CAMP HILL QUARRY Metal/Non-Metal

A 12 VOLT FAN ON DASH FELL OVER & CAUSED A "SHORT" IN WIRING. HE PUSHED FAN BACK INTO POSITION & TOUCHED THE BARE WIRE WHICH GAVE HIM AN ELECTRICAL SHOCK.

DROVE HAUL TRUCK UNDER OVERHEAD CONVEYER WITH TRUCK BED IN RAISED POSITION.

EMPLOYEE WAS WALKING ON ELEVATED WOODEN WALKWAY WHEN PLANK PULLED LOOSE AT JOINT AND FELL THROUGH OPENING TO GROUND LEVEL BELOW.

EMPLOYEE WAS IN A HURRY TO ENTER CAB OF HAUL TRUCK. HIS FOOT SLIPPED ON WET LADDER RUNG, FELL TOTHE GROUND AND STRAINED HIS RIGHT KNEE.

USING CHAIN SAW TO CUT DOWN TREE WHICH FELL AGAINST WATER LINE STAND-PIPE AND THEN ONTO HIM

EMPLOYEE PICKED UP 4 FT PIECE OF 3 1/2" O.D. BORE HOLE (METAL) CASING AND STRAINED BACK AS HE TWISTED TO WALK AWAY FROM PILE OF CASING.

EE HAD CONNECTED RE-FUELING HOSE ONTO TRUCK TANK & OPENED VALVES TRUCK USES PROPANE AS FUEL AND STARTED TANK PUMP-HOSE BLEW APART AT FITTING IMPACTED SHOULDER AREA.

EE WAS UNCLOGGING THE JAMMED OUVERSIZE CHUTE AT THE PORTABLE PLANT. A STONE CAME OFF THE SHAKER, OVER THE TOP OF THE SCREENING AND HIT THE EE ON THE LEFT ELBOW RESULTING IN A LACERATION TO THE LEFT SHOULDER.

WAS DOING "PRE-SHIFT" EQUIPMENT CHECK- STRUCK LEG AGAINST EDGE OF BLADE ON GRADER- AREA WAS SORE FROM INJURY ON PREVIOUS SATURDAY (WHICH HE HAD NOT REPORTED).

WAS OPERATING HAUL TRUCK WHEN SMOKE FILLED CAB. BATTERY "HOT" WIRE SHORTED AND CAUGHT FIRE INSIDE BATTERY BOX- AS WAS CLIMBING DOWN LADDER STRUCK "SHIN" AGAINST LADDER RUNG.

WAS DRIVING SMALL DUMP TRUCK HAULING FROM CRUSHER TO STOCKPILES. GOT OUT OF VEHICLE BECAUSE FELT HOT, ILL AND PASSED OUT. TAKEN TO HOSPITAL WHERE BLOOD TESTS INDICATED CARBON MONOXIDE POISONIN G. DOCTORS FELT THAT EXTREME HIGH AIR TEMPERATURE, HIGH HUMIDITY AND CALM WINDS CONTRIBUTED TO BUILD-UP IN CAB OF TRUCK.

TEE FELT PAIN IN GROIN WHILE SHOVELING UNDER BELTS--REPORTED EVENT, KEPT WORKING--OVER PERIOD OF SEVERAL WEEKS CONDITION WORSENED--WAS CONVINCED ON 7-10-97 TO SEE DR. WHO DETERMINE A SMALL HER NIA HAD DEVELOPED.

EMPLOYEE WAS TRYING TO LOOSEN PIECE OF ROCK CAUGHT IN JAW CRUSHER

WAS USING SHOVEL TO CLEAN UNDER CONVEYOR BELT AND TWISTED/PULLED BACK. SUFFERED LUMBAR STRAIN.

HE IGNITED ACETYLENE TORCH WHILE CONTROL VALVES WERE IN "OPEN" POSITION INSTEAD OF SETTING TO "IGNITE" POSITION-SUFFERED 2ND DEGREE BURNS TO 2,3,4,5 FINGERS ON RIGHT HAND.

DRIVER TRAVELING WITH HAUL TRUCK BED IN RAISED POSITION ENTERED A TUNNEL FROM PLANT AREA TO QUARRY AREA & JAMMED TRUCK INTO TUNNEL OPENING DRIVER ATTENDED SAFETY LECTURE THIS DATE (PR IOR TO B EGINNING WORK) ON SUBJECT OF SAFE DRIVING VEHICLES IN QUARRY AREAS & SAFE SPEEDS WHILE TRAVELING

CLIMBED DOWN FROM HAUL TRUCK & TWISTED RT KNEE IN PROCESS

HELPING TO REDULL A HOLE INVENT TO UNHOOK STEEL DRILL IT SLAPPED BACK INTO FINGER.

EMPLOYEE WAS SHOVELING DIRT FROM UNDER A CONVEYOR BELT & TWISTED/PULLED BACK.

EMPL ENTERED TAGGED CRUSHER WITHOUT INSTALLING BLOCK GATE ON FEEDER. STONE FELL FROM FEEDER STRIKING EMPL IN RIGHT LEG CAUSING DISLOCATION OF KNEE WITH ASSOCIATED CARTILIDGE DAMAGE. THIS ACCID ENT COULD HAVE BEEN PREVENTED HAD EMPL INSTALLEDBLOCK GATE PRIOR TO ENTERING CRUSHER.

CLIMBED ONTO HOPPER EXITING HOPPER COMPLAINED OF PAIN IN L FOOT ROCK HAD FALLEN ON FOOT

2 EMPLOYEES WERE USING A CHAIN COME-A-LONG TO ADJUST THE SIZE OPENING ON A TELESMITH CRUSHER. THE ANCHORING CHAIN BROKE WHLE PRESSURE WAS APPLIED CAUSING THE CHAIN TO STRIKE THE EMPLOYEE.

EE WAS SHOVELING UNDER A CONVEYOR BELT WHEN HIS BACK BEGAN BOTHERING HIM.

EE HAD WRENCH SLIP OFF NUT STRIKING HIM IN THE NOSE FRACTURINGH SAME EE HAD SURGERY ON 12-4-90 AND RETURNED TO WORK 12-6-90. ONE DAY LOST TIME.

EMPLOYEE WAS ASSISTING IN REMOVING A ROCK FROM THE JAW CRUSHER WHEN THE CHAIN BEING USED BROKE STRIKING THE EMPLOYEE IN THE ABDOMEN.

THE EMPLOYEE WAS MOVING A LEAVER THAT CONTROLS THE GATES ON THE BINS AT THE WASH PLANT IN ORDER TO MOVE A TRUCK. THE LEVER IS USED TO HOLD THE BOTTOM GATES OPEN AND IS SPRING LOADED SO THAT I T WILL AUTOMATICALLY CLOSE. WHEN THE EMPLOYEE MOVED THE LEVER IT CAME BACK ADN STRUCK HIM JUST ABOVE THE RIGHT EYE.

EMPLOYEE WAS DISMANTLING A CRANE HE WAS ATTEMPTING TO DRIVE A PIN FROM BOOM WITH A HAMMER& PUNCH HE GOT HIS HEAD BETWEEN LACING OF THE BOOM & THE TRUCK ON WHICH THE BOOM WAS RESTING WHEN THE BOOM PIN RELEASED EMPLYEES HEAD WAS STRUCK BY THE LACING CAUSING IT TO CONTACT THE REAR OF THE T RUCK & LACERATING THE EMPLOYEES HEAD EMPLOYEE WAS WEARING A HARD HAT THAT PROBABLY PREVENTED MO

EMPLOYEE WAS SHOVELING STONE AR OUND PRIMARY CRUSHER WHEN HE ATTEMPTED TO THROW THE SHOVEL FULL OF STONE HE TWISTED & FELT A PAIN IN THE BACK

USING RATCHET AND SOCKET TO TIGHTEN BOLT SOCKET SLIPED CAUSING EMP TO FALL FORWARD STRIKING R EAR ON METAL BRACE AND LACERATING IT

EMPLOYEE WAS CLEANING AROUND THE PRIMARY CRUSHER & BELTS WHILE SHOVELING IN A BENT OVER POSITION THE EMPLOYEE TWISTED TO THROW A SHOVEL FULL OF STONE WHEN HE FELT SOMETHING PULL IN HIS BACKK

EMPLOYEE WAS DISMOUNTING HAULAGE TRUCK WHEN HE SLIPPED ON MUDDY STEP TREADS ON LADDER. EMPLOYEE STRUCK STOMACH ON SIDE OF VEHICLE.

EMPLOYEE WAS ATTEMPTING TO DUMP A LOAD OF LIMESTONE WHEN THE BANK GAVE WAY CUASING THE TRUCK TO ROLL OVER BACKWARDS. THE EMPLOYE STRUCK HIS LEG ON THE DOOR, CAUSING INJURY TO HIS HIP. DAMAGE WAS LIMITED TO THE HOIST OF THE TRUCK.

EMPL INSIDE BIN BARRING DOWN COMPACTED 2A STONE.LARGE PIECE OF STONE CAME LOOSE AND STRUCK RIGHT ANKLE.EMPL WEARING SAFETY BELT WITH ATTENDANT OUTSIDE OF BIN.

TRIPPED FELL ON ROCK INJ BACK ON 3-2-89

EMPLOYEE LOST CONTROL OF HAULAGE TRUCK AND FELL OUT OF THE VEHICLE ONTO THE HAULAGE ROAD.

INJURED EMPLOYEE OPERATING HAULAGE TRUCK. RETURNING TOLOADING SITE FROM PORTABLE PRIMARY CRUSHER. TRUCK BED WAS IN RAISED POSTION AND STRUCK PORTAL TO TUNNEL, CAUSING DAMAGE TO TRUCK AND EJE CTING OPERATOR FROM SEAT.

DISMOUNTING CRANE NO TC8 DURING LOADING OF TANK FOR DELIVERY TO LOCUST POINT QUARRY SLIPPED ON WET FOOTING & TWISTED LEFT ANKLE

CLOSING CLAMGATE ON OVERSIZE BIN AT ELJAY CRUSHER.TWISTED BACK OPERATING CLAMGATE LEVER.

PREPARING BLAST3HOLES.LIFTING STEEL CASINGS.DEVELOPED BACK PAIN DURING SHIFT.

INJ EMPL DRIVIN1 STEEL CASING INTO BLAST HOLE WITH HAMMER ON DRILL.CAUGHT THUMB BETWEEN CASING AND HAMMER.

EMPL WALKED TO 0RONT OF DRILL.LOOSE ROCK AT RIM GAVE WAY CAUSING HIM TO FALL.EMPL HELD ONTO AIR HOSE ON DRILL TO PREVENT FALLING FARTHER.FELL ABOUT 8' RESULTING IN STRAINING HIS BACK AND SHOUL DER.WALL WASNT 8HEER AND MAS POSSIBLE FALL COULD'VE BEEN 15'.INJURY BECAME EVIDENT DURING NIGHT FOLLOWING ACCIDENT.WORKED SEVERAL DAYS FOLLOWING INCIDENT.

LIFTING COMPRES8ED GAS CYLINDERS FRONT TRUCK. TWISTED BACK. PRIOR BACK INJURY LIFTING EXPLOSIVES BOXES 1/4/84.

VICTIM, A HAULA1E TRUCK DRIVER, WAS ASSISTING IN CLEANING A BIN CONTAINING MODIFIED CRUSHED LIMESTONE. USING A STEEL BAR, BRIDGED MATERIAL COLLAPSED, INUNDATING THE VICTIM. CLAM GATE WAS ACT IVATED TO PERMI7 STONE TO EMPTY FROM BIN AND RELEASING AND TRAPPED EMPLOYEE.

REPLACING MAIN SHAFT IN SHOVEL NO.SH38. SLACKED OFF ON COME-ALONG-COME-ALONG HANDLE SLIPPED AND STRUCK EMPLOYEE ON THE NOSE. WILL BE ADMITTED TO HOSPITAL. 5 YEARS AGO STRUCK IN FACE BY CRANE H OOK PROBABLY WILL REQUIRE EXTENSIVE FACIAL RECONSTRUCTION. WEARING SAFETY GLASSES-GLASSES NOT BROKEN.

EVIDENTLY INJURED BACK BY LIFTING BOXES OF EXPLOSIVES. DID NOT IMMEDIATELY DISABLE EE NOR WS COMPENSABILITY DETERMINED UNTIL SEVERAL WEEKS LATER. PRESENTLY DETERMINED TO BE AN INDUSTRIAL ACCID ENT & BEING TREATED IN HOSPITAL.