Carmeuse Lime Inc: 1 recorded fatality Metal/Non-Metal

EMPLOYEE WAS RE-INSTALLING TANK LOADING SPOUT WHEN DUST FELL FROM ABOVE AND GOT IN BOTH EYES.

WHILE LOADING BAGS OF LIME DUST ENTERED EMPLOYEES EYES.

EE STEPPED ON A STONE WHILE DECENDING STAIRS ANDSLIPPED, LANDING ON LEFT LEG.

WHILE RAKING IN PIT EMPLOYEE SLIPPED AND LANDED ON HIS KNEES ON THE STAIRS LEADING INTO PIT. NO RESTRICTIONS ORDERED BUT BECAME LOST TIME 1/15.

EMPLOYEE WAS REMOVING SCRAP STEEL FROM COOLER PIT WITHOUT THE USE OF PPE (GLOVES) AND SUSTAINED A CUT ON THE PALM OF HIS HAND. FOUR STITCHES WERE REQUIRED.

TRIPPED OVER I-BEAM LYING ON THE FLOOR.

EE WAS SPLICING A CONVEYOR BELT WHEN HE LOST HIS FOOTING AND FELL ABOUT 2' TO THE GROUND.

CUTTING A PIECE OF OVERHEAD METAL W/TORCH WHEN A NICKEL SIZE PIECE OF HOT SLAG FELL DOWN SLEEVE AND BURNED RIGHT WRIST.

EE WAS DESCENDING THE END LOADER BY WAY OF THE ATTACHED LADDER WHEN HE LOST HIS FOOTING AND FELL TO THE GROUND FROM ABOUT THE SECOND TO LAST RUNG, LANDING ON HIS BACKSIDE.

EE WAS SHOVELING LIME WHEN HE REPORTED FEELING PAIN IN HIS BACK.

EE WAS CLEANING OUT CASTABLES OUT OF VIBRATOR COOLER WHEN SOME OF IT FREED & SPLASHED UP IN HIS FACE. EE WAS WEARING GOGGLES.

EE WAS TIGHTENING A SHAFT WITH A SIX INCH PIPE WRENCH WHEN PIPE WRENCH SLIPPED AND FELL ON EE'S RIGHT SHOULDER.

EE WAS OILING #5 SCREEN WHEN LIMEDUST GOT INTO HIS R EYE. WAS WEARING SAFETY GLASSES.

EE WAS LOWERING NEW HEAD PULLEY ON #8 CONVEYOR INTO POSITION WHEN IT DROPPED AND HIS RIGHT HAND AND INDEX FINGER WAS PINCHED UNDER IT.

EE WAS WORKING BENT OVER, HARD HAT FELL OFF, EE STOOD UP TO PUT HARD HAT BACK ON, AND HIT HEAD ON STEEL BAR OVERHEAD.

EE STATES THAT WHILE LOADING TRUCKS, HE INHALED SOME LIMEDUST AND BEGAN TO FEEL IRRITATION AFTER HIS SHIFT.

EE WAS SHOVELING DUST AT #3 BELT WHEN HE STATES THAT HE FELT PAIN IN HIS LOWER BACK.

EMPLOYEE OPENED KILN DOOR & LIME DUST CAUSED CHEMICAL BURN TO LEFT EYE.

EMPLOYEE WAS WALKING THROUGH PLANT WHEN WIND BLEW LIMEDUST INTO EYES. NOTE: HAD SAFETY GLASSES ON.

EMPLOYEE WAS RAKING CHUNKS OF LIME OUT OF THE KILN WHEN DUST FLEW UP AND ONTO EMPLOYEE. NOTE: EMPLOYEE WAS WEARING SAFETY GLASSES & FACE SHIELD.

EE WAS ATTEMPTING TO PUT THE ID FAN TO FLUID DRIVE COUPLING BACK TOGETHER. HE WAS HOLDING THE COUPLING W/L HAND & HITTING IT W/ A HAMMER WHEN HE STRUCK HIS LEFT 4TH FINGER W/ THE HAMMER.

EMPLOYEE WAS LIFTING BUCKET OF BRICK SHIMS WHEN HE FELT PAIN IN STOMACH. NOTE: EMPLOYEE WENT TO CLINIC 1/9/02.

EMPLOYEE WAS WORKING ON DISCHARGE SEAL OF KILN WHEN LIME FELL OFF THE TOP OF KILN & WENT INTO HIS EYES. SAFETY GLASSES WERE WORN.

EMPLOYEE WAS COMING DOWN STAIRS FROM FLUEDUST SILO WHEN LIME BLEW INTO HIS RIGHT EYE.

DRIVE HOOKUP HOSE TRAILER WHICH LOOKS LIKE IT WAS HIT WITH HAMMER AND BEATEN ON, IN RESULT WHEN HE TRIED TO UNLOAD, HIS HOSE CAME APART IN RESULT LIME WENT ON HIM AND ALL OVER GROUND.

EMPLOYEE WAS ASSISTING IN CLEARING A BLOCKAGE IN THE MULTI COND PIPE AT THE REAR OF THE KILN WHEN LIME DUST BLEW UP UNDER HIS SAFETY GLASSES ANDINTO HIS EYES.

EMPLOYEE WAS FOUND LYING ON FLOOR UNRESPONSIVE, EMPLOYEE BECAME RESPONSIVE APPROX TEN MINUTES LATER AND STATED THAT HE HAD FALLEN DOWN THE SHIPPING STAIRS FROM ABOUT HALF WAY UP. HE STATED THAT ONLY HIS PREVIOUSLY INJURED LEG HAD PAIN.

EE WAS COMING DOWN STEPS AND DID NOT NOTICE BOTTOM STEP WAS MISSING, WHEN HE STEPPED DOWN HE JOLTED HIS BACK.

EMPLOYEE TOOK OFF SAFETY GLASSES TO WIPE SWEAT OFF OF THEM AND SWEAT/LIME DRIPPED INTO HIS EYES.

WHILE INSTALLING ON AIR CONDITIONER, IT TILTED AND SLID. EMPLOYEE GRABBED THE TOP AND THE METAL CUT HIS FINGER.

WHILE CUTTING WITH TORCH(WELDING) EE BURNED HIS EYES.

EMPLOYEE WAS WORKING IN COOLER AREA WHEN SOME LIME DUST FELL INTO HIS BOOTS CAUSING BURNS TO BOTH FEET.

EMPLOYEE WAS OFF LOADING 4'X 8' X 3/16" STEEL SHEETS W/FORK TRUCK, THE SLINGS SLIPPED OFF THE FORK TRUCK CAUSING PART OF THE STEEL PLATES TO LAND ON HIS LEFT FOOT.

EE WAS PUSHING STONE OFF BELT WITH LEGS AND PULLED MUSCLE IN RIGHT THIGH.

EMPLOYEE WAS INSPECTING REAR SEAL OF KILN WHEN WIND BLEW PIECE OF LIME INTO EYE. (WAS WEARING SAFETY GLASSES AT THE TIME).

EE WAS STEPPING OFF A PALLET WHEN HE STEPPED DOWN INTO A HOLE AND TWISTED HIS LEFT ANKLE.

EMPLOYEE WAS LIFTING 50 LB BAGS OF LIME HEN HE STRAINED HIS LOWER BACK.

EMPLOYEE WAS REACHING FOR AN OIL DIP STICK ON THE LOADER WHEN HE FELT A STRAIN IN HIS BACK.

EMPLOYEE STEPPED IN A GROUND HOLE WHILE WALKING AND TWISTED HIS ANKLE.

EMPLOYEE WAS USING CHAIN PULLS AND COME-A-LONGS TO CHANGE A ROLL IN THE COAL MILL WHEN HE FELT PAIN IN HIS SHOULDERS.

EMPLOYEE WAS CHANGING BAGS IN THE BAG HOUSE, AS HE PULLED A FULL BAG OF DUST OUT HE FELT PAIN IN HIS RIGHT KNEE.

EMPLOYEE WAS CHANGING BAGS IN COMPARTMENT #7 OF TE BAGHOUSE WHEN HE FELT A STRAIN IN HIS BACK.

EMPLOYEE WAS MOVING GRATES & SLIPPED & FELL ONTOSTEEL BEAM INJURING HIS BACK & LEFT SIDE.

EMPLOYEE WAS RAKING GRATE ON KILN WHEN LIME BLEWINTO HIS EYE. HE WAS WEARING SAFETY GLASSES.

EMPLOYEE WAS LIFTING OILING BUCKET WHEN HE FELT A PAIN IN HIS BACK.

EMPLOYEE WAS CHANGING VIBRATOR MOTOR WHEN THE WRENCH SLIPPED CAUSING HIS FINGER TO GET SMASHED.

EE STEPPED OFF A HI-LO TO SET UP BAGGING MACHINE AND HE SLIPPED ON WET FLOOR DUE TO RAINY CONDITIONS AND A LEAK IN THE ROOF. EE DID THE SPLITS CAUSING INJURY TO BOTH SIDES OF GROIN AREA.

EE WAS REPAIRING MACHINERY COAL MILL ROLL ASSEMBLY AND GOT HIS FINGER STUCK BETWEEN A BEARING AND BEARING SLEEVE.

EE WAS GETTING OFF OF A HI-LO AND TWISTED HIS BACK. THIS INJURY IS FELT TO BE RELATED TO A PRIOR REPORTED INJURY. FILED ON 10/5/95 FOR DATE OF INJURY ON 6/17/95. EE HAS HAD RECURRING BACK PROB LEMS SINCE THAT DATE. EE IS CURRENTLY OFF WORK AND HAS BEEN SINCE 5/17/99.

EE WAS STANIDNG ON A LADDER WITH HANDRAIL. HE TURNED TO STEP DOWN AND FELL OFF. EE HIT THE FLOOR INJURING LEFT HAND. EE WENT TO CLINIC AND WAS TOLD IT WAS A SPRAIN. FURTER XRAYS REVEALED IT W AS FRACTURED. EE WAS CASTED ON 5-17-99.

EE HIT A PIPE WITH HIS FINGER WHILE SWINGING A SLEDGE HAMMER.

EE WAS GUIDING A PIPE BEING RAISED WITH A HILO AND THE DRIVER GOT OFF THE HI-LO ALLOWING THE HILO TO MOVE FORWARD AND PINNING THE EE S RIGHT LEG BETWEEN THE HILO AND THE CATWALK.

EE WAS CLEANING NEAR CONVEYOR #3 AND DUST BLEW IN HIS EYE.

EE WAS LIFTING A GRATE RAKE AND FELT A STRAIN IN HIS BACK.

EE WAS WORKING ON THE SHIPPING BAGHOUSE AND TWISTED HIS KNEE WHILE INSPECTING AND CHANGING BAGHOUSE BAGS.

EMPLOYEE WAS RETRIEVING A SAMPLE WHILE BENDING OVER AND HER BACK WENT OUT.

EE WAS USING HI-LO TO LOAD BINS, STEPPED OFF W/OUT ENGAGING EMERGENCY BRAKE & HI-LO ROLLED. LEFT FOOT GOT CAUGHT BY WHEEL & WAS FRACTURED.

WHILE COLLECTING SAMPLES FOR ANALYSIS LIME DUST )FLOATING IN AIR) BYPASSED EYEWEAR AND IMPACTED IN LEFT EYE.

EMPLOYEE WAS RAKING GRATES CHUNKS OF LIME

EE TWISTED RT ANKLE WHILE WALKING. TRIPPED DOWN A SMALL SLOPE IN THE PAVEMENT.

EE PICKED UP SCOOP OUT OF KILN FOR SAMPLE. WAS NOT WEARING GLOVES.

EE WAS ON PLATFORM UNDER SILO TRYING TO GET MATERIAL TO FEED SO HE COULD LOAD TRUCK. HE FELL OFFPLATFORM & HIT RIGHT SHOULDER ON GROUND.

WINDBLOWN DEBRIS DUE TO HIGHER THAN NORMAL WINDS. EMPLOYEE GOT DEBRIS IN RIGHT EYE WHILE WALKIN GIN THE PLANT.

EMPLOYEE WAS WALKING THROUGH PLANT WHILE GRINDER WAS BEING OPERATED. MATERIAL FLEW INTO HIS EYE.

FORD-ROUGE COMPLEX HAD AN EXPLOSION WHICH CAUSED DUST TO FALL ON FIRING FLOOR. EMPLOYEE GOT DUST IN BOTH EYES.

WHILE EE WAS GETTING OUT OF LOADER, HE SLIPPED AND FELL ON HIS LEFT ELBOW, HITTING IT ON LADDER OF B-77 LOADER.

EMPLOYEE WAS PREPARING A LIME SAMPLE FOR TESTING IN THE DRAW ROOM WHEN HE FELT SOMETHING IN HIS EYE

EE WAS CLEANING PREHEATER AND DUST GOT INTO HIS LEFT EYE.

INSTALLING COOLER BUSSEL DOOR DOOR FELL ON HIS HEAD

EMPLOYEE SAYS HE HAS PAIN IN BACK FROM LIFTING A 400LB BAG

WHILE RAKING GRATES,LIME ENTERED EYE AROUND HIS GOGGLES.

WORKING ON DUCT BELOW GRATING, STEPPED UP TO GRATING LEVEL AND SLIPPED AND HIT GRATE.

CHUNK OF LIME FELL ON HIM NECK.

WHILE REMVING STEEL SCRAP SOME LIME DUST GOT IN HIS EYE.

LIME DUST IN RIGHT EYE.

EMPL WAS WASHING TRUCK AND GOT ACID ON HIS PANTS WHILE SLIDING DOWN

SLIPPED WHILE GOING UP LADDER.

THUMB WAS SMASHED WHILE ALIGNING PIPE. HIS KNEE GAVE OUT AND FELL.

DUST BLEW INTO EYE WHILE LOADING TRUCK.

WHILE LIFTING A CHUNK OF FROZEN STONE OFF #19 CONVEYOR BELT FINGER WAS SMASHED

SMASHED MIDDLE FINGER USING PRY BAR TO OPEN STEEL DOOR.

FELL & HIT HIS KNEE ON AN ANGLE IRON HAND RAIL

TRIPPED & FELL WHILE CUTTING A STEEL TANK TO KEEP FROM THE PLATE FALL ON HIM

LAYING AN OIL DRUM ON A FLAT BED TRUCK AND DRUM FELL ON FINGER.

WHILE PULLING ON A PIPE WRENCH WRENCH AND PIPE GAVE LOOSE STRIKING HIM ON THE SIDE OF HIS HEAD.

INSTALLING RETURN IDLERS ON FILED CONVEYOR.

INSTALLING A MOTOR AND TWISTED KNEE.

MOVING DRUMS 3

STEPPED OFF BOB7AT INTO WET LIME SLIPPED FELL ON LEFT KNEE

WHILE GETTING I3TO EUCLID,FIRE EXTENGUISHER FELL ONTO RIGHT KNEE.

GOT LINE DUST IN HIS RIGHT EYE WHEN HE TOOK OFF HIS GOGGLES.

EMPLOYEE SLIPPED ON STAIRWAY IN ROTARY KILN 1 COOLER PIT WET LIME AND OIL SPILL.

FELL WHILE CLIMBING UP PIT ON RK#1 PREHEATER TO BLOW OUT PREHEATER.

SLIPPED ON ICY HILL BY TUNNEL, TWISTED BACK. (DID NOT FALL).

FELL DOWN STEPS OF SHIPPING STATION, TWISTING KNEE. BONE FRAGMENTS FLOATING AROUND KNEE CAP RESULTING IN SURGERY.