Green Bay Lime Kiln Metal/Non-Metal

Employee was closing the lids on top of a railcar when they tripped and fell forward. The employee was wearing their fall arrest and using a retractable lanyard. When they fell their arm was caught by the lanyard, resulting in a shoulder separation. Employee had surgery on 11/14/2023. Worked until then.

Employee felt a sharp pain in their right shoulder while pulling ash. Employee continued to work in full capacity until which time surgery was required on shoulder. Surgery was performed on 3/15/2023 to their shoulder.

Employee fell down a flight of 10 metal stairs in the Hydrating building. Employee failed to firmly plant foot on first step and failed to maintain 3 points of contact. Employee suffered minor bruising, lacerations and friction burns to their knees, shins, left cheek, left elbow, left shoulder, neck and right hand.

Employee went to use hand sanitizer and while pushing down on the nozzle the hand sanitizer was forced upward and into the employee's right eye. Employee noted a stinging in their eye. On 12/28/2020 the employee went to an optometrist and was prescribed an antibiotic eye drop.

As Graymont was not a party to this accident, Graymont does not have detailed information for this accident. Per the attached, Graymont maintains that this accident is not MSHA jurisdiction, is not chargeable to Graymont or mining industry, continues to be investigated by OSHA, was not a Graymont employee, & occurred outside of Graymont's privately held mine site.

Employee slipped on ice while exiting vehicle in parking lot. The employee landed on their elbow. Initially, employee did not report an injury. On 3/22/2019, employee reported to work with note stating they could not return to work for 2 weeks. On 4/15/2019 the injury was determined to be work related.

In the process of building a set of steel saw horses and an approximate 4' piece of 4X4 tube steel was standing vertical on the bench when it tipped and struck employee's left thumb between the steel tabletop and the piece the employee was handling.

Employee was on a back side of a cooler repairing steel, grinding, cutting and welding in dusty conditions. He was fine when he left work but the next morning his eye was irritated and felt like something was in it.

Employee opened lid of hydrate plant pugmill to inspect discharge end. When he closed the lid hydrated lime dust blew into his right eye. He was wearing safety glasses at the time. He immediately flushed the affected eye at the plant and was brought to the emergency room for additional flushing. He did not miss any work over the incident and returned to his normal work duties.

Employee was walking to parking lot when a wind gust blew lime into eye. Employee flushed eye. Additional medical treatment included prescription for the eye.

Employee was diagnosed with bilateral carpal tunnel syndrome. Employee is having surgery to repair. Date and time of accident is the date and time employee turned in paperwork showing the diagnosis.

Employee was using a 4 inch grinder to cut a piece of plastic. The grinder wheel grabbed the plastic and came into contact with employees left middle finger. The employee sustained a broken finger and a laceration.

Employee was removing chunks from G289 airlock with a rod. While employee was unplugging the G289 airlock; dust blew out of the pipe and into employees eyes.

Employee was pulling ash with the chunk puller and his left hand was pinched between an i-beam and the chunk puller causing a hand contusion with hematoma.

Employee was walking across the plant, when he slipped on the muddy and wet pavment. Employee fractured right wrist.

While employee was placing a bulk bag on the hydrate bagger, he overextended his reach which caused a muscle stain in his lower back.

Employee was pulling the ash can up with a hoist to empty the can. While employee was holding the chain to guide the ash can his thumb ran into the pulley. Employee's right thumb was cut and bruised.

Employee was raking ash with the ash puller, when hot lime dust was pushed out the door. Employee had a lot of lime dust hit face, left eye red and swollen.

Employee was using a front end loader to transfer stone from the stockpile to the reclaim system. The stockpile was frozen and snow covered in several areas. The employee undercut the stockpile attempting to reach thawed and thus free flowing stone. The stockpile overhead sloughed off and engulfed the loader into the cab.

Employee was pulling ash with ash puller and roller rest from the grates using the front pulling door. Employee struck his right hand against a burner pipe joint. The right little finger (pinky) is bruised and sore. Employee did seek medical attention on 1/30/07.

Employee was "pulling" ash with ash puller. When he lifted the ash puller, he felt a strain in his left elbow. He sought medical attention on 7-24-06; his left arm is in a sling; restricted to lifting 20#, cannot climb, occasional twisting motion allowed and seldom can squat or push/pull.

Employee was using a metal rod to clean the O2 analyzer. The system pulsed which caused hot air and dust to go onto his face. Lime and hot air combined to irritate both eyes; causing them to become red, puffy and water.

Employee was using a shovel to clean under the C32 elevator. He felt something "give" in his lower back while shoveling. (shift started previous night)

Employee was walking to the dust collectors when something blew into his right eye. Right eye became red and irritated with time. Went to a doctor and rec'd acular eye drops on 10/21/05.

Employee was using a prybar to pull off grates. Prybar slipped and hit employee on his chest and left side. Caused bruising and cuts to his chest. Em'ee started work the night of 10/18 at 6:30 p.m.

Employee was cleaning hot lime out of the #2 kiln basement. He put the hot lime into a barrel to haul out of the basement.

Employee was stepping into the skidsteer when her foot slipped causing her to fall against skidsteer with her right hand. This action bent her ring and pinky fingers backward.

EE was raking chunks of coal, while raking chujmks he twisted his back to toss chunks into a barrel. Ee felt pain in his lower back.

Employee was helping to install a sump pump near the hydrate plant; em'ee moved a pallet and slipped in water. The left boot filled with water, which reacted with lime and caused a burn to the top/left side of left foot.

Ee was attempting to dislodge a chunk of lime from the bottom of a baghouse. The hot dust that was hung up poured out onto his left boot. The extreme temperature of the dust caused the boot leather to become burning hot. The heated leather caused burns to his left foot. Ee did seek medical attention on 10-16-04.

EMPLOYEE WAS CHECKING RAILCAR TO SEE IF BOTTOM DOORS WERE CLOSED. HE STEPPED OFF CURB. HIS LEFT ANKLE GAVE OUT AND TURNED INWARD. EMPLOYEE DID SEEK MEDICAL ATTENTION: LEFT ANKLE SPRAINED.

EMPLOYEE WAS USING A WIRE WHEEL GRINDER. THE GRINDER HIT A PIECE OF METAL, KICKED BACK, HITTING THE EMPLOYEE ON RT. SIDE OF CHEST. EE DID NOT SEEK MEDICAL TREATMENT UNTIL 9/9/04.

EE WAS MIXING REFRACTORY USING A SHOVEL AND HOE. WHILE MIXING SHE FELT A "SNAP" IN HER RIGHT FOREARM. EE DID SEEK MEDICAL ATTENTION ON 5-11-04.

Employee was performing his normal duties as a hydrate operator. EE was feeling pain three hours prior to starting his shift. he did mention this fact to his supervisor.

EE WAS WALKING PAST THE CASE SKIDSTEER. HIS FOOT CAUGHT THE EDGE OF THE LOADER BUCKET. THIS CAUSED EE TO LOSE HIS BALANCE AND FALL FACE DOWNONTO THE GROUND. EE DID NOT SEEK MEDICAL ATTENTION UNTIL MARCH 1, 2004.

EMPLOYEE WAS CLIMBING DOWN THE LADDER ON A RAILCAR. HIS FOOT SLIPPED OFF THE LAST RUNG CAUSING HIM TO FALL AGAINST AN ADJOINING RAILCAR WITH HIS LOWER TORSO. HE THEN FELL TO THE GROUND LANDING ON HIS LEFT SIDE. HE DID NOT SEEK MEDICAL ATTENTION UNTIL FEB. 2, 2004.

EE WAS CLEANING OUT BOTTOM OF ELEVATOR. THE ELEVATOR DOOR CAME LOOSE, SWUNG DOWN AND HIT EE ON HIS HEAD.

EMPLOYEE WAS USING A GARDEN SHOVEL TO LOAD ASH CHUNKS AND STONE INTO A WHEELBARROW. HE FELT PAIN IN THE RIGHT SIDE OF HIS MID/LOWER BACK, WHILE HE WAS LIFTING/ TWISTING.

EE WAS MOVING A PALLET OF LIME WITH THE FORK LIFT. LIME DUST ENTERED EYE CAUSING EYE TO BECOME SORE.

EMPLOYEE WAS LEANING OVER A RAIL TO PUT BOLTS ON A PLATE. HE HAD A FEELING OF NUMBNESS AND THEN A SHARP PAIN IN HIS ABDOMEN WHEN HE STOOD UPRIGHT.

EE STATES HIS RIGHT WRIST IS SORE FROM WORKING OVER THE "YEARS". COULD NOT INDICATE ANY PARTICULAR DATE OF INJURY.

EE WAS LOADING HOT LIME MATERIAL WITH SKID STEERINTO THE BUCKLEY. UPON ENTERING THE PILE, THE HOT DUST AND STEAM ENGULPED HIM. HE RECEIVED BURNS AN HIS FACE ARM, AND CHEST AREA.

EMPLOYEE SLIPPED PARTIALLY INTO A CATWALK GRATE OPENING. HE HAS A LACERATION ON HIS LEFT LOWER LEG THAT REQUIRED SUTURES.

EMPLOYEE WAS PULLING AN EMPTY BULK BAG OUT OF A BUNDLE OF BAGS. HE FELL BACKWARDS ONTO THE CONCRETE FLOOR, EE HIT HIS LEFT ELBOW/ ARM ON THE FLOOR.

EE WAS IN THE PROCESS OF "KNOCKING DOWN" KILN ASH. EE TRIPPED OVER AN ASH PILE: HIS LEFT KNEE WAS OVEREXTENDED. MEDICAL ATTENTION WAS RECEIVED.

EE WAS SWEEPING THE PREHEATER FLOOR WITH A BROOM. DUST AND DEBRIS ENTERED HIS RIGHT EYE.

EE WAS WORKING AROUND THE PLANT DURING A SNOW STORM. WEATHER CONDITIONS WERE WINDY: DUST & LIME WERE BLOWING AROUND. A PIECE OF LIME BLEW IN HIS MOUTH ONTO HIS TONGUE.

EMPLOYEE WAS USING A RAKE TO PULL ASH CHUNKS FROM THE COOLER GRATES. EMPLOYEE FELT PAIN IN LOWER BACK FROM BENDING PULLING ACTION.

EE WAS BAGGING LIME.LIME DUST WENT THROUGH HIS CLOTHING, THE COMBINATION OF LIME DUST & THE HIGH TEMPERATURE CAUSED A CHEMICAL BURN TO HIS LOWER RIGHT BACK

WHILE PULLING 2X8 BOARDS OUT OF FEED END OF #1 KILN, THE BOARD FELL INTO THE HOPPER. THIS CAUSED THE OPPOSITE END OF THE BOARD TO BOUNCE UP. THE BOARD HIT EE IN THE CHEST AND PINNED HIM AGAINS T THE DOOR. EE EXPERIENCED CHEST PAINS AND SORENESS.

WHILE CLEANING OUT THE BAGGER PIT, LIME GOT INTO EE'S EYE RIGHT.

EE WAS RESTACKING 50# BAGS. HE PICKED ONE OFF THE FLOOR AND FELT PAIN IN HIS LOWER BACK. EE DID SEEK MEDICAL ATTENTION.

EMPLOYEE WAS CLEANING OUT THE SILO PRODUCT BINS, WHEN LIME FELL ON THE BACK OF HIS NECK. EE DID SEEK MEDICAL ATTENTION. HIS SHIFT STARTED ON 8/15/01 AT 6:30 PM UNTIL 6:30 AM ON 8/16/01.

WHILE PULLING HEAD PULLEY ONTO C-114 CONVEYOR, EE FELT PAIN IN HIS LEFT SHOULDER.

EMPLOYEE WAS USING A TWISTING MOTION TO MOVE EMPTY BAGS FROM THE LEFT SIDE OF THE BAGGER TO THE RIGHT SIDE. HE FELT A SHARP PAIN IN HIS LOWER BACK. EMPLOYEE IS SEEKING MEDICAL ATTENTION.

EE WAS PULLING ASH CHUNKS WITH A RAKE. HE NOTICED BACK PAIN. EE WENT TO THE DOCTOR ON 5-18-01.

WHILE PEROFRMING MAINTENANCE WORK, THE EE STEPPED ON A CATWALK AND THE GRATING GAVE WAY. EE FELL THRU WALKWAY AND LANDED ON A PIPE BELOW. EE DID SEEK MEDICAL ATTENTION.

EE WAS CLEANING UP A PILE OF LIME THAT SPILLED IN THE #1 BASEMENT. WHILE LIFTING, HE FELT A SHARP PAIN IN HIS LOWER BACK.

EE WAS STACKING BAGS: HE WENT TO GRAB A BAG THATWAS CAUGHT ON THE CONVEYOR BELT. HIS FINGER CAMEIN CONTACT WITH THE CONVEYOR BELT. HE DID SEEK MEDICAL ATTENTION.

EE CALLED IN ON 1-30-01 COMPLAINING OF PAINS IN HIS CHEST. HE ALLEGES WHILE HE WAS PULLING CHUNCKS OUT OF THE #1 BASEMENT HE FELT PAIN IN HIS NECK, SPINE AND CHEST. THE PAIN IN HIS CHEST CONTI NUED, SO HE WENT TO DR. HE HAS FRACTURED RIB.

EE WAS ENTERING THE DUST COLLECTORS. HE SLIPPED ON THE LADDER AND FELL FORWARD INTO THE DUST COLLECTOR. HE LANDED ON HIS RIGHT HAND. EE DID SEEK MEDICAL ATTENTION.

EMPLOYEE WAS CLEARING ASH CHUNKS FROM THE KILN COOLER GRATES. HE EXTENDED THE RAKE WITH HIS RIGHT ARM AND HIT HIS ELBOW ON THE SAFETY RAIL WHEN THE RAKE SLIPPED. EMPLOYEE DID NOT SEEK MEDICAL ATTENTION.

EMPLOYEE STUMBLED WHILE WALKING AND FELL FACE DOWN INTO A METAL POLE. EMPLOYEE DID SEEK MEDICAL ATTENTION.

EMPLOYEE WAS TALKING TO SOMEONE IN THE SHOP AREA. WIND PICKED UP AND BLEW LIME DUST IN HIS EYES. NOTICED IRRITATION LATER AND WENT TO HOSPITAL.

WHILE FILLING BULK BAGS OUT OF BIN 43, THE LIME DUST PUFFED UP. THE WIND BLEW THE LIME DUST UNDER EMPLOYEE'S SAFETY GLASSES. EMPLOYEE TAKENTO THE EYE CLINIC. MATION REC'D PRIOR TO 2/14/01 TO INDICATE ANY TREATMENT BEING GIVEN OR ANY DIAGNOSIS

EE MISSED A STEP WHILE CLIMBING DOWN FROM THE PREHEATER. HE NOTICED SWELLING AND PAIN APPROX ONE HOUR LATER. EE WAS TAKEN TO HOSPITAL.

WHILE TORCHING A HEATING PIN ON THE PAYLOADER BUCKET, THE EMPLOYEE TURNED TO LOOK AT THE PIN. AS HE TURNED THE TORCH MOVED ACROSS THE TOP OF HIS LEFT HAND.

EE WAS TOSSING ASH CHUNKS FROM THE ACESS DOOR OF KILN #2. HE FELT A SHARP PAIN IN HIS LOWER BACK.

EE WAS LIUFTING A 50 LB. BAG TO THE TOP OF THE PILE. HE FELT A PAIN IN HIS CHEST.

EMPLOYEE FELL OFF HIS TRUCK WHILE TARPING HIS LOAD. HE FELL FACE FIRST ON THE PAVEMENT. HE WAS TAKEN BY THE RESCUE SQUAD TO THE HOSPITAL. CORPORATE OFFICE NOTIFIED UMTHUN TRUCKING IMMEDIATELY AND WE CORRESPONDED HOSPITAL INFORMATION TO THEM

EE SLIPPED ON OIL THAT WAS ON THE SHOP FLOOR. HE TWISTED TO STOP HIS FALL AND FELT SHARP PAIN IN HIS BACK. EE IS NOT SEEKING MEDICAL ATTENTION AT THIS TIME. "THIS EE DID SEEK MEDICAL ATTENTION ON 1/10/00".

WHILE PULLING PLANKS OUT FOR KILN WORK, EMPLOYEESTEPPED ON A PLANK WITH NAILS STICKING UPWARD. EMPLOYEE WAS TAKEN TO INSTACARE TO GET IT CARED FOR AND TO GET A TETANUS SHOT.

EE WAS CARRYING A BAG OF VERSAFLOW (APPROX 26 LBS) ON HIS SHOULDER. EE SLIPPED OFF THE LOWER RAMP TO THE FLOOR.

EE WAS PULLING ASH CHUNKS FROM THE COOLER GRATESWITH A CHUNK PULLER. THE PULLER GOT STUCK IN THEGRATE, CAUSING EE TO USE CONSIDERABLE FORCE TO REMOVE4 THE CHUNKS

WHILE INSPECTING THE AIR DUCT BETWEEN THE COARSEDUST BOX AND DUST COLLECTOR FOR LOOSE TOOLS, EE FELL APPROX 15FT INTO THE COARSE DUST BOX

EE WAS KNOCKING DOWN LIME AND ASH IN THE #2 KILN, WHEN SOME LIME DUST AND CHUNKLS FELL BEHIND HS SAFETY GLASSES AND WENT INTO HIS EYES. HIS EYE WERE FLUSHED WITH SALIN SOLUTION AND HE DID SEEK MEDICAL ATTENTION.

EE WAS RACKING LIME. LIME DUST BLEW UP UNDER GLASSES.

EMPLYEE WAS PUSHING A TORCH CART ON AN UNEVEN SURFACE. HE INDICATES HE ALLEGEDLY AGGRAVATED AN EXISTING HERNIA.

GPF-EMPLOYEE WENT TO BELTONE FOR A HEARING TEST. BELTONE REPORTED TO EMPLOYEE THAT HE HAS A 45% HEARING LOSS IN LEFT EAR. EMPLOYEE FEELS IT MAY BE DUE TO WORKING CONDITIONS IN HIS FIRST YEARS OF EMPLOYMENT AT WESTERN LIME CORPORATION.

EE POUNDS THE LIME BINS TO DISLODGE CLUMPS OF LIME: WHILE DOING THIS, HE STATES HIS HANDS AND NECK BECOME SORE.

EE WAS CLEANING MUD OFF THE FLOOR. HE SLIPPED AND HIS LEFT PINKY FINGER GOT CAUGHT ON THE PLATFORM. LEFT HAND FRACTURE.

WHILE LIFTING A BIG STAR VALVE ROTOR INTO A HOUSING, EE FELT A SLIGHT PAIN IN HIS LOWER ABDOMEN STOMACH.

EMP WAS CLEANING UP AFTER FILLING BULK BAGS WITH PEBBLE LIME. WHILE SECURING LOADING SHOOT, HE STEPPED OFF THE SCALE ENCLOSURE (WHERE THERE IS AND APPROX 3" DROP OFF) AND SPRAINED HIS ANKLE. E MP DID SEEK MEDICAL ATTENTION.

EE WAS WELDING ON THE ID FAN. THREE HOURS AFTER LEAVING WORK, HE FELT PAIN IN HIS RIGHT EYE. HE PUT DROPS IN HIS EYE AND IT FELT BETTER. HE HAS HAD RECURRING PAIN.

EE WENT DOWN IN THE PIT AREA TO POKE LOOSE THE LIME IN THE TANK. AS IT RELEASED, LIME SHOT INTO HIS FACE AND GOT IN HIS EYES.

WHILE CLEANING THE FEED CHUTE ON KILN #1, EMPLOYEE CAUGHT FINGER BETWEEN PIPE AND METAL DOOR OPENING.

EE WAS PRODUCING SAMPLE BAGS IN THE PORTABLE BLENDER. AFTER PUTTING ON THE COVER AND TIGHTENING THE LAST WING NUT, HE STEPPED PARTIALLY TO THE SIDE AND PUSHED THE START BUTTON. WHEN THE BLEN DER STARTED, HIS LEFT HAND WAS NOT TOTALLY CLEAR OF THHE COVER. THE GLOVE HE WAS WEARING HAD ATEARIN THE PALM WHICH BECAME TANGLED ON THE WING NUT FOR THE COVE AND PULLED HIM OVER THE BLENDE

EE WAS BREAKING DOWN A RING OF ASH THAT WAS BUILT UP IN THE LIME KILN. WHILE USING A CROWBAR TO BREAK A PIECE OVERHEAD, LIME POWDER FELL INTO HIS RIGHT EYE. THE POWDER CAUSED SEVERE BURNS TO T HIS EYE. EE WAS TAKEN FROMT HE HOSPITAL TO A SPECIALIST.

WHILE CLMBING A TANKER LADDER WITH A BROOM AND SHOVEL IN HIS RIGHT HAND, HE LOST HIS GRIP AND FELL TO THE PAVEMENT.

WHILE FILLING 50# BAGS WITH HYDRATE, LIME SHOT THROUGH THE BAG. WHEN THE EE TRIED TO AVOID THE STREAM OF PRODUCT, HE STRAINED HIS BACK.

THE EMPLOYEE REMOVED HIS GOGGLES BECAUSE OF SWEATING. WHILE WALKING SOMETHING FELL IN HIS EYE.

EE WAS CLEANING OUT BASEMENT AREA UNDER KILN #1. HE WAS STRUCK IN THE EYE WITH A SMALL PIECE OF LIME OR ROCK WHICH HAD FALLEN OFF OF THE BELT.

EMPLOYEE WAS CLIMBING ONTO SCAFFOLD FROM DECK. AS HE STOOD ON A PLANK, IT GAVE WAY. AS HE WAS FALLING HE GRABBED A CROSSBRACE, WHICH CAUSED STRAIN TO HIS RIGHT SHOULDER. ALSO, SOMETIME DURING THE FALL HE BRUISED HIS LEG.

EMPLOYEE'S HAND SLIPPED OFF THE COVER OF THE COAL BELT, CAUSING HIM TO FALL FORWARD. HE TURNED HIS BODY TO AVOID HITTING A PIECE OF ANGLE IRON THAT EXTENDED SEVERAL INCHES OUT FROM THE BELT. H E WAS STRUCK IN THE LOWER BACK AREA.

EMPLOYEE WAS POUNDING RAM PINS OUT WHILE IN A KNEELING POSITION. HE COULD NOT INITIALLY WALK THE NEXT DAY WHEN HE GOT OUT OF BED. HE DID NOT SEEK MEDICAL ATTENTION UNTIL 12/7/94.

THE CRANE WAS LIFTING A SHEET OF STEEL. WHEN THE CHAIN SLIPPED OFF, THE SHEET LANDED ON A 4 X 4 BREAKING IT IN HALF. ONE HALF FLEW UP AND HIT THE EMPLOYEE ON THE SIDE OF THE HEAD. NOTE THAT TH IS IS NOT AN EMPLOYEE OF WESTERN LIME BUT RATHER A PHEIFER BROTHERS EMPLOYEE.

EE WAS SHOVELING COAL OUT THE COAL PIT AS HE THREW SOME COAL OVER HIS LEFT SHOULDER HE FELT PAIN IN THE SHOULDER (LEFT SIDE) & NECK AREA

EE WAS WORKING IN THE TUBE MILL. DUST WAS BLOWING AROUND THE AREA. EE NOTICED IRRITATION IN HIS EYE. HE SAW A PHYSICIAN ON 3/25/94.

EMPLOYEE WAS LIFTING A 5 GALLON PAIL AND AS HE TURNED, HE FELT A SHARP PAIN IN THE LOWER BACK.

EMPLOYEE WAS USING A CROWBAR TO LOOSEN STONE THAT WAS FROZEN ONTO THE ELEVATOR SHAFT. A PIECE BROKE OFF & THE CROWBAR CAME ABOUT & HIT HIM ON LTHE LEG BY HIS KNEE.

THE EMPLOYEE WAS WALKING AROUND A RAILCAR WHEN HE SLIPPED ON A MUDDY PORTION OF GROUND. WHILE TRYING TO CATCH HIS FALL WITH HIS HANDS, HIS LEFT THUMB WAS FRACTURED.

EMPLOYEE WAS GRINDING A METAL SURFACE WHEN A METAL SHAVING FLEW INTO HIS RIGHT EYE. THIS RESULTED IN A CORNEAL ABRASION.

EMPLOYEE WAS LIFTING EMPTY PURE CAL BAGS TO PLACE THEM ON THE BAGGER AT THAT POINT HE FELT A PAIN IN HIS LOWER LEFT PORTION OF THE BACK

EMPLOYEE WAS POUNDING WITH A MAUL ON THE LONG BELT SCRAPER CHUTE HE FELT A PAIN IN HIS UPPER LEFT SIDE OF BACK

EMPLOYEE WAS WALKING AROUND THE BAGGER AREA. HE STEPPED ON A PIECE OF CARDBOARDD. HE SLIPPED & FELL ONTO HIS RIGHT HIP.

EMPLOYEE WAS LIFTING A HEAVY SIDE PLATE FROM A GRINDER. THE EMPLOYEE HELPING LIFT THE PLATE LOST GRIP. THIS MOVEMENT CAUSED (INJURED) EMPLOYEE TO HAVE BACK PAIN.

54736YEE WAS PICKING UP A PALLET AT THE TIME HE FELT PAIN TO HIS GROIN AREA. MAY BE POSSIBLE HERNIA. AT AGE 21, HE HAD A HERNIA ON THE RIGHT SIDE.

54736YEE WAS CLIMBING DOWN A FIXED STEEL LADDER FROM THE PRODUCT BINS. AN INSECT/SPIDER LANDED ON HIS RIGHT EYE. THIS STARTLED HIM AND CAUSED HIM TO MISS A LADDER RUNG. HE HIT HIS WRIST ON A S 35530LADDER RUNG WHEN HE TRIED TO CATCH HIMSELF FROM FALLING.

EMPLOYEE WAS HOOKING UP AN ELECTRICAL CHAIN HOIST TO AN ACETYLENE TORCH TO LET IT DOWN FROM PREHEAT FLOOR. HIS FINGER BECAME CAUGHT BETWEEN THE CHAIN AND TORCH.

EMPLOYEE WAS IN THE KILN DOING MAINTENANCE WORK.HE LOST HIS FOOTING AND FELL ON HIS BACK.NOTE: EMPLOYEE DID NOT SEE DOCTOR UNTIL 06-24-92.

EMPLOYEE WAS CLIMBING DOWN A FIXED STEEL LADDER WITH A COFFEE CAN OF ALEN WRENCHES. HE LOST HIS GRIP. WHICH CAUSED HIM TO FALL AND LAND ON BACK. HIS RIGHT ARM WAS ALSO CUT BELOW THE ELBOW.

WALKING DOWN STAIRS FELL HIT HEAD ON FLOOR

EE WAS WALKING BEHIND FEED END OF KILN TO CLEAN FUEL ANALIZER.

WHILE CLIMBING LADDER TO DO WORK ON HYDRATE PLANT TANK WIND BLEW SAND INTO FACE.

EMPLOYEE WAS MAKING A GASKET USING A UTILITY KNIFE. THE KNIFE WENT THROUGH THE GASKET AND CUT HIS LEFT PINKY FINGER KNUCKLE.

WHILE THE EMPLOYEE WAS DESCENDING FROM THE TRUCK LOADINGF PLATFORM LADDER HIS FOOT SLIPPED OFF A RUNG WHILE TRYING TO CATCH HIS VALANCE THE WEIGHT OF HIS UPPER BODY WAS FORCED INTO HIS HAND & JAMMED IT TOWARD HIS WRIST

EE WAS DOING GENERAL MAINTENANCE ON THE DUMP TRUCK WHEN A PIECE OF DIRT FELL DOWN AND ENTERED HIS LEFT EYE.

THE EMPLOYEE WAS DRIVING A FORKLIFT TRUCK IN REERSE. THE LEFT REAR TIRE HIT A PALLET CORNER WHICH CAUSED THE STEERING WHEEL TO SPIN. WHEN THE STEERING WHEEL SPUN, THE SPEED KNOB ON THE WHEEL H IT THE EMPLOYEE'S ARM BETWEEN THE WRIST AND ELBOW THEREBY CAUSING A FRACTURE.

EMPL WAS HELPING TWO OTHER EMPLS REMOVE SCREW CONVEYOR SECTION OUT OF SCREW HOUSING WHEN HE FELT LOT OF PAIN IN LOWER BACK.

EMPLOYEE WAS OPERATING THE BAGGING MACHINE AT 11:50 AM. A BAG EXPLODED AND LIME ENTERED BOTH EYES FROM UNDER HIS SAFETY GOGGLES.

HE HAD JUST STARTED UP THE BAGGING MACHINE AT 7:05AM. DURING THE START UP, HE HAD EXPERIENCED PROBLEMS WITH THE HYDRATED LIME NOT FLOWING OUT OF THE BAGGER INTO THE BAGS. SO AT THAT TIME HE HA D STARTED TO CLEAN OUT THE FILLING SPOUTS WITH A SMALL ROD TO LOOSEN UP THE LIME THAT HAD BEEN CAUSING THE PROBLEM.HE ALSO INCREASED THE PRESSURE TO THE #2 FILLING SPOUT WHICH IS A NORMAL PRO

DUST PARTICLES HAD BLOWN INTO EMPLOYEES RT EYE WHILE CLEANING DUST OFF OF THE FIRING HOOD DUST HAD BEEN BLOWN BACK INTO THE EMPLOYEES EYE FROM THE WIND BLOWING THRU THE BUILDING EMPLOYEE WAS W EARING SAFETY GLASSE 293380257293380257 Y

EE WAS DOING ROUTINE CLEAN UP, LOOKED UP AND LIME DUST PARTICLES FELL OFF HIS HARD HAT INTO HIS RIGHT EYE. HE WAS WEARING A HARD HAT WITH A SAFETY SHIELD. THE DUST CAME THROUGH AN OPENING BY T HE MOUNTING BRACKET OF THE SHIELD TO THE HARD HAT

EMPLOYEE WAS ON HIS BACK UNDER WATER PLUNGER DOING MAINTENCE WORK. HYDRATED LIME DROPPED ONTO HIS FOREHAED AND SLID UNDER SAFTEY GLASSES INTO HIS RIGHT EYE.

EMPLOYEE WAS REACHING UP TO REMOVE A BRICK FROM THE TOP OF THE WALL. ANOTHER EMPLOYEE WAS ON THE OTHER SIDE AND DID NOT SEE HIM REACHING FOR THE BRICK. EMPLOYEE WAS HIT ON THE FOREFINGER OF TH E RIGHT HAND BY HIS SLEDGEHAMMER.

EMPLOYEE WAS RAKING ASH FROM KILN AND AIR AND DIRT BLEW INTO HIS FACE. DIRT WENT INTO EMPLOYEES EYE.

EMPLOYEE WAS CL2SING HOPPER BOTTOM AND SMASHED THUMB BETWEEN HOPPER AND GATE HANDLE

BAG EXPLODED WH3LE BAGGING AND HYDRATED LIME ENTERED BOTH EYES. EMPLOYEE HAS A BURN TO THE RIGHT EYE.

EMPLOYEE WAS ON3ROOF OF BUILDING SECTION OF ROOF GAVE WAY,EMPLOYEE FELL THROUGH TO PIPES BELOW.

EMPLOYEE WAS EM1TYING FEED AND DUST,HOT DUST POURED INTO A POOL OF WATER;WATER TURNED TO STEAM AND STEAM ROSE UP TO WALKWAY AROUND EMPLOYEE.

WHILE INSPECTIN1 THE PREHEATER INTERIOR DUST GOT INTO RIGHT EYE, RESULTING IN SCRATCHES AND IRRITATION.

WALKING INSIDE 8UST COLLECTOR, LOST BALANCE WHEN FOOT WAS CAUGHT IN TUBE SHEET. FELL AND BROKE LOWER LEG.

EMP WAS CUTTING3PLASTIC - UPON COMPLETION OF CUT, CIRCLE SAW KICKED BACK AND C UT INTO EMPLOYEES RIGHT LEG

EMPLOYEE WAS HA4MERING COAL, DURING ONE SWING EMPLOYEE SMASHED FINGER BETWEEN HAMMER AND COAL MILL DURING BACK SWING.

WHILE OPERATING3HYDRATE PACKER,BAG BROKE ON PACKER SPOUT CAUSING LIME TO FLOW FROM SPOUT INTO HIS FACE.

MANHOLE COVER O3 SCALE WAS OFF. HEATER WAS IN MANHOLE. PERSON MOVED HEATER AND FELL IN MANHOLE.

CLEANING ANALYZ9R PROBE LIME PARTICLE FELL IN EYE-RIGHT.

PIPE WRENCH WAS3ON SHAFT OF STAIR VALVE FORCE WAS APPLIED TO WRENCH & WRENCH BROKE BROKEN PIECE FELL ON RIGHT FOOT

WHILE DISPOSING OF A BROKEN BAG OF HYDRATE LIME INTO HOPPER THE CONTENTS OF BAG BLEW BACK INTO FACE AND EYES

WHILE DISLODGIN LIME FROM STORAGE BIN WITH SHAFT IN LEFT HAND, HE HIT RIGHT THUMB WHEN SHAFT STRUCK THE BIN.

BLISTERS ON ARMS FROM POISON IVY OR OAK WHILE CLEANING BRUSH AND WEEDS AROUND EQUIPMENT AND OLD PALLETS STORAGE AREA THE CONDITION STARTED TO DEVELOP BY 8/18/84 BLISTERED MORE BY 8/22/84

HE WAS SUPERVISING AND HELPING A MAINTENCE CREW TO CHANGE A SECTION OF ELEVATOR CHAIN AND AT ABOUT 1100 AM HE COMPLAINED OF BACKACHE AND LEFT THE JOB SITE REPORTED BACK TO WORK ON 4-10-84 AND SAID THE INJURYU OCCURED WHILE HE WAS DOING THE ABOVE.

WHILE REMOVING BRICK FROM SECTION OF VERTICAL EQUIPMENT SOME BRICK FELL DOWN HITTING BAR HE WAS USING CAUSING HIM TO FALL BACKWARDS AGAINST MACHINERY

CUT WRIST ON EDGE OF STEEL PIPE HE WAS MOVING

AFTER POKING THE KILN DROPPED THE ROD DOWN TURNED TO GO TO OTHER SIDE OF KILN TRIPPED OVER THE ROD AND SPRAINED LEFT FOOT

WHILE ATTEMPTING TO OPEN FEEDEND HOUSING BOTTOM DOOR A KILN BRICK FELL THROUGH OPENING HITTING RING AND SMALL FINGERS OF LEFT HAND

WHILE DESCENDING LADDER TO CRUSHER PIT SLIPPED AND FELL LANDING ON LEFT FOOT

WIND BLEW DUST IN EYE

SCAFFOLDING COLLAPSED

FOREIGN MATERIAL FELL INTO EYE WHILE MAKING A GREASE ROUND

WHILE POUNDING ON CHUTE HIT RIGHT HAND INDEX FINGER

WHILE DRILLING A PIPE LADDER SLIPPED FROM UNDER HIM

WHILE ROLLING A PIPE HIT RIGHT BIG TOE