MSHA record for Warner Co-Cedar Hollow Plant (mine ID 3600265). Fatalities, non-fatal incidents grouped by year, current operator and controller, and mine context.
Email me when a new MSHA incident is filed at Warner Co-Cedar Hollow Plant.
EMPLOYEE WAS REPORTING TO WORK & MISSED TOP STEP AT TIME CLOCK LOST HIS BALANCE IS FEET WENT OUT FROM UNDER HIM & LANDED WITH HIS BACK ON THE THIRD STEP HE WAS HOLDING THE HANDRAIL & TRIED TO BREAK THE FALL HE SUSTAINED A MUSCLE SPASM OF THE LOWER BACK
EMPLOYEE WAS CUTTING A CONVEYOR BELT WITH A RAZOR KNIFE WHEN THE KNIFE SLIPPED STRIKING HIS RT LEG ABOVE THE KNEE HE REQUIRED STITCHES
EMPLOYEE WAS WORKING IN DUSTY ENVIRONMENT UNDER VERY WIND CONDITIONS, WHEN WIND BLEW DUST IN LEFT EYE AND THE DEBRIS IRRITATED BEHIND BOTTOM EYE LID.
EE WAS SHOVELING DIRT IN WAREHOUSE. DIRT GOT UNDER PROTECTIVE GLASSES INTO LEFT EYE.
7EMPLOYEE WAS WALKING FROM OFFICE TO SHOP. SLIPPEDON ICE, FELL AND BRUISED LEFT KIDNEY.
EE WAS WALKING UNDER PEBBLE LOADER BELT SLIPPED ON WET LIME ON CONCRETE AND BUMPED RIGHT FOOT HEEL OF FOOT ON CURB.
EMPLOYEE WAS RATCHETING COME-A-LONG AND FELT A POP IN HIS RIGHT SHOULDER.
EE WAS LIFTING CONTAINER OF ANTI FREEZE INTO LOADER, STRAINED LOWER BACK.
EMPLOYEE WAS ATTEMPTING TO BREAK BLOCKAGE LOOSE IN DUST TRANSFER TANK. PINCHED FINGER BETWEEN SLEDGEHAMMER AND SIDE OF TANK. WORKING IN CLOSE QUARTERS.
EMPLOYEE WAS REUTRNING FROM WASTE SITE WHEN HIS TRUCK BODY PULLED ELECTRICAL WIRES DOWN ALONG WITH POLE.
EMPLOYEE CLAIMS HE WAS USING LEFT ARM RAISING LEVEL FOR PUMPING TRUCK BED.
AT END OF SHIFT EMPLOYEE PULLLED HOODED SWEATSHIRT OVER HIS HEAD DISLODGING LOOSE LIME DUST WHICH FELL IN HIS EYES.
EMPLOYEE WAS LIFTING & HANDING SCREEN TO COWORKER AS HE LIFTED & TURNED HE FELT A TWINGE IN HIS LOWER BACK
EE WAS ON 235 CAT WHEN HE SLIPPED OFF TRACK ONTO GROUND TWISTING LEFT KNEE LIGAMENT DAMAGE.
EMPLOYEE WAS SHOVELING MATERIAL OFF CATWALK REMOVING BUILDUP FROM BOARD UNDER BELT WHEN SHOVEL CAUGHT BELT JAMMING LEFT THUMB AGAINST FRAME WORK.
EMPLOYEE WAS HOISTING MOTOR TO SECOND FLOOR AT SUPER HYDRATE-HE HAD TO PUSH/PULL TO GET MOTOR OVER RAILING.
WORK BASKET WAS PICKED UP A W FORKLIFT JOB WAS COMPLETED EE WAS BEING LOWERED THEN BASKET HUNG ON THE LOADER SOCK AND WAS PULLED OFF THE FORKS CAUSING THE BASKET AND EE TO FALL TO GROUND.
EMPLOYEE WAS USING LARGE JACK HAMMER IN #2 ROTARY KILN TO REMOVE CASTABLE AND CLIPS. REPORTS PAIN IN LEFT ELBOW BACK AND CHEST.
EMPLOYEE WAS DESCENDING OFF LADDER-TURNED TO WALK. TO TUDE MILL, TWISTED ANKLE ON FROZEN UNEVEN LIME FALLING ON RIGHT ANKLE.
EE WAS HOLDING WRENCH TO LOOSEN BOLTS AT 3 COAL MILL HE USED A HAMMER TO HELP BREAK LOOSE THE BOLTS THE WRENCH SLIPPED AND PINCHED HIS TINGER BETWEEN WRENCH AND COAL MILL.
EE SLIPPED ON VET LIME-PUTTING STRAIN ON LEFT KNEE PREVIOUSLY INJURED. HE WAS WALKING TO REAR OF TRAILER TO LOWER DOLLY WHEELS.
EMPLOYEE WAS KNEELING DOWN ON GRATING TO CHECK A BEARING ON PALLET AND WHEN HE STOOD UP HE FELT HIS KNEE POP. SURGERY IS REQUIRED.
INJURED WAS CARRYING A GEAR BOX STRAINED NECK, SHOULDER, BACK.
INJURED WAS BLOWING LIME OUT OF MIXER AFTER MIXER CHOKER GOT DEBRIS IN LEFT EYE.
EE WAS STRINGING WELDING LEADS INTO POSITION TO DO AN ASSIGNED JOB WALKED INTO MUD CONVEYOR STRIKING HIS FOREHEAD WHEN QUESTIONED EE SAID HE HAD HIS HAT ON BACKWARDS.
EE WAS BURNING OUT PIECE OF OLD HOPPER IN TUBEMILL SECTION HE BURNED OUT TELL ON BASE OF LADDER BREAKING LADDER CAUSING HIM TO FALL.
EMPLOYEE WAS CUTTING PLASTIC TIP OFF OF ELECTRODE HOLDER W/UTILITY KNIFE. KNIFE SLIPPED AND CUT FINGER.
54730WAS BLOWING LOOSE LIME FROM TOP OF TRAILER. WIND BLEW LIME IN FACE. THEN EMPL SLIPPED OFF TOP OF TANKER-SAFETY CABLE STOPPED FALL HALFWAY DOWN SIDE OF TANKER. SAFETY HARNESS WAS BEING WOR 50369RECTLY. Y
55027RAINED HIS RIGHT SHOULDER WHILE SHOVELING SPILLAGE AT THE 5 FT PAN THIS IS A MAJOR COMPORRT FO HIS JOB.
9?514E REPAIRING LIGHTS ON LOADER HAD TO CLIMB OVER SAFETY RAILING TO GET TO LIGHTS. SLIPPED AND LANDED ON RAILING ON EMPL BACK.
EE WAS REMOVING HOIST CYLINDAR ON #486 EUCLID TRUCK-HE HAD HIS LEFT HAND BETWEEN CYLINDAR & FRAME (PINCHED) & WHEN HE PULLED IT OUT HE FELT PAIN IN LEFT WRIST.
PAIN IN CHEST DR IN HOSPITAL DIAGNOSED AS PUIMONARY EMBOLISM 5 DAYS IN HOSPITAL ON BLOOD THINNING DRUG REDIAGNOSED AS MUSCLE STRAIN.
CLEANING OFF INCLINE SLIPPED ON WET CLAY STRAINING NECK
INJURED WAS CRANKING DOWN DOLLY WHEELS ON TRAILER. TRXRH-1 TO PARK THE TRIALER. APIN ON HIS LEFT SIDE HORIZONTALLY ACROSS BODY.
HE WAS STACKING 6" PIPE IN A STEEL RACK. HE LIFTED ONE END AND PILE MOVED PINCHING HIS RIGHT THUMB BETWEEN TWO PIPES.
EMPLOYEE WAS USING JACKHAMMER TO REMOVE SOINT REFRACTORY FROM #2 RK AFTER COMPLETING WORK HE COMPLAINED OF NUMBNESS OF LEFT ARM ON 08-19-92 THIS WAS DIAGNOSED AS CARPAL TONNEL SYNDROME THE EMP LOYEE NOW HAS OPTED FOR SURGERY
I.NAME STANDING ON A BENCH PAINTING TOP OF DOOR.MOVED TO FAR TO ONE SIDE AND BENCH TIPPED OVER.FELL TO THE FLOOR AND LANDED ON REAR.
HE WAS OPERATING THE TRAYLOR JAW CRUSHER WHEN A BRIDGE OCCURRED. HE LOWERED THE CRANE HOOK AND HELD THE CABLE WITH LEFT HAND. HE STILL HOLDING THE CABLE TIGHTENED UP ON THE CRANE- THE CRANE TH EN SLAPPED HIS LEFT HAND.
BACK SPASMS DUE TO REPETITIVE BENDING AND SWINGING 50 LBS OF MATERIAL.
LIFTING PARTS IN MOBIL EQUIPMENT GARAGE AND SPRAINED BACK.
WHILE ATTEMTPING TO PUT GUARD BACK IN PLACE ALIGNMENT OF GUARD GUARD FELL PUSHING LEFT THUMB BACK.
I NAME WAS DOING 1AM STONE FILLUP HE WENT TO PULL A FROZEN LUMP OF STONE FROM THE BELT & GOT CAUGHT BETWEEN THE LUMP & #6 GATE STRAINING LEFT SHOULDER
HE WAS WALKING IN FRONT OF 8" PUMPS DISCHARGE HOSE BLEW OFF DOUBLE BOLT CLAMPS HIT HIM IN THE CHEST. HE FELL ON GROUND BUT DID NOT LOSE CONSCIOUSNESS. HE GOT UP. AMBULANCE WAS CALLED.
INJURED EE WAS SEALING LIME OFF CATWALK HAND RAILS ALONG 2 ROTARY KILN WHEN LIME DUST BLEW OFF RAILING INTO EE LEFT EYE CAUSING LIME BURN AND ABRAISION.
INJURED EMPLOYEE WAS ATTEMPTING TO CLOSE DISCHARGE VALVE ON HYDRATOR VALVE JAMMED & HANDLE HIT OPERATOR RT THUMB & KNUCKLES WHEN HANDLE HIT HAND IT SLIPPED OFF THE VALVE & HANDLE TURNED OLERA TORS HAND ONTO SIDE OF HYDRATOR
EMP DESCENDING ELEV MISSED LAST STEP OF LADDER TWISTED R ANKLE
INJURED EMPLOYEE ATTEMPTED TO RAISE DRIDGE AT PEBBLE LOAD STATION WEIGHT ON PULLEYS HUNG UP AND RELEASED QUICKLY INJURING LEFT WRIST.
EE WAS HAVING DISCHARGE PROBLEMS W/HYDRATOR WHEN OPENING THE DISCHARGE VALVE HE WRENCHED HIS SHOUDLER AFTER A PERIOD OF TIME THE PAIN BECAME WORSE & HE WENT TO THE HOSPITAL.
INJURED EMPLOYEE CONNECTED JUMPER CABLES TO AIR COMPRESSOR IN ORDER TO START IT. WHEN THE SWITCH WAS TURNED ON, THE CABLES IMMEDIATELY GOT HOT AND STARTED BURNING. HE ATTEMPTED TO TURN TO SWIT CH OFF BUT HIS LEFT FOOT GOT CAUGHT UNDER THE TONGUE OF THE AIR COMPRESSOR AND CAUSED HIM TO TWIST HIS KNEE AND FALL TO THE GROUND.
INJURED EMPLOYEE WAS CLEANING REAR WINDOW OF JOCKEY TRACTOR WHEN HIS FOOT SLIPPED AND HE FELL ACROSS TRUCK FRAME.
INJURED EMPLOYEE WAS USING A 3# SLEDGE HAMMER FOR A PROLONGED PERIOD OF TIME.
INJURED EMPLOYEE LEFT THE OIL STROAGE HOUSE WITH A BUCKET OF SOLVENT THERE WAS A PALLET WITH A 55 GALLON DRUM ON IT SITTING ABOUT 8' FROM THE DOOR.INJURED EMPLOYEE DIDN;T SEE THE PALLET AND TR IPPED OVER IT FALLING TO THE GROUND AND STRIKINGHIS LEFT KNEE ON THE CONCRETE.
EMPL LOADING TRX DUMP,THE CABLES WERE UNEVEN ON CHUTE.THE LOCK WOULDNT COME DOWN.EMPL CLIMBED ON HYDRAULIC COVER PLATFORM LOCATED DIRECTLY BEHIND CAB AT 13'HIGH.EMPL REACHING UP AND OVER TO TR Y STRAIGHTEN CABLES WHEN SHARP PAIN ENTERED LOW BACK EMPL IMMEDIATELY CAME DOWN.
INJURED EE WHILE SHOVELING LOOSE MATERIAL IN A CRAMP AREA UNDER 5 FT PAN IN PIT, SPRAINED HIS LEFT SHOULDER.
INJURED EMPLOYEE WHILE WELDING UNDERSIDE OF TRUCK BED, FELT PULL IN CHEST AND SHOULDER.
INJURED EE WHILE PERFORMING NORMAL REPETITIVE FUNCTIONS OF PACKING OPERATION AGGREVATED PERVIOUS INJURY OF RIGHT HAND.
INJURED EMPL WAS HITTING DRIFT PIN WITH SLEDGE WHEN SLEGE JUMPED & WEDGED LEFT SMALL FINGER AGAINST BOTTOM SIDE OF CRUSHER DRIVEN SHEAVE.
EMPL COMPLAINED OF PAIN,SORENESS IN ARM,BACK & CHEST.
INJ GRINDING SUPPORTS FOR NEW GUARDS ON QUARRY BELT,PIECE OF STEEL OR FIBERGLASS EMBEDDED IN EYE.EMPL WAS WEARING SAFETY GLASSES.
INJURED EMPLOYEE WAS CATCHING A 50 LB. BAG OF LIME FROM CONVEYOR BELT, WHEN HIS RIGHT HAND GLOVE BECAME LOOSE AND MUST HAVE GOTTEN CAUGHT BETWEEN CONVEYOR AND HORIZONTAL PLATFORM. HE QUICKLY P ULLED HIS HAND OUT OF THE GLOVE, THUS SPRAINING HIS THUMB.
INJURED EMPLOYEE WAS ATTEMPTING TO GET ONTO PLATFORM, AT SHIFT START-UP, TO GET TO HIS LOCKER AND COMMENCE TRUCK LOADING. EMPLOYEE STUMBLED AS HE RAISED LEFT FOOT FROM GROUND TO FIRST STEP AND INJURED LEFT WRIST ATTEMPTING TO CATCH HIMSELF.
INJURED EMPLOYEE WAS CLEANING GRATES FROM LOWER LEVEL IN HAMMERMILL WHEN SOME LIME BUILDUP BROKE LOOSE AND FELL ONTO BACK OF NECK.
INJURED EMPLOYEE WHILE WALKING THRU BAG STORAGE AREA CAUGHT HIS FOOT ON PALLET IN AREA, LOST HIS BALANCE AND FELL FORWARD HITTING RIGHT SIDE OF FACE ON CEMENT FLOOR. EMPLOYEE WAS CARRYING A HA NDFULL OF SPRINGS IN HIS HANDS AT THE TIME.
INJURED ALLEGES THAT WHILE PERFORMING HIS NORMAL JOB FUNCTIONS HIS SHOULDER BECAME SORE.
INJURED EMPLOYEE WAS WORKING ON TOP OF TRUCK REPAIRING PEBBLE LOADOUT SOCK, EMPLOYEE'S FOOT SLIPPED. ALSO, EMPLOYEE WAS WORKING IN EXTREME CROUCH POSITION FOR EXTENDED TIME. THE TWO CONDITIONS COMBINED PRODUCED INJURY IN EMPLOYEE'S LOWER BACK.
INJURED EE WHILE INSIDE THROAT OF NORDBERG CRUSHER CLEANING OBSTRUCTION, INUURED STRAINED RIGHT SHOULDER WHILE RAISING LARGE STONE OUT OF CRUSHER.
INJURED EMPLOYEE WAS ATTEMPTING TO DISLODGE ROCK CHOKING-UP CHUTE UNDER PRIMARY CRUSHER,USING A LONG BAR.WHEN ROCK PILE IN CHUTE MOVED IT CAUGHT THE END OF THA BAR,WHICH THEN STRUCK EMPLOYEE O N RIGHT SHOULDER AND SIDE OF HEAD.
INJURED EMPLOYEE WAS PULLING ON WRENCH TO LOOSEN JACK BOLT UNDER ECCENTRIC BEARINGS, STRAINING BACK.
INJURED EMPLOYEE WAS USING A SLEDGE HAMMER TO INSTALL SLIE IN HAMMERMILL GRATE AREA SLEDGE HAMMER SLIPPED OFF THE SLIDE & THE WEIGHT OF SLEDGE CONTINUED DOWN & CAUGHT INJURED EMPLOYEES FINGER ON METAL COVERING OVER ELEVATOR AREA
INJURED EMPLOYEE WHILE WALKING DOWN THE GRADE FROM MAINTENANCE SHOP TOWARD SUPER INJURED EMPLOYEE & ANOTHER EMPLOYEE WERE CARRYING THE TUB OF ACID BETWEEN THEM TUB SLIPPED OUT OF INJURED EMPLO YEES OHAND H IT THE GROUND & SPILLED ON LEFT UPPER LEG
ATTEMPT TO GUIDE DIFFERENTIAL IN HOUSING IT TWISTED CAUGHT LITTLE FINGER ON L HAND
INJURED EMPLOYEE REPORTED ON 04-23 THAT ON 04-19 HE EXPERIENCED SOME DISCOMFORT IN HIS GROIN WHYILE TIGHTENING THROUGH ROD NUTS ON #3 KILN DOWNHILL THRUST ROLL
INJURED EE WAS ASSISTING WITH REPAIRS TO TRUCK AXLE WHEN BLOCK SUPPORTING TRUCK WEIGHT SPLIT CAUSING TRUCK TO SHIFT. TRUCK BED HIT INJURED EE ON TOP OF HEAD JAMMING NECK. INJURED EE WAS WEARIN G HARD HAT. INJURED EE DID NOT REQUEST TO SEE DRAT THAT TIME AS HE THOUGH HE WAS OKAY.
INJURED EMPLOYEE WAS REMOVING PIPE FROM BOTTOM OF SCRUBBER TANK. PIPE SLIPPED AND PINNED FINGER BETWEEN PIPE AND BEAM, CUTTING FINGER.
INJURED EMPLOYEE WAS RUNNING UP STEPS FROM TRACK AREA TO #3 COAL BELT AREA, WHEN INJURED EMPLOYEE SLIPPED, JAMMING HIS LEFT WRIST ON THE STEPS.
INJURED EMPLOYEE AND ANOTHER EMPLOYEE WERE USING HAMMERS TO HIT BLOCKED CHUTE TO LOOSEN MATERIAL. HAMMER OF OTHER EMPLOYEE "GLANCED" OFF CHUTE, STRIKING INJURED EMPLOYEE ON LEFT KNEE.
EMPLOYEE COMPLAINED OF LIME BURNS ON HIS NECK & ARMS
INJURED EE WAS TRYING TO MAINTAIN LIME FLOW TO TUBEMILL, DUE TO STICKING LIME IN FEED CHUTE FROM TOP SCREW TO TUBEMILL FEED SCREW, EE WAS SCRAPING STICKING LIME IN SCHUTE, WHEN LIME SPLASHED O UT AND COVERED EE.
INJURED EMPLOYEE WAS BACKING JOCKEY TRUCK UP TO HOOK UP TO TRAILER AND MISSED THE PIN WITH THE FIFTH WHEEL PLATE. EMPLOYEE WAS INSTRUCTED TO RAISE THE TRAILER IN ORDER TO CLEAR THE PIN, HE HA D PUT BLOCKS DOWN TO BE ABLE TO RAISE THE TRAILER HIGH ENOGH TO CLEAR THE PIN, IN DOING SO HE PULLED OR STRAINED HIS LOWER BACK.
INJURED EMPL WHILE ATTEMPTING TO CLEAR BLOCKAGE OF WET COAL THAT BUILT UP IN COAL BUNKER FEED CHUTE. INJURED WAS STANDING ON COUPLER GUARD & BELT GEARSET USING 12' METAL ROD TO UNJAM BLOCKED C HUTE. WHILE USING JABBING MOTION EMPLS LEFT FOOTSLIPPED OFF GEARSET & AT SAME TIME RIGHT FOOT SLIPPED OFF UNSECURED COUPLER GFUARD. EMPL FELL DOWN ON FEED CHUTE.
INJURED EMPLOYEE HAD DISCHARGE BLOCKAGE AT HYDRATOR WHEN HE PROCEEDED DOWN THE STEPS TO THE DISCHARGE, HE SLIPPED ON THE STEPS AND REACHED TO BLOCK HIS FALL, JAMMING HIS THUMB.
CLEANING MIXER AND REPOSITIONING IT , TIGHTENING REDUCER WITH WRENCH WRENCH SLIPPED CAUSING IN TO FALL BACK AGAINST THE SUPER CONTROL ROOM
INJURED EMPLOYEE WAS WORKING ON RETURN SIDE OF PAN CONVEYOR AT HEAD SPROCKET AND WAS EDGED ALONGSIDE BENT RIDING RAIL STRUCTURE. EMPLOYEE ATTACHED OVERHEAD HOIST TO PAN TO TAKE UP SLACK, HOIST ACCIDENTALLY PULLED TOO MUCH ON PAN FREEING JAM, JUMPED UP THROWING EMPLOYEE'S TORSO AGAINST PINION SHAFT.
INJURED EMPLOYEE WAS DIGGING LIME OUT OF PIT & SHOVELING INTO A WHEELBARROW WHEN HE LIFTED A SHOVEL FULL OF LIME UP TO PUT IN THE WHEELBARROW THE LIME SLID OFF THE SHOVEL & DOWN EMPLOYEES ARMS INTO HIS FACE
INJURED EMPL WAS ATTEMPTING TO UNCLOG ROK CHUITE. EMPL STARTED TO BEAT ON CHUTE WITH HEAVY BAR. WHILE DOING THIS ONE OF BLOWS GLANCED OFF SIDE OF TANK FORCING HAND INTO PIECE OF ANGLE IRON USE D TO SUPPLY PEBBLE CHUTE.
INJURED EMPLOYEE FELT SLIGHT SORENESS IN LEFT WRIST. THE WRIST WAS SO SORE HE COULD NOT USE IT. EMPLOYEE WAS ENT TO HOSPITAL AND PROBLEM WAS DIGNOSED AS ACCUTR TENDONITIS.
INJURED EMPLOYEE WAS BEATING ON BOBCAT BUCKET WITH HAMMER TO CLEAN BUCKET, LIME FLEW BACK IN HIS EYES. LATER ON IN THE DAY, INJURED EMPLOYEE WAS WALKING UNDER #3 COAL CONVEYOR AND FELT SOMETHI NG ENTER HIS EYE. HE ASSUMES IT WAS COAL DUST.
CUTTING COVEY WITH KNIFE ALONG FRAMING SQUARE PULLING KNIFTE ALONG SIDE SQUARE HE SLICED THUMB OPER REQ STITCHES.
INJURED EMPLOYEE HAS BEEN STACKING PALLETS FOR THE PAST FIVE YEARS.
INJURED EMPLOYEE WAS WORKING IN A SEATED POSITION SCRAPING THROUGH THE LOWER ACCESS DOOR OF THE TUBEMILL TOP SCREW DISCHARGE CHUTE. WHILE CLEANING CHUTE THE HANDLE END OF THE SCRAPING TOOL STR UCK HER UPPER LIP.
INJURED EMPLOYEE WAS SHOVELING STONE & DIRT OFF OF THE RADIAL STACKER PLATFORM THE MATERIAL WAS RATHER HARD & DIFFICULT FOR A SHOVEL TO PENETRATE EASILY FOR SEVERAL HOURS THE INJURED EMPLOYEE CHIPPED AWAY AT THE BUILTUP MATERIAL WITH THE SHOVEL RESULTING IN BRUISE TO THE PALM OF HIS HAND
INJURED EMPLOYEE WAS REMOVING A BRICK FROM DISCHARGE OF A COOLER ON #2 RK WITH BOTH HANDS WHEN ANOTHER BRICK EXITED BED OF MATERIAL IN COOLER STRIKING HIM ON RIGHT HAND
INJURED EMPLOYEE WAS WELDING A 4" NIPPLE ON THE BOTTOM OF SCREW CONVEYOR WHICH HAD BEEN CUT OPEN ON PREVIOUS SHIFT. EMPLOYEE STARTED WELDING NIPPLE ON BOTTOM OF CONVEYOR HOUSING WHEN THE LIME WAS HUNG UP ABOVE THE HOLE FLUSHED DOWN REFLECTING INTO HIS WELDING HOOD AND INTO HIS LEFT EYE.
USING PICK TO BREAK MATERAIL LOOSE ON PLATFORM SWING ING THE PICK PICK CONTACTED TOP RAIL OF HAND RAILING CAUSING EMP TO LOOSE CONTRO OF PICK AND THE PICK STRUCK HIM ON THE LEFT KNEE. Y
EMPL WORKING ON MICHIGAN FEL .EMPL USING DRIFT PIN AND PINCH BAR TO KEEP FLANGE AND PINION FROM TURNING.OTHER MECHANIC TIGHTENING PINION WITH 1" DRIVE AIR IMPACT WRENCH .ACTION OF WRENCH CAUSED DRIFT PIN TO SLIP OUT OF NOTCH THROWING BAR WHICH STRUCK EMPL IN FACE CUTTING UPPER LIP AND BREAKING 2 TEETH.
HURT BACK WHILE LIFTING GRATES.ACCIDENT NEVER REPORTED TO MGMT THEREFORE,WE BELIEVE THIS NOT WORK RELATED.
INJ WORKING ON HOT BELT DUST COLLECTOR.IN PROCESS OF DISASSEMBLY OF ELEC COMPONENTS WHEN CHANNEL LOCKS SLIPPED CAUSING SPRAIN IN NECK.EMPL IN CROUCHED POSITION MOST OF DAY.
TIGHTENING UP VISE TO HOLE PC OF EWUIP TO WORKED ON EMP PULLE DUP ON VIE WITH L. ARM FELT SOMETHING PULL IN NECK.
INJURED EMPL WAS DOING LOT OF BENDING & LIFTING UNDER & AROUND TRUCK 527. HE WAS REMOVING TIRES, BRAKES & BRAKE DRUMS. NEXT DAY EMPL MENTIONED TO SUPERVISOR BACK BOTHERED HIM & WANTED AN APT W ITH CO DR.
INJURED EMPLOYEE WAS SHOVELING MATERIAL FROM PIT ONTO ISIDE PAN WHEN THE EXPERIENCED CHEST PAINS AND TIGHTENING OF CHEST, ALSO SHORTNESS OF BREATH. OPERATOR CONTACTED FOREMAN AND EMPLOYEE WAS TAKEN TO HOSPITAL.
INJURED EMMPL WAS CLMBING LADDE R ON READING BAGGER RIGHT FOOT SLIPPED GRABBED RUNG WITH LEFT HAND STRUCK LEFT SHOULDER & JERKED LEFT SHOULDER WITH BODY WEIGHT. RIGHT BUTTOCK ALSOI STRAINED WH EN HANGING ON WITH LEGT HAND. CY
WORKING AT TAIL PULLEY OF INSIDE PAN SPROCKET FELL INTO LOOSE LIM E ON FLOOR AND CAME UP INTO EMP FACE.
INJURED EMPLOYEE WAS CLEANING UP WAREHOUSE (STOREROOM). HE TOOK THE TRASH BAG WEIGHING APPROX. 25 LBS. TO THE TRASH BIN. AS HE THREW THE BAG INTO THE BIN, HE FELT HIS MUSCLE PULL IN HIS LOWER LEFT BACK.
INJ USING JACKHAMMER TO REMOVE PART OF OLD CONCRETE SLAB IN PUMPHOUSE.PLACED HAMMER AT AN ANGLE TO GET UNDER SLAB.HAMMER SLIPPED CAUSING EMPL TO SOMEHOW STRAIN HIS BACK.
INJURED EMPLOYEE WAS USING PIPE WRENCH ON GATE TO PUT LIME INTO SURGE TANKS WHILE STANDING ON TOP SCREW WRENCH SLIPPED CAUSING MAN TO FALL HITTING LEFT SIDE
INJ EMPL PUTTING KILN BRICK IN KILN,EMPL GRABBED BRICK ROLLER SYSTEM.ANOTHER EMPL PUSHED BRICK FORWARD ON ROLLER CONVEYOR SMASHING EMPL FINGER BETWEEN 2 BRICKS.
PUTTING BRICK IN KILN DID NO; T BANG OR HURT ELBOW FELT IT JUST STIFFFENING DUE TO BENDING TI SO MUCH DOING BRICK WORK.
INJURED EMPLOYEE WAS KNEELING DOWN WELDING A CHAIN ON THE POID ELEVATOR.FINISHED JOB AND GOT UP TO LEAVE WHEN HIS RIGHT BOOT CAUGHT ON SOMETHING CAUSING HIS RIGHT KNEE TO TWIST.
INJ EMP TWISTED ANKLE WHILE WALKING FORM EMP PARKING LOT TO HIS STATION OF W ORK.
INJURED EMPLOYEE WAS CHIANGING BARRELS FOR FULLER SCREW IN SUPER. MOVING PARTS AND REMOVING PLATES AND PART IN AN AWKWARD POSTION. MAN CLAIMS THAT AFTER LEAVING WORK, HIS LEG BEGAN TO HURT.
INJURED EMPLOYEE STOOPED TO PICK UP EMPTY SAMPLE CAN ON 3RD FLOOR OF HAMMERMILL BACK WENT OUT
INJURED EMPLOYEE WAS WALKING BEHIND GARAGE AND S TEPPED ON A STONE CAUSING EMPLOYEE TO TWIST ANKLE
INJURED EMPLOYEE WAS LIFTING THE ELBOW FOR #3 COAL MILL IN PLACE. THE LIFTING EYE WELDED TO THE ELBOW BROKE AND THE ELBOW ROLLED OFF STRIKING EMPLOYEE ON LEFT SHOULDER.
INJURED EMPLOYEE WHILE OPENING DROP OUT DOOR ON GATHERING SCREW ON #3 BAGHOUSE,HOT MATERIAL GOT INTO HIS GLOVE AND BURNED HIS AHND BEFORE HE COULD REMOVE GLOVE.
INJURED EMPL WHILE CHECKING TRAILERS STEPPED ON ROCK THAT WAS IN PUDDLE OF WATER & TWISTED HIS RIGHT ANKLE.
INJURED EMPLOYEE WAS BACKING JOCKEY TRUCK UNDER DUST TRAILER TO CHECK REPAIRS HE HAD JUST COMPLETED TO THE TRACTOR'S 5TH WHEEL. TRAILER WAS LOADED, EXTRA FORCE HAD TO BE USED TO ENGAGE 5TH WHE EL. WHEN TRACTOR MAKE CONTACT WITH TRAILER HITCH, THE IMPACT THREW EMPLOYEE AGAINST BACK OF CAB CAUSING INJURY.
INJ EMP BEGAN EXPERIENCING ITTITATION WHILE STRIPING NORBACK FROM SYMONS CRUSHER BOWL
INJ EMP WAS USING A SHOVEL MUCKING OUT PULL BACK ELEVATOR PIT HE SLIPPED AND FELL AGAINST DOORWAY LEADING TO THE MILL
INJURED EMPLOYEE WAS WELDING PATCH ON COAL PIPE OF @I KILN WHEN HE BECAME DIZZY AND HAD A VERY RAPID HEARTBEAT
INJURED EMPLOYEE WAS REACHING OVER FEED CHUTE ON MIXER TO MAKE AN ADJUSTMENT ON FLOW ARM WHEN THE MIXER BLEW BACK STEAM FROM FEED CHUTE HITTING EMPLOYEE ON RIGHT ARM CAUSING BURNS
INJURED EMPLOYEE WAS CLEANING OUT THE PULL BACK ELEVATOR WHICH WAS CHOKED WITH THE VACUUM CLEANER CREATING A LOT OF DUST EMPLOYEE GOT LIME DUST IN HIS EYES
INJURED EMPLOYEE SLIPPED ON WET MATERIAL WHILE CHECKING PUMP AT INSIDE PAN PIT CAUGHT HIMSELF ON RIB CAGE ON HAND RAIL
INJURED EMPLOYEE WAS REMOVING BROOM FROM A RACK AND A WRENCH FELL FROM SAME RACK STRIKING FOOT
INJURED EMPLOYEE WAS ON TOP OF PULL BACK SCREW, CLEANING TOP PULL BACK SCREW. WHILE COMING OFF SCREW EMPLOYEE TEPPED ON PILE LIME, CAUSING EMPLOYEE TO TWIST RIGHT ANKLE.
INJURED EMPLOYEE WHILE ATTEMPTING TO CORRECT A SNAG IN CHAIN THAT ACTIVATES THE TRIP ON LATCH ABAR IN THE BUCKET LID CAUGHT HIS MIDDLE FINGER BETWEEN LATCH BAR AND BUCKET LID
INJURED EMPL GOT LIME OR SUBSTANCE IN RIGHT EYE.
INJ EMP WAS DESCENDING STEPS FROM LOADING PLATFORM TO TRACK AREA. HE SLIPPED AND STRUCK HIS BACK AGAINST ONE OF THE STEPS
INJ EMP WAS REMOVING A PIECE OF COAL RING FROM CHUTE TO #4 TANK. MATERIAL FELL FROM TURNHEAD AND STRUCK EMP ONH AND AND FORED HAND AGAINST PIECE OF STEEL IN CHUTE, INJURING FINGER
INJ WMP WAS GOING UP LADDER TO TOP OF TRUCK, OPERATOR STEPPED ON RUNG WITH LEFT FT (ARCH) FELT PAIN IN F OOT
INJURED EMPLOYEE WAS LIFTING CHUTE FROM TANKER. AS HE STARTED TO LIFT, SOMETHING PULLED IN HIS BACK.
INJURED EMPLOYEE WAS WALKING DOWN THE STEPS AT PEBBLE LOADING PLATFORM. SLIPPED ON WET STEPS AND INJURED BACK.
INJURED EMPLOYEE WAS USING SMALL HAND GRINDER ON CLIPS ON BELT TO REMOVE OLD CLIPS. GRINDER KICKED BACK STRIKING MAN ON RIGHT INDEX FINGER CAUSING DEEP LACERATION.
INJ WAS SWEEPING UNDER CRUSHER AREA, EMP STRUCK RTIGHT ELBOW ON PIECE OF ANGLE IRON
INJURED EMPLOYEE WAS DESCENDING FROM CAB OF DROP BALL STEPPED ON TRAVEL PAN WHICH WAS SEPARATED DUE TO REPAIR IN PROGRESS EMPLOYEE SLIPPED AND TWISTED ANKLE.
INJURED EMPLOYEE WAS LIFTING A 5 GAL CAN OF OIL, HE FELT PAIN IN UPPER BACK NEAR NECK.
INJURED EMPLOYEE WAS TIGHTENING MIXER SPRAY WRENCH SLIPPED EMPLOYEE FELL FORWARD AND HIT HEAD ON STEEL BEAM CAUSING A CUT TO HIS FOREHEAD.
INJURED EMPLOYEE WAS STEPPING ON SUPPORT BEAM ON TUNNEL BELT TO GET SKIRTING HIS FOOT SLIPPED AND HE BANGED RIGHT KNEE ON BEAM.
INJURED EMPLOYE9 WAS CLEANING FLOOR IN HAMMERMILL HIT WHEELBARROW WITH HIS RT ELBOW REINJURING HIS ELBOW
INJURED EMPLOYE9 WAS CLEANING LIME OFF PIA PACKING BLDG ROOF EMPLOYEE WAS USING A PICK SWINGING THE PICK IT CAME IN CONTACT WITH A STEEL BEAM REINJURING I.NAMES ELBOW
INJ EMPL DRILLI3G WELDING LEAD STINGER,DRILL BIT FETCHED IN SCREW HOLE.WELDING STINGER AND LEADS BECAME WRAPPED CAPTURING HAND AND TEARING THUMB NAIL OFF.
INJURED EMPLOYE9 WAS REMOVING CAP FROM A FIAT ALLIS LOADER TO OBSERVE WATER LEVEL AND WAS BURNEED BY MIXTURE OF WATER AND OIL WHICH RELEASED FROM THE CAP
INJURED EMPLOYE9 WAS CLEANING AREA ALONG NORTH SIDE OF A-15 BELT CONVEYOR. WHEN A LARGE STONE FELL FROM ABOVE 30 FT HIGH FROM 52 FTBELT STRIKING INJURED ON SIDE OF FACE BY LEFT EYE.
INJ EMP WAS PAS8ING UNDER #2 KILN AT #1 HOT TIRE AND HIS HARD HAT SCRAPED THE KILN AND THE BUILDUP OF LIME ON KILN FELL ONTO THE BACK OF HIS NECK
INJURED EMPLOYE9 WAS CLEANING HARD LIME FROM DUCTWORK.WHILE DOING THIS,HE BANGED HIS RIGHT ELBOW.
INJURED EMPLOYE9 WAS HAVING TROUBLE WITH LIME COMING OUT OF HYDRATOR HE WAS OPENING THE VALVE WITH A PIPE IN HITTING THE VALVE TOO HARD HE CAUGHT HIS HAND BETWEEN A STEEL STRUCTURE AND THE P IPE 3
INJURED EMPLOYE9 WAS REMOVING THE COVER ON THE TUBEMILL USING A CHAIN COME-ALONG WHILE RAISING THE COVER THE HOOK CAME OUT CAUSING THE COVER TO FALL WHILE DOING THIS THE CHAIN HIT THE EMPLOYEE LEFT ELBOW 3
INJ EMPL WALKIN1 ALONG #2 ROTARY KILN TOWARDS SO/ STONE END.WHILE WALKING DOWN STEPS BY KILN DRIVE,SLIPPED ON 2ND STEP-ICY-FROM BOTTOM.GRABBED HANDRAILS AND WHILE TRYING TO CATCH HIMSELF HE TW ISTED HIS BACK.3
EMPLOYEE WAS CLEARING THE BLOCKED SCRUBBER SYSTEM WHEN HE INJURED HIS BACK.
MAN WAS REPAITRING A FENDER ON A TRUCK. HE WAS BRAZING THE FENDER WHEN THE TORCH BLEW BACK CURNING HIS RT FOREARM.
INJURED WAS LIFTING & SORTING 6 1/2" STEEL PIPE IN A WET MUDDY AREA OF THE QUARRY PAN WHEN HE HURT HIS BACK.
WHILE MOVING 1 1/2" STONE GATE INJURED STRAINED HIS BACK GATE WORK AT TIMES STONE GETS STUCK ALONG SIDE OF GATE.
INJURED EE WAS CLOSING THE LARGE STOREROOM DOOE WHEN HE SLIPPED & PULLED HIS GROIN MUSCLE.
INJ EMP WAS CLIMBING OUT OF TRUCK AFTER LOADING IT WITH PEBBLE LIME AND AS HE STEPPED TO GROUND HE SLIPPED ON ICE AND TWISTED HIS KNEE
WET AND ICY CONDITIONS. INJURED EMPLOYEE CLAIMED TO HAVE TURNED HIS ANKLE ON THE RAILROAD TRACK APPROX. 50\ WEST OF THE PEBBLE LOADING CHUTE.
EMPLOYEE WAS STRADDLING A LOCKED OUT SCREW CONVEYOR AND BENDING OVER TO ONE SIDE TRYING TO TIGHTEN BOLTS WHICH ARE A PART OF SEVERAL OUTLETS FROM THIS SCREW AS HE PULLED HE FELT THE MUSCLE STR AIN OR PULL IN HIS BACK
EMPLOYEE WAS ASSISTING IN MAKING ADJUSTMENT TO THE PRIMARY JAW CRUSHER. AS HE PULLED ON A LARGE WRENCH, HE FELT SOMETHING CATCH IN HIS LEFT SHOULDER AREA AT WHICH TIME IT BECAME VERY PAINFUL TO MOVE HIS HEAD (OR TURN HIS HEAD) TO THE LEFT AND TO LIFT HIS LEFT ARM.
EMPLOYEE HAD FINISHED LOADING TANKER WHEN HE STEPPED FROM THE BACK OF THE TANKER TO THE GROUND. HIS RIGHT FOOT SLIPPED OUT FROM UNDER HIM
WHILE SHOVELING STONE SPILLAGE AT THE QUARRY PAN FEEDER INJURED EMPLOYEE FELT A PAIN IN THE LOWER BACK AREA
WHILE LIFTING CHANNEL IRON AND IRON PLATES SHARP APIN OCCURRED IN EMPLOYEES LEFT SHOULDER WEIGHT LIFTED WAS APPROX 100 LBS
EMPLOYEE USED A LADDER TO REACH A GREASE FITTING, LOST HIS BALANCE AND FELL.
WHILE EMP WAS HOOKING PULLER TO WELL DRILL CASINGS HE GOT HIS HAND CAUGHT BETWEEN THE BUCKET LIP ON THE JOHN DEERE LOADER AND THE CHAIN BEING USED TO PULL WELL DRILL CAINGS WHILE LOADING PRIM PRIMARY SHOT
A dated report covering the 26-year penalty trail, line-item violation pattern, contest and docket posture, rate-normalized peer benchmark, and full fatality history. Delivered as a PDF with the underlying data as CSV.