FT MEADE MINE Metal/Non-Metal

Employee was walking through revolving frame, looked up into the port hole for leads and stepped into an uncovered hole fracturing several ribs on his (R) side and bruising his (L) hip. He is working restricted duty.

Employee was laying on his back while lifting a porta-power into place and felt a muscle pull in his back. He is working restricted duty.

EMPLOYEE WAS CHECKING PAN MOTOR OIL AND WALKED AROUND TO CRANK UP THE MACHINE. HIS FOOT SLIPPED AND HE FELL, TWISTING HIS LEFT ANKLE.

CHECKING OIL AND WATER IN RADIATOR IN D9 (DOZER).

GETTING OFF PAN AFTER FUELING IT, SLIPPED AND FELL.

EE WAS USING A SLEDGE HAMMER TO DRIVE A PIN THROUGH TWO BORES WHEN THE HAMMER HANDLE BROKE ALLOWING THE 20 LB SECTION OF THE HAMMER TO FLY OFF AND LAND ON HIS HAND.

ANOTHER EE WAS USING SLEDGE HAMMER TO PUT IN A BACK HOE PIN. HAMMER GLANCED OFF PIN KNOCKER, HIT EE IN MOUTH.

FOREIGN BODY IN CHIN.

EE WAS ON BERM ROAD IN HIS PERSONAL VEHICLE TRAVELING TOWARD THE PARKING LOT WHILE A 631 SCRAPER OPERATOR WAS LEAVING THE PARKING LOT. IT WAS 7:05 A.M., JUST BEFORE SUNRISE. BOTH VEHICLES HAD THEIR LIGHTS ON. THE SCRAPER OPERATOR REACHED UP TO TURN HIS WINDSHIELD WIPERS ON (OVERHEAD DASH). WHEN HE LOOKED BACK DOWN THE PAN STRUCK THE LEFT REAR PANEL OF THE TRUCK.

GOING TOO FAST DOWN RAMP, HIT HOLE IN ROAD.

EE WAS INSTALLING A BELLY PAN ON THE #631 PAN. BELLY PAN SLIPPED BETWEEN CHAIN AND THE PAN.

DRIVING DOWN HAUL ROAD, EQUIP HIT BUMP, BOUNCED HIM UP AND JAMMED HIS ELBOW ON ARM REST, DISLOCATED LEFT SHOULDER.

30" BAR SLIPPED WHILE EE WAS HOLDING BELLY PAN IN PLACE SO BOLTS COULD STARTED.

SOMEONE HAD TIED THE STEPS UP WITH ROPE, EMPLOYEE WAS PULLING HIMSELF UP TO GET ON THE EQUIPMENT, ROPE BROKE AND HE SLID, CAUGHT WITH ONE HAND AND PULLED SHOULDER.

EMPLOYEE WAS LIFTING SAMPLE BUCKET (IN EXCESS OF 50 LBS) TO DUMP MATRIX INTO THE MIXER FOR THE PILOT PLANT IN THE LAB. WHILE ATTEMPTING TO MOVE THE MATRIX BUCKET HE STRAINED HIS BACK.

EMPLOYEE PLACED A 5 GALLON BUCKET FILLED WITH MATRIX SAMPLE, WEIGHING APP 65 LBS ONTO THE SIDE OF THE MIXING TANK IN PREPARATION OF POURING THE SAMPLE INTO THE TANK. WHEN EMPLOYEE REACHED TO T URN ON WATER VALVE, BUCKET SLID OFF MIXER. EMPLOYEE GRABBED THE BUCKET AS IT WAS FALLING, RESULTING IN AN ACUTE SPRAIN OF RT PECTORALIS MUSCLE IN HIS CHEST.

EE WAS WALKING IN WATER PUTTING IN STAKES WHEN HE STEPPED INTO QUICK SAND MATERIAL. ANOTHER EE TRIED TO PULL HIM OUT, WHEN THEY PULLED HIM, THIS PUT A LOT OF PRESSURE ON HIS RIGHT KNEE AND ANK LE. STRAINED HIS KNEE AND ANKLE (SPRAIN).

HIT A HOLE IN HAUL ROAD.

HIT HOLE IN ROAD

EE ALLEGES STEPPING OUT OF TRUCK ONTO LOOSE GRAVEL AS HE STEPPED ONTO THE LOOSE GRAVEL HIS LEFT KNEE TWISTED. HE WAS SEEN BY ORTHOPAEDIC SURGEION & AFTER AN OBSERVATION PERIOD SURGERY WAS DOEN TO REPAIR TORN MENISCUS ON 10/8/99

THE DRIVER WAS PREPARING TO ENTER TRUCK COMPARTMENT WHEN HE CAUGHT HIS HAND IN DOOR HANDLE AND TWISTED AND SPRAINED HIS LEFT WRIST.

HIT HOLE IN HAUL ROAD, JERKED AND BOUNCED HIM.

STARTING PUTT PUTT MOTOR, IT BACKFIRED AND CAUGHT FIRE, BURNED LEFT ARM.

LIFTING 16 HP ENGINE.

HYRAULIC LINE BURST CAUSING A FLASH FIRE. FIRE CAME IN CAB & BURNED EE ON FACE & SIDE. HE ALSO JUMPED FROM EQUIPMENT AND CAUSED HIS BACK TO HURT

HIT HOLE IN HAUL ROAD CAUSING INJURY TO LEFT SHOULDER & NECK Y

EXCESSIVE SPEED COMING INTO THE PARKING LOT, HIT A HOLE CAUSING MACHINE TO JUMP OFF THE GROUND.

FUELING TRUCK, STEPPED ON PLASTIC, SLIPPED AND FELL.

TURNED OVER EQUIPMENT, ABRAISION - CONTUSION RIGHT KNEE.

OPERATING SCRAPER, HIT A WASH OUT IN ROAD, THREW HIM TO THE LEFT, HE WAS HOLDING TO STEERING WHEEL, JERKED HIM VERY HARD.

HIT WRIST ON THE TRANINING STAND ON SIDE OF 631 SCRAPER EE STANDING ON STAND FOR TRAINING OPERATOR HIT A HOLE AND BOUNCED HIM.

BOOM TRUCK REMOVING AN APRON OUT OF 631 SCRAPPER, PUTTING APRON OUT OF PAN AND IT WEDGED. APRON SLIPPED AND COUGHT THUMB.

ROLLING OUT LINER, STEPPED ON THE LINER WHICH WAS SLICK. FELL

WAS STILL A LITTLE DARK, STEPPED OFF OF 1250W DRAGLINE, MISSED STEP, FELL AND DISLOCATED LEFT SHOULDER.

BACKED OVER STUMP WHILE OPERATING EQUIPMENT, JARRED NECK.

CUTTING FLANGES ON ROLLER, A PIECE OF SLAG FLEW IN RIGHT EAR.

EE PUTTING ROLLER IN BACK OF TRUCK, BROKE RING FINGER.

TEE ALLEGES WHILE DOING ROUTINE WORK IN MINE AREA WIND BLEW FOREIGN OBJECT INT RIGHT EYE. INCIDENT BECAME RECORDABLE DUE TO RX GIVEN ON 2ND TRIP TO DOCTOR. 11/27/96

A WORKER WAS WORKING AT PULLING THE TAIL BEARING OFF A CLASSIFIER WHEN HE STRAINED A MUSCLE OR PULLED SOMETHING INTERNALLY. HE DID NOT MENTION THIS TO THE OTHER WORKERS OR SUPERVISOR. HE WORKE D THREE DAYS AFTER THIS THEN WHEN TO SEE A DOCTOR ON MONDAY 4 DAYS LATER.

EE'S WERE REPAIRING CONVEYOR WEIGHT PULLEY. WHILE PUMPING GREASE INTO BEARINGS, GREASE LINE BEING HANDED TO EE ENTERED RT EYE.

EMPLOYEE RECEIVED A SERIOUS ELECTRICAL SHOCK WHEN HE CAME IN CONTACT WITH A METAL WATER PIPE THAT HAD BECOME ENERGIZED BY AN UNINTENTIONAL GROUND FAULT.

EE ATTEMPTED TO WASH FEED OFF PIT WALL USING PILE GUN. WATER STREAM EITHER WENT OVER TOP OF BERM OR DEFLECTED OFF BERM & STRUCK DRAGLINE CAB WINDSHIELD. BROKEN GLASS STRUCK DRAGLINE OPERATOR C AUSING CUTS TO FACE, ARM AND THIGH.

EMPLOYEE WAS WORKING FROM A LADDER, DOING PIPE WORK USING A LARGE WRENCH AND AS HE ATTEMPTED TO BREAK THE BOLT HE FELT A STINGING SENSATION IN HIS LEFT GROIN AREA.

EMPLOYEE WAS ATTEMPTING TO USE A WATER HOSE TO WASH DOWN THE BACK OF A PIT CAR. EMPLOYEE STATES THAT THE WATER PRESSURE WAS TOO HIGH CAUSING HER TO LOSE HER GRIP ON THE HOSE. THE HOSE SLIPPED IN HER HAND UNTIL THE NOZZLE CLAMP STRUCK HER BETWEEN THE RIGHT FIRST AND SECOND FINGERS. LACERATION TO FINGER WEBBING REQUIRED 6 SUTURES.

EMPLOYEE WAS STANDING IN THE WALKWA NEXT TO A PIECE OF PIPE WHICH WAS SUPPORTED BY AN I BEAM WHICH WAS STICKING ABOUT 6" INTO THE WALKWAY. EMPLOYEE BEGAN TO WALK, HE TRIPPED OVER THE I BEAM AN D STRUCK HIS KNEE ON FLANGE BOLT.

EE WAS ATTEMPTING TO REMOVE TWO BOLTS FROM THE HYDRAULIC LINE WHILE IT WAS RUNNING, THEY WERE PLACING ANOTHER PIPE ON TOP OF THE LINE TO START THE NEXT WELL PREP. THE GASKET BLEW OUT AND SOMET HING HIT HIM ABOVE THE EYE.

EMP WAS WORKING ON 18" X 44" PUMP TO REMOVE THE FACE PLATE. WHILE USING A BAR TO REMOVE PLATE FROM PUMP, THE BAR SLIPPED AND EMP LOST HIS BALANCE CAUSING HIM TO TWIST HIS KNEE.

BUMPED TOP OF FOOT ON REBAR.

USING SLIDE HAMMER PULLER TO REMOVE SHEAVE FROM DRIVE GEAR BOX REPETITIVE BANGING OFF AND ON ALL DAY REPORTED PROBLEM WITH NUMBNESS IN FINGER HANDS NEXT DAY. SEEN BY PHYSCIAN NO TREATMENT. UNT IL FURTHER TESTING DONER DIAGNOSIS CUMULATIVE TRAUMA SURGERY WAS DONE BILATERALLY BOTH HANDS 9-22-95. RESTRICTED DUTY BEGAN THEN.

EMPLOYEE WAS CUTTING A PIECE OF FLAT BAR. HE WAS LINING UP SECOND PIECE FOR CUT AND IT SLIPPED OUT OF ALIGNMENT. AS HE REACHED TO RELIGN BAR, HIS FOOT ACCIDENTLY HIT THE START SWITCH AND HE AM PUTATED OUTER TIP OF RIGHT THUMB- DISTAL TIP.

EE WAS CHANING A ROLLER ON 32 A BELT UNDER DUMP CHUTE. THE ROLLER WAS STUCK AND HE WAS ATTEMPTING TO FORCE IT OUT WITH HIS HAND. THE ROLLER SLIPPED AND HAND HIT ASSEMBLY UNIT CAUSING LACERATIO N TO MIDDLE FINGER DISTAL ONTO LEFT HAND WITH TENDON DAMAGE.

SHE RECEIVED AN ELECTRIC SHOCK FROM A STARTER PUSH BUTTON WHEN A MOTOR SHE WAS TRYING TO START SHORTED TO GROUND. THE MOTOR FAILURE CAUSED AN ELECTRICAL FLASH.

EE WAS DRESSING A DRILL CHUCK BY FILING IT WHILE RUNNING IN A VISE.

EE WAS GRINDING AN AREA PRIOR TO WELDING & ACCIDENTLLY LAID HIS LEFT INDEX FINGER AGAINST THE WHEEL. HE DID NOT HAVE A GUARD ON THE GRINDER.

HELPING INSTALL STEEL CHUTE USING COMEALONG. COMEALONG MALFUNCTIONED CAUSING CHUTE TO DROP ONE FOOT. STRUCK EE AND KNOCKED HIM DOWN ON BEAM, BEFORE ANYONE COULD REACH HIM HE ROLLED OFF AND FEL L TEN FEET TO THE GROUND.

HELPING INSTALL STEEL CHUTE USING COMEALONG. COMEALONG MALFUNCTIONED CAUSING CHUTE TO DROP ONE FOOT. EE WAS INSIDE CHUTE AND LANDED ON FEET, THEN FELL TO THE GROUND LANDING ON RT SIDE.

EMPLOYEE WAS PRYING ON A SHAFT WITH A 5 FT. BAR USING SIDE PRESSURE. AT ONE POINT HE LEANED ALL HIS WEIGHT ON THE BAR AND THE BAR SLIPPED CAUSING HIM TO LOSE HIS BALANCE AND FALL AGAINST A DRA G DRUM SPIDER RIM WITH HIS LOWER RIB CAGE. THIS FRACTURED 2 RIBS, #8 AND #9. HE REPORTED THIS TO ME AT 12:30 PM. I TOOK HIM FOR X-RAYS. THE DR. SAID RETURN TO WORK THE NEXT DAY & HE DID.

EMPLOYEE WAS USING AN AIR IMPACT TO BREAK PIPE FLANGE AT THE TOP OF WASHER PLANT. AIR BLEM OUT FROM IMPACT GUN & DEBRIS BLEW OMTP JOS RT EYE. EMPLOYEE USED EMERGENCY EYE WASH AT SITE & THE FOL LOWING AM WITHOUT RELIEF. REPORTED TO MEDICAL DEPT FOR RT. & REFERRAL

EE WAS GRINDING & BECAME AWARE OF SOMETHING IN HIS RIGHT EYE. HE REPORTED THIS TO ME THE FOLLOWING MORNING AT 7 AM. I TOOK HIM TO A DOCTOR IMMEDIATELY. DR. SAID THEIR WAS A SMALL PIECE OF STEE L EMBEDDED IN THE RIGHT EYE. HE REMOVED IT & SAID THE EE COULD RETURN TO WORK IMMEDIATELY. THE EE WAS WEARING SAFETY GLASSES & A FACE SHIELD AT THE TIME OF THE ACCIDENT.

STEEL PARTICLE EMBEDDED IN EYE. INJURED WAS WEARING SAFETY GLASSES AND A FACE SHIELD. I NOTICED EE WEARING AN EYE PATCH 2-3-95 AFTERNOON. HE SAID IT WAS WELD FLASH. HE DID NOT WANT TO GO TO A DR. HE SAID IT WAS ALRIGHT. 2-8-95HE SAID IT STILL HURT. I TOOK HIM TO A DR IMMEDIATELY. HE RETURNED TO NORMAL WORK DUTY AFTER TREATMENT.

EE WAS PACKING #4 BOOSTER ON COMMON LINE. HE WAS WALKING AROUND END OF PUMP SLEA, LT FOOT AND ANKLE DROPPED INTO PULL RESESS (HOLE). FRACTURE OF BONE IN FT ANKLE RESULTED.

HAULING FILL DIR TTO DDUMP AREA, HIT A HOLD I THE HAUL ROAD.

EE STRUCK HIS RT. HAND ON SHARP EDGE OF METAL TABLE IN MAINTANANCE SHOP.

EE WALKED OVER STEPS AT 3 DRAGLINE. HE HAD BEEN CALLED TO CHECK A POSSIBLE OIL LEAK. EE SLIPPED ON GREASE ON FLOOR AND STRUCK HIS LF. KNEE ON FLOOR.

EE WAS BANDING A PIPE AND LACERATED LATERAL ASPECT OF RT. 5TH DIGIT ON THE BANDING MATERIAL. SUSTRES WERE REQUIRED TO CLOSE WOUND.

WORKING ON GRID OVERHEAD, TRIPPED AND FELL. WHEN STANDING UP HIT HEAD ON GRID AND JAMMED NECK.

PIECE OF METAL BLEW INTO LEFT EYE WHILE AIR ARCING-HAD WELDING HOOD ON AND SAFETY GLASSES ON AT TIME OF ACCIDENT.

EMPLOYEE WAS WORKING AT 32A CONVEYOR BELT. HE WAS PUTTING A VELT CLAMP IN PLACE. THE CLAMP SLIPPED AND JAMMED THE 3RD RIGHT FINGER INTO THE CONVEYOR FRAME. HE REPORTED INCIDENT TO CO-WORKER BU T NOT TO MEDICAL DEPT. OR SUPERVISOR TIL 10-20-94. REFERRED TO DR. FOR X RAYS AND EVALUATION AT THAT TIME.

OPERATING PAN FINGER WAS CAUGHT IN SEAT LEVER AND AMPUTATED END OF RING FINGER RIGHT HAND.

EMPLOYEE WAS BENT OVER IN A AREA WITH 4FT CLEARANCE A BROKEN SAMPLE CATCHER CAUSED EMPLOYEE TO BE IN THE AREA EMP WENT INTO THE AREA BENDING OVER INSTEAD OF STOOPING WHEN SHE STOOD BACK UP SHE STRUCK HER MID BACK ON A PIECE OF PIPE

SLIPPED & FELL STRIKING CHIN ON HANDRAIL WHILE ATTEMPTING TO REMOVE WEEDS FROM SPILLWAY GRATING ON HYDRALIC DITCH.

PULLED POWER TRAIN OUT OF 631 SCRAPER CAUSING SHOULDER STRAIN AND SPRAIN LEFT.

SLIPPED FOOT GOT CAUGHT BETWEEN PICKER TIRE AND FRAME WHILE BEING STEERED.

TRYING TO REMOVE PUMP PACKING TOOL RELEASED UNEXPECTEDLY CAUSING INJURED TO LOOSE BALANCE, STRAINING HER UPPER BACK.

EMPLOYTEE WAS PULLING HIMSELF FROM UNDER ONE OF THE VEHICLES ON A MECH'S CREEPER. HE TURNED TO HIS SIDE TO DISMOUNT THE CREEPER AND IN DOING SO HE TWISTED HIS KNEE. HE FELT LITTLE OR NO DISCOM FORT AFTER THE INITIAL TWINGE, BUT AS TIME PASSED HIS KNEE HAS PROGRESSIVELY GOTTEN SORER. SENT TO DOCTOR 6-23-94, RETURNED TO GUARDED DUTY, NOTEXPECTED TO LOOSE TIME.

EMPLOYEE HAD COMPLETED HIS INSPECTION OF 46A MIXER GEAR BOX AS HE WAS WALKING AWAY THE FLOOR GRATING GAVE WAY HE FELL THRU THE FLOOR CATCHING HIMSELF WITH HIS ARMS PREVENTING A FALL OF APPROX 14FT TO THE GROUND BELOW

MACHINE HIT A BUMP IN THE HAUL ROAD, HURTING HIS BACK.

EMPLOYEE THOUGHT SYSTEM WAS DOWN FOR MAINTENANCE ATTEMPTED TO REMOVE A PIPE PLUG FOR A WATER LINE/SYSTEM WAS ON THE WAY UP/PRESSURE BLEW THE PLUGE OUT HITTING HIM IN THE SHOULDER AND IMPREGNAT ING HIS FACE W/RUST & DEBRIS.

WAS ATTEMPTING TO UNPLUG A SEALING WATER SUPPLY LINE AT 3 BOOSTER. WHEN HE REMOVED THE PIPE PLUG FROM THE CHECK VALVE MUDDY WATER BLEW IN HIS FACE. THE PIPE WAS STILL UNDER PRESSURE BECAUSE TH E CHECK VALVE WOULD NOT ALLOW THE SYSTEM TO DRAIN. HE SUFFERED TRASH IN BOTH EYES BUT NO LASTING DAMAGE. THE DR FLUSHED HIS EYE OUT AND ADM. SOME DROPS. HE RETURN LAMAR TO REG DUTY SHOULD NOT

DOOR OPEN ON THE TRUCK WHILE MOVING TRIED TO CLOSE IT AND HIS FOOT GOT SLAMED IN IT.

TURNED ANKLE WHILE OILING IN BACK OF DRAGLINE LOST BALANCE WHEN MACHINE WAS SWINGING.

THE PAN WAS IN REVERSE TRYING TO HIT THE D9 WHILE HOOKING UP. HIT TOO HARD.

PAN SLID OFF IN BAR PIT, LEFT SIDE OF BODY HIT THE GROUND.

EE WAS CHANGING BRAKE PATCH LINE ON UPPER HOIST CHAIN. CAUGHT LEFT THUMB ON PINCH POINT WHEN PULLING LINK APART.

BUCKET ON MAN LIFT WEDGED BETWEEN SUPPORT BEAMS.INJURED ATTEMPTED TO FREE SAME BY LIFTING IT UP.THE BUCKET SURGED WHEN IT REALEASED CAUSING THE INJURED PARTY'S ARM TO BE PINCHED BEWTEEN A BEAM AND THE EDGE OF THE BUCKET.

INSTALLING CONDUIT UNDER PIPE RACK, TRASK FELL IN HIS EYE - UNABLE TO WASH OUT 3/7/94 REPORTED IRRITATION - SENT TO DR - RUST PIECE EXTRACTED.

TURNED ANKLE TRYING TO AVOID A ROOT/WALKING ON UNEVEN MINED GROUND.

TWISTED ANKLE DISMOUNTING A TRACTOR.

PAN OPERATOR WAS HAULING TAILING SAND. STARTED LOADING SCRAPER. PUSH CAT OPERATOR HIT PUSH BLOCK TOO HARD.

EE WAS REPLACING A HANDRAIL AT THE BENEFICIATIONPLANT, IN ORDER TO LINE UP THE ANGLE IRON HE REACHED AROUND A BEAM WITH A VALVE CHEATER, PULLINGAGAINST HIS CHEST. IMPROPER POSITION & NOT USING THE PROPER TOOL.

EE WAS HIT IN THE MOUTH WHILE ATTEMPTING TO DICONNECT A QUICK DISCONNECT HYDRALIC COUPLING. THE COUPLING WAS STUCK SO HE TAPPED THE COUPLING WITH A WRENCH & TUGGED ON THE HOSE, IT PARTED SUDDE NLY & STRUCK HIM IN THE MOUTH, CUTTING HIS LIP AND CHIPPING HIS TEETH.

STEPPED OFF D8N DOZER AND TWISTED RIGHT ANKLE.

HOLDING STEERING WHEEL TIGHT, WAS GOING OVER SEVERAL POT HOLES IN ROAD, FELT LIKE HE JAMED HIS LEFT WRIST.

GROIN PULL WHILE PULLING WRENCH/TIGHTENING BASE BOLTS ON 1250 HP ELECT. MOTOR.

EMPLOYEE WAS CHANGING OUT AN OXYGEN TANK ON THE CUTTING TORCH. HE PICKED UP THE TANK BY THE CAP. THE CAP CAME LOOSE AND HIT EMPLOYEE IN THE NOSE.

EMPLOYEE WAS BACKING A 1 X 5 BOLT OUT OF A PIPE FLANGE. THE BOLT WAS IN A BIND. HE WAS USING AN IMPACT. WHEN THE BOLT CAME OUT IT FLEW UP & HIT HIM IN THE FACE.

EMPLOYEE WAS HELPING A. C. CONTRACTOR REMOVE WINDOW A.C. FROM #F9 DRAGLINE/CONTRACTOR SLIPPED & EMPLOYEE TRIED TO SHOULDER ENTIRE LOAD. THE LOAD WAS TO HEAVY FOR ONE PERSON. HE FELT STRAIN AT THAT POINT BUT HOPED IT WOULD SUBSIDE.

SLIPPED WALKING I MUDDLY FLOOR.

AUTO ACCIDENT ON PUBLIC HIGHWAY/DRIVR OF OTHER TRUCK CHARGED WITH FAILURE TO YIELD RIGHT-OF-WAY.

AUTO ACCIDENT ON PUBLIC WHY/DRIVER OF OTHER TRUCK CHARGED WITH FAILURE TO YIELD RIGHT-OF-WAY.

EMPLOYEE WAS PULLING ON PIPE.

EMPLOYEE TRIED TO GET ON A BARGE TO PRIME A PUMP. THE BARGE HAD FLOATED AWAY FROM THE BANK. HE SLIPPED AND FELL INTO THE DITCH

LACERATION RIGHT THUMB/HIT BY HAMMER WHILE PEENING STEEL PIN.

EMPLOYEE CHALLANGED A TRESPASSER ON HIS ROUNDS. THE TRESPASSER HIT HIM WITH HIS FIST AND FLED THE PROPERTY.

EMPLOYEE WAS USING A KNIFE TO CUT A GASKET KNIFE SLIPPED STRIKING THE LITTLE FINGER ON HIS LEFT HAND

EMPLOYEE WAS FALGGING TRUCKS ACCROSS HWY & SOMETHING FLEW IN HIS EYE. HE WAS WEARING SAFETY GLASSES.

INJURED HAS LACERATION WITH EXTENSOR TENDON INJURY TO LEFT FINGER.

EE WAS USING 3/4 NYLON ROPE TO RELOCATE A FLATING DEWATERING PUMP. ONE END OF THE ROPE CAME LOOSE UNDER EXTREMEM PRESSURE AND STRUCK THE EE IN THE RIGHT JAW.

HE FELT PAIN IN LOWER BACK WHEN TURNING MACHINE.

EMPLOYEE WAS HOLDING A 3/8" DRILL IN HIS HAND WHILE ATTACHING A 3/4" HOLE SAW. THE SCREWDRIVER SLIPPED OFF THE SET SCREW AND STRUCK HIS PALM.

55061S ATTEMPTING TO REMOVE AN OBSTRUCTION METAL PLATE FROM THE DISCHARGE GATE OF A FEED BIN THE PLATE FELL FREE PINNING HIS RIGHT HAND BETWEEN METAL SUPPORT BEAM AND THE CONVEYOR BELT.

STEPPED DOWN FROM PLATFORM TWISTED L FOOT

(BELLY PAN FROM A D8N BULLDOZER- REMOVING BELLY PAN- LACERATION AND FRACTURE OF RING FINGER)>

STEPPED ON CABLES DRAWING FOOT AND ANKLE INTO PINCH POINT ON DRAGLINE SHEAVES. BROKE BONE LOWER LEG 6" ABOVE ANKLE.

EMPLOYEE WAS USING POCKETKNIFE TO TRIM SOME PLASTIC FROM THE EDGES OF A SHAKER SCREEN PANEL SO IT WOULD FIT INTO ITS SLOT.THE KNIFE SLIPPED STRIKING THE EMPLOYEE IN THE WEB OF HIS LEFT HAND.

HOLE IN ROAD WHILE DRIVING PAN

EMPL WAS DESCENDING STEPS FROM REAR END OF TROMMEL SCREEN & STEPPED ON SOME SPILLAGE ON FLOOR CAUSING HIM TO SLIP. HE STRUCK HEAD ON 4" CLEANOUT PIPE.

EMPLOYEE WAS MANEUVERING TWO 100' SECTIONS OF 18" PIPE INTO PLACE TO BOLT THEM TOGETHER-ONE OF WHICH WAS BALANCED IN THE AIR BY A DOZER.AS THE PIPES CAME TOGETHER HE GOT HIS RING FINGER CAUGHT BETWEEN THE TWO FLANGES.

EMPLOYEE WAS USING A 20LB SLEDGE HAMMER TO STRIKE A B&O TOOL IN AN EFFORT TO REMOVE A TOOTH FROM A 1260W BUCYRUS-ERIE DRAGLINE BUCKET A FRAGMENT OF METAL BROKE OFF THE TOOTH & IMBEDDED IN H IS RT UPPER THIGH

EMPLOYEE WAS USING A 20LB SLEDGE HAMMER TO DRIVEA NEW 2 7/8IN DRAG CABLE & WEDGE INTO THE SOCKET ONE BLOW OF THE HAMMER SLIPPED MASHING HIS LEFT INDEX FINGER BETWEEN THE CABLE & HAMMER HANDLE

EMPLOYEE WAS USING A WELDERS CHIPPING HAMMER IN AN ATTEMPT TO REMOVE A METAL BAND HOLDING A PIPE NIPPLE INSIDE A 1IN WATER HOSE A FRAGMENT OF METAL BROKE OFF THE TIP OF THE HAMMER & IMBEDDED I N HIS LEFT HAND

EMPLOYEE WAS CLIMBING THE STAIRS UP TO THE CAB OF A 1260-W B/3 DRAGLINE WHEN HIS FOOT SLIPPED OFF THE STEP CAUSING HIM TO SCRAPE HIS LEFT ANKLE ON THE STEP. HE DID NOT SEEK MEDICAL ATTENTION UNTIL 3-28-91 WHEN HE WAS ADMITTED TO THE HOSPITAL WITH TETNUS.

INDIVIDUAL WAS INSTALLING A ROLLER ON ROUGHER BELT, ROLLER SLIPPED OFF OPPOSITE BEAM CAUSING END OF ROLLER HE WAS HOLDING TO SMASH HIS HAND AGAINST A BEAM. SUSTAINED SMALL LACERATION IN RIGHT PALM, MASHED RIGHT THUMB AND WRIST.

STEPPING OFF BULLDOZER SLIPPED & HIT RIGHT LOWER BACK ALSO BRUISED BUTTOCKS.

INDIVIDUAL WAS WALKING ACROSS GRATING CARRYING A 20' PIECE OF 4X6 ANGLE IRON.GRATING GAVE WAY AND INDIVIDUAL FELL THROUGH AND ANGLE IRON CAME UP AND CUT HIS FACE.

EMPLOYEE WAS USING A 6" X62" PUTTY KNIFE TO PUT LUBRICATION ON THE OPEN GEARS OF A DEWATERING CLASSIFIER (SCREW CONVEYOR). THE PROTECTIVE GUARD WAS NOT IN PLACE AND THE PUTTY KNIFE AND EMPLOY EE'S GLOVE GOT CAUGHT IN THE GEAR PINCH POINT. THE EMPLOYEE LOST PART OF FOUR FINGERS AND PART OF THE THUMB ON THE RIGHT HAND.

INDIVIDUAL WAS CLIMBING UP SIDE OF CONVEYOR BELT WHEN HE SLIPPED AND FELL APPROXIMATELY 4 FT.SUSTAINED NECK INJURY.

EMPLOYEE WAS TO USE A 65 MOBILE CRANE TO REPLACE A SWING SHAFT IN A 1260-W BUEYRUS-ERIE DRAGLINEHE PULLED THE 650 LB HEADACHE BALL OUT OF HIS WAY & FELT A PAIN IN HIS LOWER STOMACH HE DID NOT REQUEST MEDICAL ATTENTIOJN UNTIL 01-14-91

DOWN IN HOLE OF DIRT CUTTING SHEET PILINGS HAD DIRT EXCAVATED AWAY FROM WHERE THEY WERE CUTTING ONE MAN WAS CUTTING & I NAME & EMPLOYEE I NAME WERE TALKING & NOT PAYING ATTENTION THEY WERE TOO CLOSE TO THE BANK SOMEONE YELLED AT THEM BUT THY DID NOT HEAR IN TIME DIRT FELL IN AROUND THEM ALMOST TO WAIST

WAS REPLACING A PIECE OF STRUCTUES STEEL WHEN HE STRUCK HIS HAND AGHAINST THE JAGGED EDGER OF A PIECE OF METAL THATY HAD NOT BEEN BURNED OFF SMOOTHLY. MONOR LACERATION TO MIDDLE FINGER OF LEF T HADN REQUIRING TWO SUTURES TO CLOSE.

LOADING TRACTOR BLADE ARM SLIPPED OFFF TAIL GATE FELL ON L FOOT

EMPL STARTED TO DESCEND FLIGHT OF STEPS DOWN INTO FEED RECLAIM TUNNEL. HER FEET SLIPPED IN SAND AS SHE STARTED DOWN STEPS CAUSING HER TO FALL. SHE ALSO FAILED TO PROPERLY USE HANDRAILS.

EMPL REPLACING PACKING IN 18" 427 G1W GATE VALVE.HAD USED COMBINATION WRENCH TO BLOCK UP PACKING GLAND WHICH SLIPPED ALLOWING PACKING GLAND TO FALL ACROSS BOTH HANDS.SHARP EDGE CAUSED 1" LACER ATION ON RIGHT INDEX FINGER.

EMPLOYEE WAS ATTEMPTING TO MANUALLY REPOSITION A 55 GAL. DRUM OF MINERAL SPIRITS ON THE DRUM RACK. ONE END OF THE DRUM SLIPPED OFF THE RACK PINCHING HIS FINGER BETWEEN THE DRUM AND DRUM RACK. HE SUFFERED A LACERATION AND SEVERED FLEXON TENDON. EMPLOYEE SHOULD HAVE USED A FORK LIFT SITTING NEARBY. EXPANDED METAL HAS BEEN WELDED BENEATH THE DRUMS TO PREVENT A REOCURRENCE.

HAD A D8N STUCK AND EMPLOYEE WAS HELPING ANOTHER OPERATOR BY PULLING ON THE CABLES TO GET THEM HOOKED UP WHEN HE PULLED A MUSCLE IN BACK OR LOWER PART OF NECK.

THE EMPLOYEE WAS USING A ACETYLENE TORCH TO REMOVE A 1 1/4" STEEL CABLE FROM TEH DRUM OF A WINCH ON A D-8 DOZER. AS THE CABLE BURNED IN TWO, THE TENSION ON THE COILDED CABLE WAS RELEASED CAUS ING THE CABLE TO UNCOIL QUICKLY, STRIKING THE EMPLOYEE ON THE LEFT THIGH.

BACKED OVER WINDROW AND HIT HARD ON THE BACK OF THE SEAT ON MACHINE.

REMOVING HEAVY SAFETY COVER GUARD TO FACILITATE REMOVAL OF PINION GEAR OF CLASSIFIER.INSTEAD OF REQ ASSISTANCE,EMPL REMOVED AND RELOCATED GEAR COVER BY HIMSELF.

EMPLOYEE WAS TIGHTENING LOCK NUT ON PUMP SHAFT WITH BJO WHEN METAL CHIP FLEW FROM BJO AND EMBEDDED IN LEFT ARM JUST ABOVE WRIST.

EMPLOYEE HAD OPENED PRIMING VALVE ON THE PIT CAR AND WAS LEAVING AREA WHEN SHE TRIPPED ON WASH H DOWN HOSE CAUSING HER TO FALL AGAINST VALVE

THE EMPLOYEE WAS UNHOOKING A DOZER WINCH CABLE FROM A SLED. THE WORN CABLE HAD SEVERAL BROKEN STRANDS WHICH CUT HIS HAND WHEN THE CABLE TWISTED IN HIS HAND.

THE INJURED WAS3ONE OF TWO EMPLOYEES WHO WERE LIFTING A DRILL RIG DRIVER-BLOCK 'HAMMER) WEIGHING APPROX. 300 LBS. OFF THE GROUND UP TO A PICKUP BED.

EMP WAS USING A36' STEEL PRY BAR TO CLOSE BOTTOM RAILROAD HOPPER CARS. THE PRY BAR SLIPPED CAUSING HIM TO FALL BACKWARDS ONTO HIS RIGHT FOOT

JUMPED OFF LOAD9R TRACTOR, LANDED ON LET FOOT, FRACTURING 3 BONES. EMPLOYEE WAS SERVICING EQUIPMENT.

HELPING TO SET 5 SUMP PUMP IN THE GROUND. CRANE WAS LIFTING A PIECE OF PIPE. THE PIPE KNOCKED I NAME OFF THE FOUNDATION AND HE FELL ON HIS SHOULDER SIDE AND BACK

EMPLOYEE WAS ST5NDING BETWEEN THE HANDRAIL AND A SUPPORTING I BEAM ON THE #11E SCREEN DECK AS A 966 CAT PAYLOADER WAS LIFTING A SCREEN SECTION IUP TO THE MEN ON THE SCREEN DECK THE PAYLOADER R OLLED FORWARD S7RIKING THE SCREEN PLATFORM AND PINNING THE EMPLOYEE AGAINST THE I BEAM

EMPL REMOVING L5RGE POWER PLUG IN TUB OF 1260 W.BUCYCRUS ERIE DRAGLINE IN PREPARATION FOR ELECTRICIANS TO CHANGE OUT 4160 V POWER CABLE.

EMPLOYEE WAS WO9KING ON #8A PUMP DISCHARGE HE WAS LIFTING A PIPE WITH A PORTABLE CABLE HOIST THE CABLE SLIPPED CAUSING THE END OF THE DISCHARGE PIPE TO STRIKE THE EMPLOYEES ARM

EMP WAS ASSISTI3G IN REPLACING THE DRAG ROPES ON THE #7 12COW DRAGLINE. HE WAS DOWN IN THE DRAG PIT. AFTER FINISHING WITH A 20 LB. SLEDGE HAMMER, HE HANDED IT UP TO A CO-WORKER TO USE ON THE DRAG DRUM. AFTE9 THE CO-WORKER HAD FINISHED WITH THE HAMMER HE SAT IT DOWN ON TOP OF THE DRA G DRUM IT FALL APPROX 4' STRIKING HIM ON HARD HAT, NEAR THE BACK OF THE SKULL

EMPLOYEE WAS PU7TING A COUPLING ON A PIECE OF ELECTRICAL CONDUIT THAT WAS BEING HELD IN A VISE THE VISE SLIPPED AS I TURNED THE COUPLING WITH A VISE CAUSING MY HAND TO HIT THE BENCH VISE

EMPLOYEE WAS BO5TING A FLANGE TOGETHER ON A 18 INCH MATRIX PIPE LINE HE HAD USED HIS BAR TO LINE THE HOLES AND HAD THROWN THE BAR INTO THE GROUND AS HE SQUATTED DOWN TO PUT BOLTS IN THE BOTTO M OF THE FLANGE3HE SAT DOWN ON THE PRY BAR

EMP WAS BOLTING3PIPE TOGETHER AT #8 WELL SET-UP AND PINCHED THE END OF T HE THIRD FINGER ON LEFT HAND BETWEEN TWO PIPE FLANGES

EMPLOYEE STEPPED OVER A 18 INCH DIAMETER PIPELIEN AGGRAVATING A PRE-EXISTING KNEE DISEASE HE DID NOT START LOSING TIME FROM WORK UNTIL 091485 SURGERY WAS SCHEDULED AT THIS TIME FOR 0-91885

HIT A ROCK ON FILL AREA. IT THREW ME INTO THE SIDE OF THE CAB CAUSING ME TO HIT THE SIDE OF NY HEAD.

EMPLOYEE WAS SITTING ON A COMBINATION BENCH SEAT TOOL BOX ON THE FIELDMANS CREW TRUCK AND THE TRUCK HIT A BUMP CAUSING THE HINGED LID TO OPEN AND SLAM QUICKLY SMASHING THE EMPLOYEES 3RD AND 4T H FINGERS OF HIS LEFT HAND

EMPLYEE WAS CUTTING A PIECE OF BELTING FOR USE OAS A SPLASH SHIELD FOR THE #1 TRUMBLE SCREEN USING A RAZOR KNIFE; THE KNIFE SLIPPED CUTTING THE PALM OF EMPLOYEE\S HAND.

EMPLOYEE WAS DUMPING A CUBIC FOOT SAMPLE CONTAINER INTO A 5 GALLON BUCKET & CAUGHT HIS FINGER BETWEEN THE CONTAINERS

EMPLOYEE WAS PINNED BETWEEN SERVICE TRUCK REAR END AND A REAR TIRE OF MOTOR GRADER.

EMPLOYEE TWISTED HIS KNEE WHILE WALKING ON UNEVEN GROUND NEAR 8 GUN CAR.

EMP WAS CLENAING A REAGENT CONDITIONER AND BUMPED THE BACK OF HIS LEFT HAND ON PIECE OF SHARP METAL CAUSING LACERATION ABOUT 2 1/2 HOURS LATER AS EMP WAS GRIPPING A STEAM HOSE THE TNEDON ON L LEFT MIDDLE FINGER SEPARATED DUE TO ORIGINAL INJURY

EMPLOYEE WAS BRINGING SAMPLDS OF FINE FEED DOWN THE STEP ON THE NORTH SIDE OF THE FLOAT PLANT HE SLIPPED ON A GREASY AREA ON THE FLOOR GRATING AND TWISTED HIS ANKLE

EMPLOYEE WAS ASSISTING IN LOWERING A CORE DRILLING BARREL INTO PLACE ON THE CORE BARREL RACK OF OUR DRILL RIG AS THE SENIOR MINE TECHNICIAN APPLIED THE BRAKE TO THE LIFTING DRUM THE LIFTING CA BLE SNAPPED CAUSING THE CORE LIFTING BALE TO ROLL-OUT OF THE SINGLE LOCKING SAFETY HOOK

EMPLOYEE GOT UP FROM HIS OPERATORS CHAIR ON #7 1260W DRAGLINE AS HE STEPPED TO HIS RT TO WALK AROUND RT SIDE OF OPERATOR CONSOLE HIS LEFT FOOT CAUGHT UNDER SWING PETALS THIS PITCHED HIM FORW ARD OUT THROUGH THE OPEN FRONT CAB WINDOW OVER THE CATWALK TO THE GROUND BELOW APPROX A 25FT FALL

EMPLOYEE WAS WORKING ON A VALVE OUTSIDE THE PLANT MAINTENANCE SHOP. IT SLIPPED AND ROLLED OVER THE MIDDLE FINGER OF HIS RIGHT HAND. LACERATION REQUIRED FOUR SUTURES.

SLIPPED ON WET STAIRS ON SOUTH SIDE OF FLOAT PLANT DURING RAIN STORM.BRUISED AND LACERATED THIGH OF RIGHT LEG -8 STITCHES TO CLOSE.