Wagner Quarries Metal/Non-Metal

Employee was checking their surroundings while reversing the loader. When they turned to look beside them, they lost feeling in their lower extremities.

While using a hammer to hit a punch, the employee missed striking left thumb. This resulted in 9 stitches and a fractured bone at the end of the thumb.

While stepping out of a pick up truck the employee twisted ankle. X-ray showed a broken 5th metatarsal bone on left ankle.

While pouring concrete, it started to rain. EE was on EE's hands and knees screening concrete and had concrete on EE's pants. The rain helped soak it into EE's pants and on EE's skin causing a rash.

Removing back of the plate from the Seco screen. Employee lost grip on the handle and the backer plate pitched EE's finger between the backer plate and the screen frame. The injury required sutures to close.

Employee was injured while the haul truck was being loaded. Their left shoulder/lower neck injured when they were jostled around in the truck cab while rocks were being loaded in the bed. Type of injury is yet to be determined, but appears to be a type of strain.

Employee was releasing a quick coupler on the pressure washer hose. Residual pressure in the hose caused it to whip when disconnected. The hose and fitting struck the employee in the face, cutting his lip.

The employee was removing an engine panel from a rubbertired front end loader when the panel slipped from his grasp. The employee tried to keep the panel from falling injuring his back.

Contributing conditions unknown-employee had heart attack while on the job.

Employee called supervisor on radio and said he needed to go to the hospital and have his neck checked. The injured employee told his supervisor that the loader operator had slammed his truck with a big rock, causing injury to his neck.

East 42" Conveyor went down due to being overloaded. EE had conveyor belt de-energized and was sitting on belt shoveling out "pant leg chute" that feeds conveyor. Employee reported, after shoveling, that his back was hurting. This was not a reportanle injury until Feb 6, 2006 when employee under went surgery and was taken off work.

GRINDING & CHIPPING OF RUSTY METAL. LEFT EYE GOT PIECE OF RUST IN THE EYE.

DISLOCATED RT PINKY FINGER WHILE CHECKING CHUTE AT SECO SCREEN.

HE WAS OBSERVING THE WELDER WHILE HOLDING A PLATE. HIS EYES RECEIVED A FLASH BURN.

WALKING DOWN STEPS AT PRIMARY CRUSHER, SLIPPED AND FRACTURED ANKLE.

ATTEMPTING TO REMOVE FLOOR JOIST. TRYING TO LOOSEN WITH HAMMER & ACCIDENTLY HIT HIS LEFT RING FINGER WITH HAMMER

FELL OFF TOP OF 2769 CAT HAUL TRUCK AND BROKE RIGHT WRIST. EE WAS ON TOP OF ENGINE COMPARTMENT AREA CHECKING FLUID LEVELS. WHILE MOVING TO THE DRIVER SIDE CAB DOOR, HIS RIGHT FOOT SLIPPED OUT FROM UNDER NEATH HIM AND HE FELL ON HIS RIGHT SIDE. THE FRACTURE WAS NOT A COMPOUND FRACTURE.

TIGHTENING BOLT ON SNUBBER PULLEY WITH 3/4" DRIVE RATCHET WHEN HE FELT A SHARP PAIN IN WRIST AREA. Y

EMPLOYEE WAS CLIMBING LADDER TO ENTER WHELDED LOADER TO PERFROM CUSTOMER LOADING ASSIGNMENT. ANOTHER EMPLOYEE GREASED THE BACKSIDE OF THE UPPER PART OF HAND LADDER. EMPLOYEE SLIPPED DOWN LA DDER TWISTING HIS BACK. NO WITNESS TO ACCIDENT.

CHANGING SHOES ON VSI CRUSHER, FELT PAIN IN LEFT ARM AND NUMBNESS. INJURY NOT REPORTED UNTIL 10-8-98. EE THOUGHT IT WOULD GO AWAY.

WHILE INSTALLING A CYLINDER ON A 773-B TRUCK, HE FELT PAIN IN HIS BACK, HE FELT IT WOULD GO AWAY, BUT IT DID NOT.

SLEDGE HAMMER HEAD BROKE OFF HANDLE, HIT IN MOUTH AREA. CUT TONGUE, REQUIRED STITCHES.

SPRAINED BACK MUSCLE WHILE LIFTING CRUSHER PARTS.

EXTENDED SHOVELING OF STONE & PULLED A MUSCLE IN RIB AREA

WHILE WORKING AROUND DRILL RIG & COMPRESSOR: SLIPPED ON ICE AND FELL. TWISTED BACK ON THE FALL. LOWER BACK AREA.

FUSE BLOWN AND ATTEMPTED TO CHANGE FUSE. 1ST AND2ND DEGREE BURNS TO FACE AND ARMS.

WHILE WORKING ON 980-C LOADER HE SLIPPED & HIT LEFT KNEE ON BATTERY BOX AREA. ABRASION TO KNEE &PIN.

WHILE CUTTING METAL ON BANDSAW, THE WORKPIECE GRABED & THE INJURED THUMB HIT THE BLADE. INJURED LEFT THUMB & NEEDED 6 STITCHES.

PULLED LOWER BACK BY LIFTING A CAT WALK WHILE DOING REPAIRS IN THE MILL.

CUTTING OUT STEEL BUCKET LINER IN LOADER BUCKET, STEEL LINER SPRUNG UP AND THREW HIM UP IN THE AIR. HE HIT HIS HEAD ON TOP, THEN CAME DOWN ON HIP ON EDGE OF BUCKET. BACK AND NECK PAIN AS A RES ULT.

CUTTING A BOLT WITH TORCH, A PIECE OF SLAG WENT BEHND GLASSES AND EMBEDDED IN THE LEFT EYE.

CLIMBING DOWN THE FEED PLATE OF CRUSHER TO ASSIST INT HE REMOVAL OF AN OVERSIZE STONE, SLIPPED AND FELL DOWN AND LEFT FOOT HIT THE ROTOR. LEFT NAKLE WAS FRACTURED.

WHILE PREPARING WORK AREA AT SECONDARY CRUSHER SLIPPED AND FELL ON LEFT SIDE, FRACTURED 7TH RIB ON LEFT SIDE.

WHILE USING CUTTING TORCH ON AWKWARD CUT, SPARK ROLLED INTO LEFT EAR, CUASING INFLAMMATION, NO PERMANENT DAMAGER TO EAR.

WALKING ON STACKING CONVEYOR AND TRIPPED PULLED MUSCLE IN LOWER RIGHT LEG CONVEYOR WAS ON GROUND. DID NOT FALL ANY DISTANCE.

WELDING ON WATER TRUCK TANK AND PIECE OF METAL FRAGMENT FLEW INTO LEFT EYE. COULD REMOVE IT WITH A CLOTH. WENT TO ER AT FIRELANDS HOSP. AND THEY REMOVE THE FRAGMENT. I WAS WEARING EYE PROTECT ION AND MASK. IT WAS A PIECE OF RUST.

RECEIVE WELDER'S FLASH TO BOTH EYES WHILE HOLDING UP STEEL FOR THE WELDER. I HAD SAFTY GLASSES ON. NO DAMAGE TO THE EYES. NO LOST TIME.

WINDY DAY, DRY CONDITIONS, WINDOW OF TRUCK OPEN. DUST BLEW INTO WINDOW AND LODGED INTO HIS EYE.

SLIPPED ON ICE AND FELL INJURING RIGHT SIDE OF BACK UNDER THE SHOULDER BLADE.

EMPLOYEE HAS ENGAGED IN LIFTING DYNAMITE AND EQUIPMENT AT QUARRY FOR 19 YEARS.

94559NG ACROSS THE SHELF SIDE-STEPPED MUD PUDDLE FOOT SLIPPED LANDED ON HARD ROCK SHELF ROCK INJURING LEFT KNEE

EMPLOYEE WAS STARTING EQUIPMENT AND AS HE WALKED ACROSS THE TOP SIDE OF THE TRUCK, HE FELL FROMT EH TRUCK LANDING ON HIS BACKSIDE HURTING HIS LOWER BACK. FALL RESULTED IN AC. CONTUSION/SPRAIN OF LOWER BACK.

EE WAS USING A HAMMER AND A DRIFT ALIGNING PLATES ON THE SURGE BY PASS HOPPER FOR ASSEMBLY WHILE HIGGINT THE DRIFT, A PIECE OF THE DRIFT WENT INTO THE EE S EYE.

EE OF LEFT HAND WHILE HEATING A STEERING KNUCKLE ON 6/773. EE WAS USING A RAG TO REMOVE HOT OIL FROM THE JOINT WHEN IT SPILLED OVER ONTO HIS LEFT THUMB.

WAS SETTING UP CHAIN FALL TO LIFT A 12 INCH PIPE INTO PLACE. WAS STANDING ON A CONVEYOR BELT AND LADDER AND WENT TO HOOK UP CHAINFALL. I MISSED THE CHAIN AND HAD A CHOICE EIGHTER FALL ON WHERE I WAS STANDING OR CATCH MYSELF AND DROP FALL. ILET THE CHAIN FALL ON TOP OF MY LEFT FOOT WT 40 LBS OF SOLID STEEL.

EMPLOYEE WAS CUTTING A PIECE OF PIPE (12"X70') TO BE USED AS A DRAIN TILE FOR THE ROAD LOCATED WEST OF THE 9B STOCK PILE. THE INJURY WAS CAUSEDBY EMPLOYEE RILLING THE PIPE TO COMPLETE CUTTING IT. INJURY RESULTED TO THE LEFT SIDE OF THE GROIN AREA.

JUMPED 5 - 6 FEET OFF LOADER INTO SOILD ROCK, CAUSING COMPRESSION INJURY TO LOWER SPINE.

PULLING ROLL OUT CHUTE CLOSED, HOOK ON COME-A-LONG SLIPPED OFF CAME BACK AND STRUCK HIM IN THE FACE BUSTING HIS NOSE AND BRUISING HIS EYE AND CHEEK.

WAS CHECKING SE7ONDARY MILL FOR BROKEN PIN, CHECKED ADJUSTER, PINS WERE BROKE AND SCREEN CAME BACK AND HIT HAND AND FOREARM AND SUFFERED LACERATIONS OF THE RIGHT AND FINGERS AND BROKEN BONE IN THE RIGHT FORE5RM.

WAS HELPING OT 6NHOOK TRAILER FROM VAN,WEIGHT ON TRAILER WAS HEAVY ON REAR,WHEN UNCOUPLED CAUSED TRAILER FROMT TO RAISE CATCHING HAND BETWEEN HITCH AND BUMPER.

WAS CLEANING RO5LERS AT DRIVE AND CAUGHT THE HAND CAUSING LACERATION OF THE RIGHT PALM.

WHEN HOIST UNHO2KED FROM SUPPORT, ATTACHING PART OF HOIST SLIPPED FROM EMPLOYEE S HANDS AND FELL HITTING EMPLOYEE ACROSS ARM AND HAND SPRAIN AND BRUISE OF RIGHT FOREARM AND HAND.

WHILE REMOVING ROCK FROM UNDER CONVEYOR BELT AT THE VIBRATOR IN THE MILL WITH A HOOK, THE HOOK SLIPPED FROM THE STONE LETTING HAND HIT AGAINST THE WALL CAUSING INJURY TO THE LEFT THUMB. X-RAYS SHOWED THE LEFT THUMB TO BE BROKEN.