Amrize Dundee Quarry Metal/Non-Metal

Two employees were removing and reinstalling a tail pulley bearing on a conveyor. There was no triggering incident or acute pain/injury, but one of the employees felt increasing pain in their left shoulder later that night and reported it to their Site Manager the next morning.

WAS RUNNING LOADER. WHEN FINISHED PARKED MACHINE. EXITED MACHINE AND PROCEEDED DOWN STEPS/LADDER USING THREE POINTS OF CONTACT. ONCE ON THE GROUND, TURNED TO WALK TOWARDS THE PLANT - SLIPPED ON ICE AND FELL TO THE GROUND. LANDED ON BUTT / LEFT SIDE.

Over the road trucking contract driver had been successfully loaded. Made his way to designated tarping area. While engaging manual tarping mechanism the handle malfunctioned causing truck driver to lose balance from bottom rung of ladder. Driver slipped and struck parts of his truck. Suffered lacerations to "rear end and hand". lacerations required sutures(stitches).

He was removing a boom cylinder pin and as he drove the pin out, the broken section started to fall towards his lower leg. He reached out to grab the pin and the broken edge of the pin cut his hand.

Employee was found laying face down, unresponsive, next to his pickup. The time of the accident is between 5:30 AM - 6:00 AM.

In the process of moving the water pump. The terminal end of the cable is attached to a concrete block. When the employee was attaching a second cable to a chain, the concrete block rolled over and onto employee's left leg.

EE WAS CHIPPING CLAY OFF JAW DIES W/BAR, BAR SLIPPED & HIT EE IN LITTLE TOE. BROKEN TOE RESULTED.

WORKING ON PRIMARY, TOGGLE SPRING WAS WEDGED. EE GRABBED IT TO FREE IT; IT RELEASED AND PINCHED HIS THUMB.

SHOVELING GRAVEL, FELT PAIN IN GROIN AREA, WENT TO EMERGENCY ROOM FOUND OUT HAVE A DIRECT HERNIA.

PULLING ON COMEALONG HANDLE-HANDLE BROKE AND HITEMPLOYEE IN THE NOSE.

WHILE POKING THE CONE A ROCK FLEW IN THE AIR AND HIT RIGHT WRIST.

WHILE LAYING ON BACK POUNDING WITH A SLUDGE HAMMER TO LOOSEN ROCKS, A LARGE ROCK FELL AND ROLLED OVER LEFT PINKY AND SMASHED IT.

A ROCK FELL OFF THE PRIMARY, STRIKING HIM IN THE HEAD, WHILE HE WAS SHOVELING. HE WAS LEFT WITH A SLIGHT CONCUSSION, AND 10 STITCHES.

WHILE WORKING ON CONVEYOR BELT HIS LEFT ARM GOT CAUGHT & PULLED MUSCLES.

WHILE STEPPING OFF THE LOADER, HE STEPPED ONTO SOME FROZEN DIRT AND TWISTED HIS ANKLE.

WHILE MOVING SOME WOOD, HE GOT HIT IN THE CHEST AND BRUISED SOME CARTILAGE.

WHILE HE WAS WORKING NEAR A CONVEYOR, A ROCK FELL OFF THE CONVEYOR BELT AND HIT HIM ON HIS BACK.

WHILE ASSISTING IN LIFTING A BARREL OF OIL, THE BARREL SLIPPED AND LANDED ON EE S LEFT FOOT.

WHILE WORKING ON MACHINERY, THE WRENCH HE WAS USING SLIPPED OFF A BOLT AN DFELL ON HIS FINGER.

MOVING STEEL FROM ONE PLACE OT ANOTHER WITH THE EQUIPMENT.

STONE FLEW FROM CRUSHER INTO EYE.

OPERATOR LOADING MATERIALS INTO PLANT

FOOT SLIPPED OFF DOZER TRACKS AND HIT LEFT KNEE VERY HARD.

DRILLING HOLES IN CONVEYOR AND BUMPED KNEE INTO CONVEYOR.

WHILE DURING MAINTENCE FOR THE SHOP, FELL AND INJURED KNEE. PART OF A BRANCH LODGED IN KNEE.

CHAINING DOWN A CONVEYOR ON THE LOWBOY. I,NAME SLIPPED AND GRABBED THE CONVEYOR TO STOP FALLING. PULLED BACK MUSCLES.