Malloy Bridge Plant 1201 Metal/Non-Metal

While installing tracks on a John Deere 750 Excavator, the 20' chain that was hooked from the bucket to the tracks to pull the track onto the track frame broke, striking the employee that was standing approximately five feet from the left track frame on the left forearm, hand and forehead. Employee was examined by physician and released to restricted duty.

Employee was repairing (pit) water pump, when he stepped away from pump to wave over the trackhoe operator. The employee fell, causing pain and swelling on right knee. He was placed on light duty, will follow-up with Doctor on 11-14-05.

EE was installing repaired lift cylinder on a 750 John Deere trackhoe he positioned a ladder against the boom of the excavator, as the cylinder was lifted up and close enough for him to reach, the ladder started to slide along the boom of the excavator. He then lost his balance, fell & struck the rear bumper of the service truck resulting in pain to left shoulder & neck.

EE WAS INSTALLING REPAIRED LIFT CYLINDER ON A 750 JOHN DEERE TRACKHOE HE POSITIONED A LADDER AGAINST THE BOOM OF THE EXCAVATOR AS THE CYLINDER WAS LIFTED UP AND CLOSE ENOUGH FOR HIM TO REACH THE LADDER STARTED TO SLIDE ALONG THE BOOM OF THE EXCAVATOR HE THEN LOST HIS BALANCE AND FELL AND STRUCK THE REAR BUMPER OF SERVICE TRK RESULTING IN PAIN TO LEFT SHOULDER

PICKING UP PIPE FROM RACK AT PIT 201 WASP NEST INSIDE PIPE.

GETTING ANTI-FREEZ FOR HAL TRUCK & TURNED THE MINERAL SPIRIT DEGREASER ON INSTEAD.

DRIVING A MOBILE EQUIPMENT LOST VCONTROL OF BRAKES & STEERING HIT A FENCE AND WENT DOWN A CREEK BOTTOM WHICH CAUSED BOUNCING & JERKING.

WHILE RETREIVING A DROPPED CLIPBOARD EE LOOKED DOWN AND STRUCK THE SIDE OF A LUFKIN END DUMP WAS TAKEN FOR A DRUG SCREEN AND HE STATED HE WASNOT HURT. WAS DISCHARGED FOR THIS INCIDENT. 8 DA YS LATER HE WET TO DR FOR BACK PAIN. IS OFF FOR BACK STRAIN

WAS TARPING TRAILER, WENT UNDER TRAILER TO GET TO OTHER SIDE OF TRAILER AND GOT POKED BY ROLLOVER TARP HANDLE IN NECK AREA, CAUSING PAIN.

EE WAS ADJUSTING BRAKES ON DRAGLINE WHEN HE FINISHED HE PROCEEDED TO STEP IN FRONT OF CAB AND SLIP AND FELL HITTING LEFT SIDE OF RIB CAGE

HE WAS EXITING TRUCK CAB WHEN LEFT FOOT SLIPPED CAUSING HIM TO HIT TAILBONE ON TRUCK CAB, BRUISING TAIL BONE.

EE WAS WALKING BESIDE DRAGLINE & STEPPED INTO A DRILL HOLE WITH HIS RT LEG & HIS LEFT KNEE BUCKLED

MECHANIC WAS LIFTING A BRAKE DRUM BRAKE DRUM WASTOO HEAVY THEREFORE HURTING HIS BACK

EMPLOYEE LEANED ACROSS STEERING WHEEL IN HER TRUCK AND STRAINED HER NECK/SHOULDER.

SWOLLEN RIGHT ELOBW WHEN HIT IT ON GUARDRAIL WHILE WALKING UP STAIRS.

EE STRAINED NECK WHILE LIFTING HEAVY STEEL.

EMPLOYEE WAS CHANGING A TIRE. WRENCH SLIPPED. EMPLOYE EHIT RIGHT ELBOW ON TRAILER.

DUE TO HORSEPLAY, WAS TALKING TO ANOTHER EMPLOYEE WHILE GETTING READY TO CALL OUT. ANOTHER EMPLOYEE WAS IN HIS CAR GOING HOME AND HE WAS BUMPED ON THE KNEE BY THE CAR.

STEPPED OFF TRAILER AND TWISTED ANKLE.

ATTEMPTING TO PUT SEATBELT ON WHILE DRIVING TRUCK. LOST CONTROL AND WENT OFF ROAD. BUMPED HEAD, ELBOW AND KNEE.

DRIVER WAS CLEANING BED OF DUMP TRUCK WITH SHOVEL & WATER HOSE. LOWER BACK STARTED HURTING SOME TIME LATER.

LIFTED TRUCK TIRE TO FIX FLAT. STRAINED SHOULDER & ARM.

LIFTING TRUCK HOOD TO CHECK UNDER HOOD.

SLIPPED ON PLATFORM AND FELL WHILE HELPING TO INSTALL A SCREEN ON PLANT.

LOST CONTROL OF TRUCK ON CURVE GOING TOO FAST WITH LOADED TRAILER.

GOING TOO FAST IN TRUCK LOADED WITH MATERIALS AND MISSED CURVE AND ROLLED TRUCK.

NO UNSAFE CONDITIONS.

EMPLOYEE WAS OILING 190-D DRAGLINE, WAS TURNING FAIR LEAD AND GOT PINKIE FINGER HUNG WHEN HE TRUNED IT AND IT CUT ABOUT ONE THIRD OF HIS PINKIE OFF. AMPUTATION TO FIRST JOINT PER CALL.

EMPLOYEE TWISTED AROUND TO ENTER TRUCK AND HE SNEEZED REAL BIG AND THIS CAUSED HIS TO GO TO HIS KNEES WITH HIS BACK HURTING.

EMPLOYEE SLIPPED THRU GRISSLY ON TOP OF HOPPER AND FELL INSIDE HOPPER PAETIALLY AND HURT HIS HIP.

EMPLOYEE WAS STEPPING OUT OF TRUCK HE STEPPED DOWN AND MISSED ON THE TRUCK AND HE TWISTED HIS LOWER BACK.

EMPLOYEE ADN ANOTHER EMPLOYEE WERE REPAIRING TRACKS ON A DRAGLINE, HE WAS PULLING ON THE TRACKS, ADN HE HURT HIS SHOULDER.

LIFTING ASSEMBLY FELT SHARP PAIN IN BACK.THAT NIGHT BACK BECAME TIGHT WITH PAIN.SAW DR NEXT DAY AND WAS PUT TO BED REST.PAIN CONTINUED TO INCREASE,SAW DR AND NO IMPROVEMTN WAS MADE.

EMPLOYEE FELL OFF OF THE LOADER AND HURT HIS ABCK.

EMPLOYEE WAS LOADING HOUSE ROLLER SHAFT INTO THE TRUCK WITH ANOTHER EMPLOYEE THE OTHER EMPLOYEE DROPPED HIS END THE SHAFT AND IT FELL ON I NAME S HAND.

EMP WA LOADING HOUSE ROLLER SHAFT INTO TRUCCK WIHT ANOTHER EMP OTHER EMP DROPED HIS END OF SHAFT AND IT FELL ON INJ HAND.

EMP WAS ADDING OIL TO GEAR DRIVE ON DRABGLINE HE WAS WALKING ON CATWALK OF MACHINE AND SLIPPED AN HIT KNEE ON HAND RAIL UPRIGHT.

EMPL WAS INSTALLING CUTTING EDGES ON LOADER ANDHE PULLED HIS BACK

EMPLOYEE WAS HE5PING MECHANIC WORK ON A TRUCK. THEY WERE TRYING TO REPLACE A BUSHING AT THE TIME OF THE ACCIDENT. I,NAME WAS WORKING TO LOOSEN THE BUSHING, HE PINCHED HIS HAND BETWEEN THE BALL OF THE TRUCK A3D THE REAR AXLE. THE TRUCK SHIFTED AND HIS HAND WAS CAUGHT, CRUSHING HIS THE LITTLE FINGER ON RT HAND.

EMPLOYEE WAS UN5OADING PEAT MOSS OFF TRUCK, THE BAGS WERE FROZEN TOGETHER, HE PULLED ON ONE TO RELEASE IT FROM ANOTHER BAG, HE THEN FELL OUT OF THE VAN & FELL ON HIS BACK.

EMPLOYEE WAS LI0TING PART OFF TRUCK, TURNED AROUND AND HURT BACK.

HELPING REPAIR 7RAILER HIT IN HEAD WITH PIN.

EMPL GETTING IN7O DUMP TRUCK AND HIT LEG AND KNEE.

EMPL PUTTING FU9L IN EQUIPMENT STEPPED DOWN SLIPPED AND SLID DOWN HITTING RIGHT KNEE AND LANDING ON GROUND.

EMPLOYEE WAS RE1AIRING TRUCK AND SOME TYPE OF FOREIGN MATTER GOT IN HIS EYE.

EMPLOYEE WAS WO9KING WITH PEAT MOSS AT PUG MILL HE SLIPPED AND CUT HIS FOOT ON A PIECE OF METAL

EMPLOYEE WAS WE5DING ON DRAGLINE METAL OBJECT FLEW IN HIS EYE (HELPING WELDER) EMPLOYEE DID NOT COMPLY WITH COMPANY SAFETY HE HAD NO GOGGLES ON

EMPLOYEE WORKIN1 AT WASHING PLANT WAS STUNG BY A YELLOWJACKET HE HAD A BAD ALLERGIC REACTION.

EMPLOYEE WAS WE5DING ON FRAME OF TRUCK HE GRABBED DOOR HANDLE TO STEP DOWN MISSED HE FELL BROKE LEFT WRIST.

EMPLOYEE WAS WORKIN GON AN AMERICAN DRAGLINE WHEN A BRACKET FELL ON HIS LEFT HAND HE PULLED HAND BACK IT CAUGHT ONLY HIS LEFT INDEX FINGER AND CUT IT PARTIALLY OFF