WEBER QUARRY AND MILL Metal/Non-Metal

Splitting stone and a piece of stone landed on EE's right foot.

Splitting stone blocks with chisel and maul and piece of stone fell on foot.

Employee was walking alongside moving forklift, forklift turned and ran over employee's left heel.

Stone block broke at drier, the piece that fell cut employees left leg below the knee.

stacking flagstone slabs onto bigger slab that was raised up by loader for transporting to cutting area. The big slab broke and fell onto employees right foot, breaking it in three places.

Cutting straps from bundles of landscape stone, when 2nd strap was cut the stone pieces fell all over pinching employees finger between stones.

Moving power lines and shoulder popped.

Stacking 8-9" cut wall stone onto pallet, stone piece he was stacking broke apart which then caught his finger tip between the stones and cut it off. It is his left hand middle finger.

Flipping stone, finger got caught between stone and table. Open fracture to right-hand pinky finger from top joint to tip of finger; bone crushed, stitches to close and re-attach fingernail.

On 7/25 EE said he was going to chiro. He did not say he got hurt during work. Not convinced this is work related injury because of what ee did over weekend on July 28, but found out on 8/22 that work. comp. insurance will be treating injury as work related until further investigation.

Swinging maul to split stone and felt pain in leg and by 6/18/2012 pain moved to lower back.

Pushing stone off of stone cutter that had broke down, thus injuring his back.

Sunny day, hot, humid

sunny

PICKED UP A PIECE OF STONE WHICH CRACKED WITH ONE PIECE DROPPING ON FOOT WITH SLIGHT FRACTURE. WILL BE BACK TO WORK IN 2-3 WEEKS WITH NO FURTHER OR FUTURE IMPAIRMENT.

LIFTING A STONE STEP & BACK POPPED

HE WAS PUTTING A SLAB OF STONE THRU A HYDRAULIC STONE CUTTER. THEY GUIDE THE STONE INTO THE TEETH OF THE CUTTER BY HAND. HE GOT HIS FINGERS IN TOO CLOSE TO THE TEETH AND GOT ONE OF THEM PINCHE D BETWEEN THE CUTTER TEETH AND THE STONE.

THIS MAN WAS STACKING STONE ON PALLETS AS IT CAME OFF THE END OF THE HYDRAULIC CUTTER. HE DROPPED A PIECE OF STONE AND IT HIT THE TOP OF HIS FOOT BRUSING IT BADLY THE X RAY APPEARED TO HAVE A HAIRLINE CRACK IN IT.

EE WAS MAKING FLAGSTONE. HE WAS USING A MALL TO BREAK SLABS INTO PIECES. HIT FINGER WITH AMLL WHILE STRIKING AT PIECE OF STONE. HE SMASHED A FINGER VERY BADLY REQUIRING STITCHES EXRAYS AND ETC .

EE WAS SPLITTING FLAGSTONE PIECES HIS ARM SLIPPED AS HE WENT TO BREAK THE SLAB WITH A MALL AND THE ARM CAME DOWN ON THE EDGE OF TYHE SLAB AND MADE A DEEP LACERATION REQUIRING STITCHES.

HE WAS HELPING MOVE SLABS OF STONE AROUND TO LOAD ON A TRUCK AND HE TWISTED HIS BACK.

EMPLOYEE WAS PULLING ON A OVERHEAD HOIST THAT PICKS UP PIECES OF STONE AND MOVES THEM. HE TWISTED HIS BACK AND PULLED A MUSCLE. THIS WAS NOT CAUSED BY ANY MACHINE OR ANY CERTAIN THING. IT WAS JUST A WRONG MOVE ON HIS PART THAT CAUSED HIM EXTREME PAIN FOR SEVERAL DAYS.

HE AND ANOTHER EMPLOYEE WERE SPLITTING BLOCKS OF STONE AND ONE OF THE PEICES THEY SPLIT OFF BROKE IN TWO PIECES. ONE PEICE OF THE STONE HIT MANS ARM AND THE SHARP EDGE PUT A DEEP CUT IN THE A RM.

TAKING OFF OLD SHEETING ON BUILDING SLIPPED AND FELL

EMPLOYEE WAS USING THE JACK HAMMER AND SPLITTING STONE INTO SLABS OFF THE BIG BLOCKS OF STONE. A PEICE OF STEEL BROKE OFF THE HEAD OF THE HAMMER AND PEIECRED THE EMPLOYEES ARM.

EMPLOYEE WAS LIFTING STONE OFF THE END OF THE CUTTER AND STACKING IT ON PALLETS. HE STRAINED HIS BACK MUSCLES WHEN IN THE PROCESS OF LIFTING THE STONE.

EMPL WAS HELPING LOAD A PIECE OF POLISHED STONE IN A CUSTOMERS VEHICLE USING ONLY HIS HANDS TO HOLD ON TO THE PIECE OF STONE HE SPRAINED THE LOWER PART OF HIS BACK WHEN HE PICKED THE PIECE OF STONE UP OFF THE PALLET

EMPL WAS CARRYING STONE FROM THE HYDRAULIC STONE CUTTER TO THE PALLET TO STACK IT HE STEPPED ON A SMALL PIECE OF BROKEN STONE THAT WAS LAYING ON THE GROUND AND TWISTED HIS ANKLE

EMP WAS CUTTING TREES ON SIDE OF HILL. SUN WAS SHINING ON HILL AND AREA BECAME SLIPPERY CAUSING MANS FOOT TO SLIP. THE CHAIN SAW CAME DOWN ACROSS HIS LEG CUTTING THROUGH HIS PANTS AND MAKING A SMALL LACERATION ON HIS LEG REQUIRING A FEW STITCHES

EMPLOYEE WAS SP5ITTING STONE INTO LAYERS TO DO THIS THEY INSERT A WEDGE INTO THE SEAM IN THE BIG BLOCK OF STONE AND HIT IT WITH A MAUL TO SPLIT THE STONE IN TO TWO PIECES THE STONE HAD A FRACT URE IN IT AND B9OKE BEFORE IT SHOULD HAVE AND HIT HIM IN THE STOMACH AREA KNOCKING THE WIND OUT OF HIM

EMPLOYEE WAS PI7KING UP A PIECE OF STONE TO SET ON THE PLANER MACHINE TO BE PLANED HE DROPPED THE PIECE OF STONE PINNING HIS FINGERS BETWEEN THE PLANER MACHINE AND THE PIECE OF STNE

THE MAN WAS SPL3TTING A BLOCK OF STONE INTO SLABS.THEY USE A HAMMER AND WEDGE AND SPLIT THE STONE ON THE BED LINES.A SLIVER OF STEEL BROKE OFF THE HEAD OF THE WEDGE AND PENETRATED HIS LEFT SH OULDER.THIS WAS3A NEW WEDGE.

EMP WAS WORKING3CLEARING OUT SOME TREES MAKING A NEW ROADWAY FOR ACCESS TO MORE STONE A LIMB OFF OF ONE OF THE TREES STRUCK HIM IN THE FHAND AND WRIST BRUSING IT. THE TREES HAD BEEN PUSHED OU WITH THE DOZER 5ND HE WAS ACTUALLY TRIMMING THEM SOT THAT THE LOGS COULS BE SAWED

EMPLOYEE WAS US3NG A BIG WRENCH TO LOOSEN SOME BOLTS ON A MOTOR HE WAS WORKING ON & HE STRAINED HIS BACK

WORKER STACKING3STONE ON PALLET.STONE BEING TAKEN OFF END OF HUYDRAULIC CUTTER.PIECE OF STONE BROKE IN 2 PIECES WHEN WORKER PICKED IT UP AND AS IT FELL IT CAUGHT HIS LEFT HAND AND BRUISED IT.

EMPLOYEE WAS WO9KING REGULAR JOB PUTTING STONE THROUGH THE HYDRAULIC CUTTER. WAS WEARING SAFETY GLASSES. SOME DUST OR FOREIGN MATTER MUST HAVE BEEN IN THE AIR AND HIS EYES BECAME IRRITATED CAU SING A SLIGHT I3FECTION.

THIS MAN WAS SP5ITTING A SLAB OF STONE ON THE BED LINE OF THE STONE. WHEN IT SPLIT IN 2 PIECES ONE OF T HEM HAD A DRYER IN IT & FELL APART & A PIECE OF T HE STONE FELL ON HIS FOOT BRUISING I T. 3

WORKING ON END 2F CUTTER PULLING STONE THROUGH AND STACKING IT ON PALLET.A BIGGER PIECE OF STONE CAME THROUGH AND FELL ON HIS THUMB AS HE REACHED TO PICK UP SMALL PIECE OF STONE.

MAN WAS OPERATI3G JACK HAMMER DRILLING OUT A BLOCK OF STONE.THE DRILL STEEL BROKE IN HALF AND THE REST OF THE JACK HAMMER FELL DOWN ON HIS RIGHT FOOT BRUISING THE TOP OF THE FOOT NOT PROTECTED WITH STEEL SAFE7Y FLAP.

A SLAB OF STONE3CRACKED THROUGH THE MIDDLE AND HALF OF THE SLAB DROPPED ON THE RIGHT FOOT AND ANKLE. THE EMPLOYEE WAS STACKING SLABS OF STONE WHEN THIS HAPPENED

WAS WORKING ON 5 TRUCK IN THE SHHOP. HE WAS LAYING UNDER THE TRUCK AND EVEN THOUGH HE HAD HIS SAFETY GLASSES ON, DIRT GOT IN HIS EYE

EMP WA LIFTING 8TONE TO PLACE ON A PALLET. HE STRAINED A MUSCLE IN HIS BACK

EMP WAS TAKING 1IECES OF STONE AS THEY WERE PUT THROUGH THE CUTTER AND STACKING THEM ON A PALLET. A PIECE OF STONE BROKE INTO TWO PIECES AND INE ONE OF THEM DROPPED ON HIS FOOT