Cementon Quarry Metal/Non-Metal

Employee was working in slag dryer DC fan shroud with concurved base, as he was inside he threw out a piece of steel ring he had cut from the fan plenum. As he threw object employee slipped on the incline in the fan housing and fell against the housing hitting his right side; shoulder, ribs, arm and a small laceration under his right eye.

Lifting corner of bridge crane with 50 ton hydraulic cylinder (port-a-power) to remove cribbing from under crane. As the crane was being lifted, the cylinder was ejected from under the crane and hit employee in chest. Contusion to chest, heart, lungs, spleen, laceration to liver and broken rib(s).

While the employee was loosening a 4" pipe cap with a 3' pipe wrench he felt pulling sensation in his back that caused a strain.

While pushing up clinker with loader, employee was scraping south side of shed floor. While backing up, employee alleges to have hit concrete wall with rear of loader, causing neck to be hurt on left side.

Employee was using a chipping bar to clear chunks from the Feeder.As employee was poking a chunk he was flipped by the bar as the chunk fell onto the pry bar. Employee fell and struck upper right side and thumb on the mid-rail of the floor handrail system.

Two employees working on seized pump. Employee locked the pump out, unseized it; took off the lock and reset it. Pump seized up again so the employee instructed his partner to turn the pump back a second time with a 4 foot pipe wrench. The pump started and the wrench flew out of the partners hand and hit the employee in the right forearm.

Walking around Feeder, employee allegedly stepped on a piece of flooring and lost balance, falling and striking his left arm, elbow and shoulder.

Cable was slacked when tension caused cable to slip across spool causing right foot to be pinned between cable and spool.

Employee was walking to shower room - caught shoe on seam in concrete- tripped and dropped glass dish he was carrying. Employee fell and left hand hit the broken glass on the ground, causing a laceration to his left hand.

The employee was walking in the plant, going to measure Silo 58, when he stepped on an icy area, slipped and fell on the ground.

The employee was changing the hammer vavle on the south line. The valve spun and the employee reached out to grab it - it came to a stop against the pipe wedging the employees finger, causing a laceration to left index finger.

THE EMPLOYEE WAS GETTING ONTO A LOCOMOTIVE TO BRING IT BACK DOWN TO THE PLANT. THE EMPLOYEE LOST HIS FOOTING DUE TO LOOSE STONE; GRABBED THE LOCOMOTIVE RAIL AND FELT PAIN IN HIS LOWER BACK.

Employee was inspecting the Packhouse Incline Belt. Somehow the employee's glove got caught causing his hand to be caught between two rollers. The employee recieved an abraision to the top of his left hand.

THE EE WAS REMOVING CHECK VALVE FROM SILO 51 PURGE AIR LINE, WHEN CEMENT DUST CAME BACK INTO HIS FACE, UNDER HIS SAFETY GLASSES.

THE EE WAS ON TOP OF THE #1 MILL PULLING THE DOOR OUT WITH STRAPS ATTACHED. AS THE DOOR WAS BEING LIFTED BY THE CRANE, A BOLT ON THE DOOR CAUGHTON THE MILL. THE CRANE CONTINUED LIFTING, THE ST RAP STETCHED AND SNAPPED, AND CLEVIS RELEASED UNDER PRESSURE, STRIKING THE EE'S LEFT HAND.

WHILE BLOWING OUT THE SEPARATOR, THE EMPLOYEE GOT DUST/ FOREIGN BODY IN RIGHT EYE. NOTE: 8/21/03 WAS THE FIRST TIME THIS OFFICE WAS NOTIFIED OF INJURY.

THE EE WAS HELPING TWO OTHER EE WHO WERE COME A LONGING A LOADING SCOOP INTO A LOADER BUCKET. THE EE SAID THE SCOPE GOT CAUGHT ON THE BUCKET LIP. HE TRIED TO FREE THE SCOPE. WHEN HE DID, THE S COPE, WHICH STILL HAD TENSION ON IT, POPPED LOOSE AND CAUGHT HIS LEFT HAND POINTER FINGER BETWEEN THE BUCKET AND SCOPE.

THE EE WAS USING A 6 LB SLEDGE HAMMER TO POUND A COUPLING ON THE COMPRESSOR TO LOOSEN IT. THE EE MISSED THE BRASS SHAFT AND HIT THE SECOND KNUCKLE OF HIS MIDDLE FINGER ON THE LEFT HAND, CAUSING A CUT.

EE WAS WORKING NEAR HATCH COVER WHEN MERCHANT VESSEL CREW MEMBER CLOSED HATCH CAUSING THE EE TO BE TRAPPED THEN FORCING HIM INTO GETTING KNOCKED INTO HOLD.

THE EMPLOYEE HAD HOOKED THE LOCOMOTIVE TO TWO EMPTY RAIL CARS. HE STEPPED OFF THE LADDER OF THE RAIL CAR TO THROW THE SWITCH AT WHICH TIME HE EITHER STEPPED ON A STONE OR A RAILROAD TIE SPRAIN ING HIS LEFT ANKLE.

THE EE WAS LOCKING THE DOOR TO SECURE THE BLDG OFOR THE WEEKEND AS THE EE WAS CLOSING THE LEFT HANDED DOOR, HIS MIDDLE FINGER OF LEFT HAND (AT THE KNUCKLE) GOT CAUGHT BETWEEN THE DOOR STOP & THE METAL COVER OF THE DOOR KNOB NIPPING OFF THEEND OF HIS LEFT MIDDEL FINGER

WHILE PULLING PINS FROM FEEDER, EMPLOYEE LOST BALANCE, TRIPPED & FELL.

EE WAS WINTERIZING EQUIPMENT AND TRIPPED OVER A DRAIN PIPE. HE LOST HIS BALANCE AND STRUCK HIS LEFT ELBOW ON A MOTOR, RESULTING IN CONTUSION TO LEFT ELBOW.

CLEANING MUD OFF TRACKS OF DOZER WITH CROWBAR & A PIECE OF METAL WENT IN EYE.

EMPLOYEE WAS HELPING ANOTHER EMPLOYEE CLEAN OUT SPITZER TRAP EMPLOYEE TWISTED BACK WHILE SWINGING SLEDGE HAMMER

EMPLOYEE WAS REPAIRING FLEX CONDUIT ON TOP OF SLURRY PUMP HOUSE UNDER AIR LINE TO NORTH BASIN HE SLIPPED IN OIL SPILL TWISTING LOWER BACK & EXPERIENCED PAIN IN HIS LEFT LEG

EMPLOYEE WAS CUTTING CABLE TO CLINKER CRANE WHEN LIFTING CABLE INTO PLACE FELT A PULL IN LOWER LEFT GROIN AREA. SURGERY SCHEDULED 4-14-94.

MILLWRIGHTS WERE REMOVING PLASTIC BUCKETS FROM A REX COAL ELEVATOR AND COMPLETED JOB AT 12:00PM AT END OF JOB ELEVATOR ROTATED 360 DEGREES FOR FIRE INSPECTION (NORMAL PROCEDURE). AT 12:30PM AR EA FOUND IN FLAMES AND MALDEN-WEST CAMP FIRE DEPT. WAS NOTIFIED. FIRE DEPT. ON PROPERTY AT 12:55 PM AND FIRE EXTINGUISHED AT 1:40PM BY USE OF WATER AND FOAM. NO INJURIES REPORTED WITH MINIMAL

EE WAS INSTALLING COAL MILL ROTARY LOCK USING A PINCH BAR TO LIFT ROTARY LOCK PINCH BAR SLIPPED CAUSING RIGHT HAND TO HIT GUARD BRACKET REQUIRED 4 SUTURES.

EMPLOYEE WAS REMOVING A SUPPORT ROLLER FROM UNDER COOLER. HE PICKED IT UP 1 FOOT TO GET IT OUT OF THE DOOR.

INJURED WAS WALKING OUT OF KILN AND STEPPED INTO HOLE, FALLING FORWARD. INJURED'S LEFT HAND CAME INTO CONTACT WITH HOT CLINKDER CAUSING BURNS TO LEFT HAND. ALSO HOT CLINKER ENTERED INJURED'S L EFT SHOE, CAUSING BURN TO LEFT FOOT.

INJURED WAS IN A KNEELING POSITION ALLEGEDLY LIFTING FOLLOWER PLATE FOR 301J PUMP ESTIMATED WEIGHT 80 AT THE RAW MILL DISCHARGE END. HE STRAINED HIS LOWER BACK MUSCLE.

EE WAS CRAWLING OUT FROM UNDER T3 BELT. UPON STANDING, EE STRUCK HIS HEAD ON A RAIL SUPPORT.

HOOD SAFETY PROP FAILED TO LOCK. HOOD DROPPED ONTO RIGHT HAND, CRUSHING/PINCHING IMPAIRMENT TO FINGERS.

54730DESCENDING 6' LADDER AND SLIPPED CAUSING TWISTING OF LEFT ANKLE.

INJURED WAS BLOWING OUT AIRLINES ON SOUTH SLURERY BASIN AGITATOR. WHEN HE UNCOUPLED ADAPTER TO THE AIRLINE, THE 2.5 INCH PRESSURIZED WATER HOSE JERKED STRAIGHT OUT. INJURED WAS STRUCK IN THE M OUTH AREA.

EE WAS OPERATING 743 BOBCAT AND WAS ATTEMPTING TO PICK UP MATERIAL AT THE FEED END OF ROLL MILL. THE BUCKET CAME INTO CONTACT WITH HARD MATERIAL ON FLOOR AND THE 743 BOBCAT CAME TO A SUDDEN ST OP EE WAS FORCED FORWARD AND CAME IN CONTACT IN CONTACT WITH THE FOAM SAFETY BAR. ]

INJURED WAS COMING INTO CONFERENCE ROOM AND TRIPPED ON LEG OF CHAIR. HE FELL TO FLOOR, STRIKING HIS RIGHT HIP AND RIGHT ELBOW.

INJURED WAS SITTING ON A METAL GRATE 6 FOOT ABOVE WORK WITH 6" FLEX HOSE (SUPERSUCKER) WITH BROOM HANDLE EXTENSION. SUPERSUCKER HOSE SUCKED INTO PILE OF MATERIAL AND INJURED ATTEMPTED TO FREE 6" HOSE. WAS PUSHED BETWEEN HOSE AND GRATE.

EMPLOYEE ALLEGED HE WAS POKING HARD BUILD UP AND ICE OUT OF 301JA SLURRY PUMP WITH A STEEL ROD. HE ALLEGED THE BUILD UP LOOSENED AND THE ROD STRUCK HIS LEFT KNEE.

CONDITIONS INSIDE CRUSHER BUILDING- COOL, APPROX. 35-40 DEGREES FAHRENHEIT. EMPLOYEE WAS ASSISTING IN THE RIGGING OF A STEEL REPLACEMENT PART INSIDE A CHUTE. THE HOISTING EQUIPMENT HAD A TWIST IN THE CABLE. THE CABLE SPRUNG DURING THE EMPLOYEE'S ATTEMPT TO UNTWIST IT. IT KNOCKED HIM INTO THE CHUTE, 15-20 FT.

WHILE REMOVING LINERS FRM TERTIARY CRUSHER BUILDING A SAFETY CLIP ON THE COME-ALONG CAME LOOSE THE COME-ALONG TWISTED LOOSE FROM THE CABLE & FELL ON INJUREDS RIGHT THUMB

EE WAS ATTEMPTING TO HOIST UP A 6 INCH SUPERSUCKER HOSE TO THE TOP FLOOR OF THE DUST BUILDING. WHILE TRYING TO TIE OFF THE ROPE, IT SLIPPED THRU INJURED S HAND.

EMPLOYEE WAS RETURNING TO STAIRWAY AFTER PICKING UP CLINKER SAMPLE. INSTEAD OF STEPPING IN A PUDDLE OF WATER, HE STEPPED OVER THE PUDDLE. HE TWISTED HIS LEFT KNEE WHEN STEPPING UP IN ELEVATOR.

EMPLOYEE WAS STEPPING BACKWARDS PULLING A WET COLD FIRE HOSE OVER APPROX. 1 1/2" SLURRY UNDER A THE RAW MILL. AS HE WAS DOING THIS HE SLIPPED BUT DID OT FALL. HE FELT A SLIGHT PULL IN HIS BA CK MUSCLE. HAS BEEN OUT OF WORK SINCE 1-21-92.

EMPLOYEE STATED THAT HE WAS PICKING UP THE PLYWOOD COVER TO REMOVE ANY BUILDUP ON THE INTERIOR OF A SCREW HOUSING. WHILE HOLDING THE 3/4" PLYWOOD, EMPLOYEE ATTEMPTED TO REMOVE A BUILDUP ON CRO SSMEMBER. HE STATED THE PLYWOOD SLIPPED OUT OF HIS LEFT HAND AND CRASHED DOWN UPON HIS RIGHT WRIST.

EMPLOYEE HAD JUST STOPPED JACKHAMMERING HE RELEASED THE JACKHAMMER & STEPPED BACK HE LOST HIS BALANCER DUE TO A SMALL MOUMND ON THE FLOOR HE STARTED TO FALL & STRUCK HIS RT KNEE AGAINST A PROT RUDING METAL HINGE IN THE DOORWAY

THE KILN WAS BEING WASHED OUT.THE OPERATOR NOTICIED THE TORCH HAD COME LOOSE FROM THE CHAIN.WHEN HE PICKED THE STAND AND TORCH UP OVER A METAL LIP ON FLOOR IN KILN,HE FELT A PAIN IN HIS LOWER ABDOMEN AND GROIN AREA.

EMPLOYEE WAS CLOSING A VALVE ON SILO 35 WITH A 4' CAST IRON PIPE WRENCH. THE PIPE WRENCH SLIPPED OFF, AND EMPLOYEE FELT A SHARP PAIN IN HIS LOWER LEFT SIDE OF HIS BACK.

EMPL WAS ON TOP FLOOR OF DUST BUILDING CLEANING DAILY AREA. WHILE SHOVELING DRIED SLURRY UNDER VORTX TANK SHOVEL HIT OBJECT UNDER PILE. AS HE TRIED TO LIFT PIECE OF STEEL HE FELT PAIN IN LEFT SHOULDER.

EMPL WAS OPERATING D8 DOZER AT #6 QUARRY PUSHING TREES AND CLAY OFF AREA TO BE MINED. HE PUSHED LARGE TREE OVER ROOTS & ALL WITH BLADE UP. AS HE MOVED FORWARD DOZER CATS DROPPED INTO HOLE JERK ING OPERATOR SUDDELY AGAINST SEAT BELT HE WAS ALLEGEDLY WEARING. HE DID NOT SEEK MEDICAL CARE UNTIL 10/5/91,

EMPLOYEE WAS SITTING ON CUSHIONED CHAIR INSIDE THE CAB OF THE OVERHEAD CRANE HE HAD BEEN OPERATING THE CRANE APPROX 11/2HRS WENT TO HIS FOREMAN & STATED HIS BACK WAS BOTHERING HIM ASKED PERMIS SION TO GO TO HOSPITAL

EMPL WAS CLIMBING THROUGH CHAIN SECTION IN KILN WHEN HE ALLEGEDLY TRIPPED OVER CHAIN & HIT RIGHT FOOT ON ANOTHER PIECE OF CHAIN BRUISING IT. ON 8/14/91 WHILE WALKING UP STAIRS TO SLURRY BASIN HE ALLEGEDLY HIT RIGHT FOOT ON STEP BRUISING IT AGAIN IN SAME AREA.

EMPLOYEE WAS GOING TO CHANGE THE BEARING ON THE HEAD BOX SHAFT OF THE 214 BELT. AS HE PULLED THE OLD BEARING DOWN THE BELT TO REMOVE IT TO A PLATFORM, IT WENT UNDER AN ELECTRO-MAGNET. THE MA GNET PULLED THE BEARING UP, CRUSHING INJURED'S RIGHT HAND BETWEEN THE MAGNET AND THE BEARING.

EMPLOYEE WAS INSIDE THE CAB OF THE CRANE MOVING BACKWARDS WHEN A WHEEL BEARING BROKE ON THE CRANE SHEEL. THE CRANE DROPPED, CAUSING THE BRIDGE TO BOUNCE, WHICH JARRED EMPLOYEE'S BACK.

EMPLOYEE WAS WALKING AROUND UNDER RAW MILL, INSPECTING SLURRY PUMPS, SHE SLIPPED IN SLURRY, TWISTING NECK AND UPPER BACK.

EE WAS ASSISTING A MILLWRIGHT BY GRINDING ANGLE STEEL. WHILE GRINDING A PIECE OF STEEL CHIP DEFLECTED FROM THE SURFACE WENT UNDER HIS SAFETY GLASES AND ENTERED HISS RIGHT EYE.

EE WAS IN THE WASHROOM CLEANING THE SHOWER AREA. WHILE PULLING A MAT INTO SHOWER ROOM BACKWARDS HE TRIPPED ON A STEP AND FELL.

EE WAS USING A PRY BAR TO MOVE FROZEN STONE MATERIAL WEDGED IN SILO TO THE FEEDER BELT. LOOSE MATERIAL FELL INSIDE THE SILO, STRIKING THE PRY BAR. THIS CAUSED THE PRY BAR TO PIVOT WHICH RESULT ED IN A FINGER ON HIS LEFT HAND BEING SMASHED BETWEEN THE PRY BAR HANDLE AND THE STEEL FRAME OUTSIDE OF FEED BOX.

EMPL WAS RETRIEVING SHIEVES FROM CRUSHING ROOM OVEN. AS HE WAS WALKING HE TRIPPED OVER HOSE ATTACHED TO VALVE & FELL HITTING LEFT KNEE ON FLOOR.

AS EMPLOYEE DECENDED LADDER ON 988 FRONT END LOADER, HIS RIGHT FOOT SLIPPED OFF THE BOTTOM RUNG. HE LOST HIS GRIP ON THE LADDER AND HIS BALANCE. THIS CAUSED HIM TO TWIST HIS BODY, RESULTING IN INJURY TO HIS LOWER BACK.

EMPLOYEE WENT UPSTAIRS TO HIS LOCKER TO PICK UP RAGS FOR THE STOREROOM. ON HIS WAY BACK DOWN THE STAIRS, HE ALLEGEDLY SLIPPED AND FELT PAIN IN THE LEFT SIDE OF HIS BACK. NOTE: EMPLOYEE HAS A H ISTORY OF RE-OCCURRING BACK INJURIES.

EMPL WAS USING COMEALONG TO PULL & STRAIGHTEN T=3 BELT UPRIGHT BRACKET HOLDING CABLE TRAY. AFTER WELDING BOTTOM OF BRACKET TO FRAME COMEALONG HOOK SLIPPED OFF EAST BRACKET CUTTING INJURED ON F OREHEAD.

AFTER SHOVELING EXCESS ROCK & MUD MATERIAL FROM UNDER SHUTTLE BELT EMPL BEGAN TO NOTICE STIFFNESS & PAIN IN RIGHT SHOULDER. BY FOLLOWING MORNING HE WAS UNABLE TO LIFT RIGHT ARM MORE THAN 2".

WHILE ATTEMPTING TO CONNECT AN AIR HOSE TO A FITTING ON SILO AT 52D PLATFORM, EE STEPPED BACK OFF A SMALL PLATFORM. HE TRIPPED AND FELL BACKWARDS AND AS HE DID SO TRIED TO BREAK HIS FALL WITH HIS HANDS.

EMPL CLEANING BASEMENT OF NEW 1961 SILO.LIFTED SHOVEL FULL OF CEMENT INTO WHEEL BARROW FELT SOMETHING SNAP ON LOWER RIGHT SIDE OF BACK.

EE WAS ATTEMPTING TO DISLODGE HARDNEED BUILDUP OF MATERIAL ON THE INSIDE OF THE HEADBOX LOCATED AT THE TRANSFER THE ENTIRE BUILDUP BROKE LOOSE FROM THE SIDE OF THE HEADBOX. PINNING THE EE S LE FT LEG AGAINST THE WALL OF THE HEAD BOX.

INJURED WAS VISUALLY INSPECTING THE DRAG CHAIN ON THE DRAG CONVEYOR AFTER REPLACING PINS. DUST EMITTED FROM THE INSPECTION PORT DOORS AND BLEW INTO HIS RIGHT EYE.

EMPLOYEE WAS WALKING INTO SHOWER ARERA ND TRIPPED ON FLOOR MAT, BRUISIG TOE ON LEFT FOOT. HE THEN FELL AND STRUCK HIS LEFT ELBOW ON GROUND.

EMPLOYEE STEPPED OVER TRANSFER PIPE IN BASEMENT OF SILO. HE LOST HIS FOOTING AND SLIPPED TWISTING HIS BACK AS HE FELL TO THE GROUND.

EMPL WAS GOING TO REPLCE FEED BELT AT #2 FINISH MILL HE WAS GUIDING THE ROLL OF BELTING AS IT WAS BEING LOWERED BY FORKLIFT OPERATOR ONTO THE SUPPORT STAND BRACKETS THE ROLL OF BELTING SLID OF F THE FORKS OF FORKLIFT AND CAUGHT EMPLS R HAND BETWEEN PIPE AND BRACKET

EMPL WAS ATTEMPTING TO JUMP START THE STARTER UNIT OF DODGE PICKUP TRUCK BY BYPASSING THE SOLENOID UNDER THE TRUCK THE INJURED SUSTAINED 7 BROKEN RIBS WHEN THE PICKUP TRUCK MOVED BACKWARDS ROL LING ONTO HIS R SIDE AND CHEST

EMPL WAS REPAIRING WIPERS ON 988 LOADER HE WAS STANDING ON FRONT OF LOADER AND REACHED TO REMOVE WIPER ARM WHILE REACHING HE TWISTED HIS LOWER BACK RECURRING BACK INJURY

WHILE SHOVELIGN THE NORMALLY LOOSE MATERIAL FROM AROUND AND UNDER 215VA TAIL PULLEY IN THE CRUSHER BUILDING, EMPLOYEE STEPPED DOWN HARD ON THE SHOVEL WITH HIS RIGHT FOOT. THE SHOVEL HIT HARDEN ED MATERIAL WHICH CAUSED EMPLOYEE TO BRUISE THE ARCH OF HIS FOOT.

EMPLOYEE WAS UNLOADING BUCKET OF CLINKER IN CRANE SHED WHILE DUMPING THE BUCKET OF CLINKER THE WIND BLEW BACK AT THE LOADER CLINKER DUST BLEW INTO THE CAB & INTO EMPLOYEES LEFT EYE

EE WAS INSIDE CHUTE WELDING A LINER PLATE FROM 301 STONE FEEDER TO 307V BELT. A PIECE OF HOT SLAG LANDED ON HIS BOOT. IT BURNED A HOLE THROUGH THE BOOT AND SOCK AND CAUSED BURNS ON HIS LEFT FO OT.

EMPL CLEANING AREA OF PAD IN FRONT OF OIL HOUSE.DRUM OF WASTE OIL WAS LAYING ON ITS SIDE.EMPL SET IT UPRIGHT FELT SHARP PAIN IN HIS BACK.

DRIVING LOADED STONE TRUCK ON #3S QUARRY HAULAGE ROAD.EMPL TRIED TO AVOID 10" ROCK IN ROADWAY TO. FRONT TIRE STRUCK R0CK CAUSING STEERING WHEEL TO SPIN CATCHING EMPL THUMB & HANDS IN SPOKES OF STEERING WHEEL RESULTING INRT INDEX FINGER AND BRUISES TO BOTH HANDS & WRISTS.

EMPLOYEE WAS DESCENDING STAIRWAY BY WEST SIDE OF COOLER TO RREE TORCH LINE THAT HAD CAUGHT ON BOTTOM OF STEP. WHEN STARTING DOWN, HE SLIPPED ON A CLINKER BALL, HITTING HIS SHOULDER AND NECK ON STAIR RAIL AND POST.

EMPLOYEE WAS RUNNING A SMALL LATHE IN SHOP, MACHINING A KEEPER PIN FOR JIB ON GROVE CRANE. AS HE REOVED A BUILD-UP OF METAL CUTTINGS FROM AROUND THE TOOL POST, SEVERAL STRANDS OF CUTTINGS CAUG HT ON THE POST AND CUT HIS FINGER AS HE PULLED THEM.

WHILE REPLACING SINGLE CABLE ON BRIDGE CRANE, EMPLOYEE WAS LETTING SLACK OUT. WHEN CABLE STARTED GOINT TOO FAST, IT PULLED EMPLOYEE FORWARD, CAUSING HIM STRAIN ON HIS LOWER BACK.

WHILE INSTALLING FIRST OF THREE DRAIN LINE BRACKETS IN BETWEEN TWO PIPES BY #1 KILN PIER, EMPLOYEE WAS BENDING THE END OF BRACKET OVER WITH A PEEN HAMMER. WHEN HE SWUNG THE HAMMER IT HIT AN AD JACENT PIPE AND DEFLECTED OFF, STRIKING EMPLOYEE'S LEFT THUMB TIP.

EMPLOYEE WAS STANDING AT TOP OF STEPS TO #1 BELT TUNNEL. HE WAS PULLING ON FIREHOSE WHICH WAS FULL OF WATER, TO REMOVE SLACK FOR PERSON CLEANING TUNNEL.

COAL FEEDER IN RECLAIM TUNNEL, INJURED WAS ATTEMPTING TO PRY FROZEN CHUNK OF COAL CAUGHT BETWEEN VIB PAN AND SCAFFOLD SUPPORT PLATFORM. AS HE WAS PULLING DOWN ON END OF PRY BAR HE FELT A DISC OMFORT IN RIGHT SHOULDER AND UPPER ARM.

EMPLOYEE WAS JACKHAMMERING HARD MATERIAL BETWEEN 421-422 DRAGS WHILE STARTING A NEW CUT THE JACKHAMMER BIT VIBRATED OFF OF PILE HIS LEFT RING FINGERTIP SUSTAINED A CRUSH INJURY WHEN CAUGHT BET WEEN JACKHAMMER HANDLE & STEEL ANGLE

AFTER SHOVELING COAL COKE SPILL AT FEEDER #9 IN RECLAIM TUNNEL FOR APPROX. 5 HOURS, EMPLOYEE WENT TO CONTROL ROOM. WHEN DESCENDING STAIRS FROM CONTROL ROOM, HE ALLEGEDLY STARTED FEELING DIZZY. LATER HE FELT NAUSEOUS AND FELT LACK OF COORDINATION. DURING THE NEXT TWO DAYS THE SYMPTOMS REMAINED.

WHILE STRIPPING TOP OF MONUMENT AT #3 QUARRY, TRACK OF D-8 CLIMBED UP ON LARGE ROCKS AND DROPPED SUDDENLY, CAUSING JOLT TO EMPLOYEE.

EMPLOYEE DOES NOT KNOW. ASSUMES WHILE SHOVELING CLINKER DUST BURNED HIS BACK. HIS SUPERVISORS DISAGREE, SAYS NO HOT MATERIAL IN AREA. NO WITNESSES.

INJURED WAS ASSISTING M&E MOVE MOTOR FROM SHUTTLE BELT CARRIAGE-HE TOOK MOTOR, WHICH WAS APPROX. 5' OF OF FLOOR, AND WALKED APPROX. 10' AND THEN PLACED MOTOR ON GROUND. DID NOT FEEL PAIN UNTIL NEXT DAY. COMPANY WAS NOT AWARE OF WORK RELATED INJURY DISABILITY UNTIL JAN. 3, 1989.

WHILE CLEANING BOTTOM FLOOR OF CRUSHER BUILDING WITH SUPERSUCKER, DAMP MATERIAL PLUGGED 4" HOSE. EMPLOYEE LIFTED HOSE TO CLEAN OUT PLUGGED MATERIAL. EMPLOYEE ALLEGES HE EXPERIENCED PAIN IN HIS LOWER BACK THE NEXT DAY.

WHILE JACKHAMMERING CHUNKS OUT OF HI BLAINE FDDEER, HOT CLINKER DUST FELL ON WRTISTS AND BURNED SKIN. LATER BECAME INFECTED.

WHEN EMPLOYEE STARTED TOP GET OFF PACKING MACHINE, HIS FEET SLIPPED OFF THE PEDALS. AS HE GRABBED THE BAR ABOVE HIS HEAD, HE FELT A CATCH IN THE MIDDLE OF HIS BACK. EMPLOYEE EXPERIENCED INCREA SED AND CONTINUING PAIN SINCE THE INJURY AND SUBSEQUENTLY CHOSE TO GO TO A DOCTOR WHO PLACED HIM ON DISABILITY AS OF 3/15/89.

WHILE USING SUPER SUCKER WITH 4 IN SUCTION HOSE TO CLEAN CEMENT SPILL THE SUCTION PULLED THE HOES INTO THE CEMENT PILE CAUSING EMPLOYEE TO LOSE HIS BALANCE AND FALL INTO PILE OF CEMENT

WHILE STANDING ON NORTH END OF GREASY PIG PLATFORM, EMPLOYEE WAS USING A PIPE TOLOOSEN FLANGE JOINT ON HAMER VAVLVES. HIS HAND SLIPPED AND STRUCK SIDE OF HAND RAIL BY GREASY PIG SYSTEM. EMPLO EE ALLEGES ABSCESS IS RELATED TO INJURY.

WHILE OPENING HATCH COVER ON FLEX CEMENT CAR,EMPLOYEE FELT APAIN IN HIS UPPER LEFT ARM.

EMPLOYEE WAS PULLING ON ROPE TO DEADMAN TYPING UP CEMENT BOAT.

EMPL WAS STADING ON FENDER OF FRONT END LOADER FUELING MACHINE STEPPED ON TANK TO PUT CAP ON AND SLIPPED OFF TANK WAS COVERED WITH FUEL OIL

WHILE PERFORMING REPAIRS TO RAW MILL SLURRY PUMP EMPLOYEES FEET WERE SOAKED WITH WATER

WHILE DESCENDING SET OF STAIRS COMING DOWN FROM CRANE EMPLOYEE SLIPPED AND JAMMED HAND ON HOPPER

WHILE PICKING UP A NEWLY CUT PLATE THE PLATE SLIPPED LANDING ON INJUREDS FOREARM BURNING HIM

ALLEGEDLY RE-INJURED NECK WHILE DRIVING-JARRING CAUSED PAIN IN HIS NECK INJUIRED FELT A BURNING IN HIS NECK WHILE AT HOME WHEN HE TWISTED HIS NECK

WHILE BURNING BEARING FROM BEARING HOUSING AT 2ND COOLER DRIVE A HOT ROLLER POPPED OUT AS BEARING WAS EJECTED EMPLOYEE LOST FOOTING AND FELL TOWARDS FLYING OBJECT

WHILE ASCENDING STAIRS AT NORTH ENTRANCE OF RECLAIM TUNNEL EMPLOYEE ALLEGEDLY SLIPPED ON LOOSE MATERIAL AND FELL STRIKING CHEST ONSHOVEL BRUISING LEFT SIDE OF CHEST

WHILE WALKING IN RECLAIM TUNNEL ON WAY TO CHECK 214 TAIL PULLEY AND SUMP, EMPLOYEE STEPPED IN WET COAL PILE, SLIPPED AND TWISTED ANKLE AND FELL ON KNEE.

EMPLOYEE WAS ON TOP OF OLD SILO BY #29 LOOSENNG BOLT FROM LINE FLANGE WITH WRENCH. AS HE WAS BENDING OVER AND PULLING WRENCH ON BOLT HE FELT A SHARP PAIN IN HIS BACK AND THEN IN HIS RIGHT LE G.

WHILE CLIMBING INTO THE MASONARY DUST COLLECTOR TO REPAIR THE CLEANING SYSTEM, EMPLOYEE LOST HIS BALANCE. HE REACHED OUT TO BREAK HIS FALL AND HIT HIS HAND ON A PROTRUDING PIECE OF ANGLE IRON.

EMPL WAS DIGGING OUT COAL FROM BETWEEN TROUGHING ROLLERS AT #3 COAL BELT. AS HE WAS WALKING UP INCLINE WALKWAY HE ALLEGEDLY LOST HIS FOOTING & FELL BACK ON HIS ELBOWS & FELT PAIN IN HIS BACK

EMPLOYEE WAS USING A KNIFE TO REPLACE A WINDOW IN AURSLIDE ON LO BLAINE MILL THE SCREWDRIVER BLADE CLOSED CUTTING HIS LEFT INDEX FONGER THIS REQUIRED 6 STITCHES

WHILE OPERATING DOZER EMPLOYEE ALLEGES THAT HE REINJURED HIS LOWER BACK EMPLOYEE FELT STIFFNESS ON INITIAL DAY THE FOLLOWING DAY HIS BACK WAS VERY PAINFUL

WHILE IN THE PROCESS OF GREASING THE UPPER GREASE FITTING OF THE 988 FRONT END LOADER BUCKET, EMPLOYEE ATTEMPTED TO PULL HERSELF UP ONTO BUCKET WITH BOTH ARMS AND FELT PAIN IN UPPER BACK.

EMPLOYEE WAS CLEANING PARTS FRO REXNORD GEAR BOCX HE LIFTED THE GEAR INTO THE PARTS CLEANING TANK AND FELT SOMETHING POP IN HIS UPPER RT ARM

EMPLOYEE WAS WASHING OFF BUILDUP ON FLOOR WITH FIREHOSE USING RECYCLED SUMP WATER THIS TOOK PLACE AT #1 BELT TUNNEL

EMPLOYEE WAS LIFTING AND PLACING SCREW INTO CASING TROUTH (SCREW WAS ON SHOULDER) IN REXNORD.

EMPLOYEE WAS CLEANING OUT CLINKER IN NW COOLER ADRAG DUST CAME OFF OF COOLER GRATE OVERHEAD AND EMPLOYEE GOT CLINKER DUST IN HIS RT EYE

EMPLOYEE WENT TO MEASURE SILO IT WAS SNOWING HARD AND HE PRIPP TRIPPED ON A PALLET THAT WAS BURIED UNDER THE SNOW BY SILO 58 HE EXPERIENCED PAIN IN HIS LOWER B ACK ON LEFT SIDE

EMPLOYEE SLIPPE8 ON A PATCH OF ICE WHILE GETTING OUT OF TRUCK.

EMPLOYEE SLIPPE8 WHEN STEPPING OVER BENCH IN LOCKERROOM AFTER LEAVING SHOWER AND STRUCK BACKSIDE OF LEFT RIBS ON BENCH; HIT TAILBONE ON FLOOR.

EMPLOYEE WAS KN9ELING DOWN WHIOLE GRINDING ON DOOR SILL FOR NEW FOREMAN'S OFFICE.HE FELT A SHARP PAIN IN HIS LEFT SIDE.THIS IS A REOCCURING BACK INJURY.

EMP WAS SETTING3UP GROVE CRANE TO LIFT MOTOR O WEST KILN PIER. WHILE PUTTING WOOD BLOCK UNDER LIFTING PAD, HE HIT HIS FINGER ONMETAL LIFTING PAD ON GROVE CRANE

WHILE ATTEMPTIN1 TO READ VOLTAGE ACROSS THE FUSES OF THE SYMON CONE CRUSHER, THE METER EXPLODED AND A FIREBALL CAME FROM THE FUSES CAUSING 2ND DEGREE BUNRS ON EMPLOYEES HANDS AND ARMS

WHILE TRYING TO3UNPLUG SILO WITH AIR LANCE, EMPLOYEE REACHED FOR AIR VALVE. WHEN PULLING ON VALVE STEM, HE FELT A "POP" IN HIS RIGHT SHOULDER.

WHILE OPERATING3LOADER IN CLINKER PILE,IT TIPPED OVER ON IT'S SIDE,CAUSING INJURED TO HIT KNEE ON INSIDE OF CAB.

AFTER DISMOUNTI3G FRONTEND LOADER,INJURED WAS WLAKING IN PARKING AREA WHEN HE TRIPPED OVER A CABLE PROTRUDING FROM THE GROUND,INJURED TRIPPED TWISTING LEFT KNEE.THE ACCIDENT CAUSED A REINJURY TO THIS KNEE. 3

EMPLOYEE WAS D9SCENDING STAIRS NEAR RAW MILL WHEN HE ALLEDGEDLY TRIPPED TWISTING HIS RT ANKLE AND STRIKING THE BACK OF HIS RT HAND

EE WAS HOOKING 6P A PORTABLE AIR COMPRESSOR. WHILE RETURNING BACK TO COMPRESSOR EE HAD TO CLIMB OUT A WINDOW. WHILE DECENDING EE FELT SNAP TO LEFT KNEE. AS SHIFT PROGRESSED THE CONDITION GR EW WORSE. 3

SEE ATTACHED RE1ORT- CODERS NOTE NOTHING ATTACHED

WHILE HAND LOAD3NG BAGS TO COMPLETE 40 BAGS TO A PALLET, EMPLOYEE STRAINED BACK.

WHILE REMOVING 6ROKEN BAG FROM BELT LINE INJURED SLIPPED AND FELL AGAINST BELT LINE FRAMEWORK

WHILE LOOSENING3BOLTS IN FLANGE ON 8" CEMENT LINE TO SILO 51, EMPLOYEE FELT STRAIN IN BACK BETWEEN RIGHT SHOULDER BLADE AND RIGHT SPINE. (REOCCURRANCE OF INJURY- 2-27-85)

EMPLOYEE WAS UN1LUGGING CHUTE FROM STONE WITH A 6 FOOT CROWBAR.THE BAR SLIPPED AND THE EMPLOYEE LUNGED FORWARD,STRAINING BACK.

EMP WAS OFF DUT2 HE WAS TAKING HIS WASH UP SHOWER WHEN HE STEPPED OUT OF THE SHOWER AREA, STEPPED ON THE CONCRETE FLOOR, SLIPPED AND STRUCK HIS ELBOW ON THE STEP TO THE SHOWER

EMP WAS ASSIGN9D TO LOAD GRINDING MEDIA INTO THER AW MILL. BARREL WAS BEING LOWERED INTO POSITION BY THE OVERHEAD CRANE USING A SLING AROUND THE BARREL. WHILE ATTEMPTING TO ALIGN THE BARREL O NTO THE EDGE OF3THE LOADING HOPPER, THE BARREL STIPPED BACKWARDS TOWARD HIM. HE ATTEMPTED TO PREVENT THE BARREL FROM STRIKING HIM, HE PUSHED BARREL AWAY STRAINING HIS ARM

WHILE ATTEMPTIN1 TO CLEAN DOWN COAL CHUTE FROM THE COAL CONVEYOR TO THE COAL ELEVATOR WITH AN AIR LANCE, THE AIR LANCE WAS CUAHGT CAUSING EMPLOYEE TO STRIKE HIS FOREARM AGAINST THE ELEVATOR CA USING RESULTING3IN A LACERATION REQUIRING 5 SUTURES.

WHILE DISMOUNTI3G PICKUP TRUCK, EMPLOYEES FOOT SLIPPED OFF BACK BUMPER CAUSING HIM TO FALL STRICKING HIS ELBOW ON CONCRETE. FUEL OIL HAD BEEN SPILLED ON THE BED OF THE TRUCK WHICH EMPLOYEE ST EPPED IN WHICH 7AUSED SLIPPERY CONDITIONS.

WHILE REPLACING3LIGHT BULBS IN CEILING FIXTURE, AS EMPLOYEE DISMOUNTED STEP LADDER, HE MISSED THE BOTTOM STEP OF THE 4' LADDER, CAUSING HIM TO FALL TO THE FLOOR ON HIS BACK, STRIKING THE BACK OF HIS HEAD AN8 SHOULDER.

EMPL STEPPING U1 ON RAIL CAR WHEN HE STRUCK LEFT KNEE ON LADDER STEP.

WHILE UNPLUGGIN3THE LO BLAINE GYPSUM FEEDER A CHUNK BROKE LOOSE FALING ONTO THE RUNNING FEED BELT THE EMP ATTEMPTED TO REMOVE CHUNK FROM THE BELT AND EMP RAN DOWN INCLINED RAMP TWISTING RT KNE

000000041186031218 1804 WHILE DISMOUNTING TD-20 DOZER, EMPLOYEE'S FOOT SLIPPED OFF PUSH ARM COVERED WITH WET, MUDDY STONE, CAUSING A TWISTED LEFT KNEE.

EMPL CHANGING C3RCUIT BREAKER IN MOTOR CONTROL CENTER MCC 8. FAILED TO REMOVE STARTER BUCKET IN ORDER TO MAKE CHANGE AND REMOVED LINE SIDE WIRES FROM BREAKER.AS HE REMOVED 3RD HOT WIRE,SCREWDR IVER CONTACTED 2NE OF THE OTHER WIRES AND SHORTED,RESULTING IN ELECTRICAL BLOW UP IN HIS FACE.

JACKHAMMERING I3 KILNG COOLER PIECE OF REFRACTORY FELL FROM ABOVE STRIKING EMPL IN BACK OF NECK.

CLEARING FROZEN3MATERIAL FROM #5 RECLAIM FEEDER,RECLAIM BELT BEGAN RUNNING CAUSING EMPL TO HIT ARM AND ELBOW AS HE JUMPED CLEAR OF THE BELT.

CLEANING AND HO8ING DOWN SLURRY PUMP HOUSE,EMPL SLIPPED ON RAMP SPRAINING BACK BUSCLE.

WHILE CLEANING 2UT HEAD BOX CHUTE OF 215 VB BELT WITH A SHOVEL, EMPLOYEE CAUGHT BLADE OF SHOVEL IN MOVING BELT, FORCING THE SHOVEL HANDLE TO STRIKE RIGHT FOREARM

WHILE TRANSPORT3NG EMPTY COAL CARS ACROSS 9W TRAIN CAME TO A STOP THE CARS SHIFTED BACKWARDS CAUSING EMPLOYEE TO FALL OFF TRHE END CAR

WHILE CLOSING C2AL CAR DOOR BAR SLIPPED & STRUCK EMPLOYEE IN FOREHEAD & CHIPPING TOOTH

WHILE CHECKING GATE VALVE FOR HEAT, AIR CONDITIONER COVER DROPPED ON EMPLOYEE\S LEFT FOOT.

WHILE EMPTYING SWEEPER DUST HOPPER, SHAKING BACK & FORTH TO EMPTY MATERIAL, EMPLOYEE FELT PULL IN LOWER RIGHT SIDE OF BACK.

WHILE CUTTING OFF PIPE RAILING WITH PIPE CUTTER, EMPLOYEE HAND CAME UP UNDER SHARP END OF PIPE AND CUT BACK OF HAND.

WHILE ATTEMPTING TO LIFT A LOADING CHUTE BASKET OUT OF THE TRUCK FILL HOLE EMPLOYEE FELT SHARP PAIN IN LOWER BACK

WHILE DESCENDING STAIRWAY TO RECLAIM TUNNEL AT THE NORTH ENTRANCE,INJURED SLIPPED ON WET STAIRS CAUSING HIM TO FALL,SLIDING DOWN THE STAIRS ON HIS BACK SIDE STRIKING HIS LEFT LEG.RIGHT KNEE,RI GHT SHOULDER AND RIGHT ELBOW.

WHILE BACKING THE STONE TRUCK UP THE ACCESS ROAD WHILE CONSTRUCTING THE ROAD TO TO #7 QUARRY,THE REAR WHEELS OF THE TRUCK BACKED OVER THE SOFT FRESH SHOULDER OF THE ROAD,CAUSING THE TRUCK TO R TO ROLL DOWN THE EMBANKMENT.THE TRUCK ROLLED COMPLETELY OVER,RESTING ON THE WHEELS.

WHILE WALKING ON STAIRWAY FROM BURNER FLOOR TO EAST CAT WALK EMPLOYEE SLIPPED ON LOOSE MATERIAL.

WHILE WALKING DOWN INCLINED WALKWAY ON EAST SIDE OF HIGH BLAINE FINISH MILL, EMPLOYEE TWISTED RIGHT ANKLE ON LOOSE MATERIAL.

INJURED STATED HE WAS FITTING UP 2 PIECES OF STEEL WITH BOLTS AT A CONNECTION AND ONE PIEC E OF STEEL SLIPPED CRUSHING HIS LEFT RING FINGER BETWEEN THE TWO.

WHILE STACKING PACKAGE CEMTEN BAGS ONTO PALLET ON A FLATBED THE EMPLOYEE STEPPED INTO A HOLE IN THE FLATBET SURFACE CAUSING HIM TO FALL TWISTING HIS BACK.

WHILE PERFORMING ROUTINE INSPECTION AND CLEANUP OF PRIMARY CRUSHER COOLING SYSTEM WORK PLATFORM EMPLOYEE WAS DUMPING A WHEELBARROW LOST HIS FOOTING AND TWISTED HIS BACK WORK PLATFORM WAS COVER ED WITH ANTIFREEZE THAT HAD LEAKED OUT OF THE COOLING SYSTEM

WHILE CARRYING TRASH BAGS DOWN THE OFFICE STAIRS, EMPLOYEE SLIPPED, FALLING ABOUT FOUR STAIRS TO THE LANDING OF THE STAIRWAY.

WHILE REMOVING FOLLOWER PLATE OF PUMP WEIGHING ABOUT 125 LBS EMPLOYEE LOST CONTROL OF PLATE CAUSING IT TO DROP ABOUT 4" ONTO THE PUMP SHAFT. THE EMPLOYEES FINGER WAS CAUGHT BETWEEN THE SHAFT A ND THE FOLLOWER PLATE

WHILE GRINDING A POINT ON A 12" ROD, THE ROD CAMBECAME JAMMED IN WHEEL AND SUPPORT TABLE, CAUSING EMPLOYEES LEFT THUMB TO COME INTO CONTACT WITH THE GRINDING WHEEL

WHILE WELDING IN SHOP, IN A CROUCHED POSITION HOT SLAG GOT CAUGHT INSIDE LEFT HSHOE CAUSING A BURN ON EMPLOYEE ANKLE. THIS WOUND LATER BECAME INFECTED CAUSING LOST TIME.

WHILE POKING OUT A FEEDER IN THE MILL ROOM EMPLOYEE STRUCK BACK OF LEFT HAND ON OVERHEAD METAL PINCHING IT BETWEEN THE METAL AND THE BAR CAUSING A LACERATION

WHILE ATTEMPTING TO OPERATE THE ON/OFF SWITCH HANDLE ON THE ELECTRICAL BOX OF THE MAIN DISCONNECT OF THE TERTEARY CRUSHER EMP. CUT BACK OF FINGER ON THE LOCK OUT HASP REQUIRING SUTURES.

WHILE INSTALLING A HAMMER IN THE CRUSHER THE CABLE HOLDING THE HAMMER TWISTED CAUSING THE HAMMER TO SLIP OFF THE HOIST STRIKING EMPLOYEE ON RIGHT KNEE SHIN AND FOOT

WHILE USING A HAND HELD SURFACE GRINDER ON JD FAN HOUSING GRINDER STRUCK HARD MATERIAL CAUSING IT TO BOUNCE BACK STRIKING EMP LEFT KNEE CAUSING A DEEP LACERATION

WHILE CARRYING A SECTION OF BRICKING SCAFFOLD INTO KILN, EMPLOYEE STEPPED ONTO THE IRREGULAR SURFACE (COATING/REFRACTAORY) TWISTIANG KNEE. EMPLOYEE CONTINUED TO WORK AFTER THE ACCIDENT, A CYST DEVELOPED BEHING THE KNEE REQUIRING MEDICAL ATTENTION AND OPERATION. LOST TIME BEGAN 03-28-83