOT AWARE OF EXTGENT OF INJURY UNTIL ADDITIONAL X-RAYS WERE TAKEN BY PHYSICIAN AND SENT TO SPEC IALIST FOR STUDY FIRST REPORT WAS WRIST INJURY (THOUGHT TO BE SPRAIN)

EMPLOYEE WAS CLEANING OUT THE NORTH BUCKET ELEVATOR USING A SMALL AIR HAMMER AND HIT HIS HAND ON ELEVATOR WALL